Product ID:TT-E-2124, 14193 GREEN, H4-014
MSDS Date:05/24/1988
FSC:8010
NIIN:01-136-5240
MSDS Number: BKJVH

CRAWFORD LABORATORIES, INC.

4165 SOUTH EMERALD AVENUE
CHICAGO, IL 60609
US

Emergency Phone: 312-433-1307

Info Phone: 312-376-7132

Cage: DO165

CRAWFORD LABORATORIES, INC

CHICAGO, IL 60609 US

Telephone: 312-376-7132

Cage: 5V430

XYLENES (O-,M-,P- ISOMERS) (SARA III)

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: 20-50%

OSHA PEL 100 PPM/150 STEL

ACGIH TLV: 100 PPM/150STEL;9192

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

METHYL ISOBUTYL KETONE (SARA III)

CAS: 108-10-1

RTECS: SA9275000

Fraction By Weight: 20-50%

OSHA PEL 100 PPM/75 STEL

ACGIH TLV: 50 PPM/75 STEL; 9293

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

DIISOBUTYL KETONE

CAS: 108-83-8

RTECS: MJ5775000

Fraction By Weight: <1%

OSHA PEL 50 PPM

ACGIH TLV: 25 PPM; 9293

PB AS LEAD CHROMATE

CAS: 7758-97-6

RTECS: GB2975000

Fraction By Weight: 1-5%

OSHA PEL .05 MG/M3

ACGIH TLV: .05 MG/M3

CHROMATE (AS CR03)

Fraction By Weight: 1-5%

OSHA PEL .1 MG/M3

ACGIH TLV: .1 MG/M3

VINYL RESIN (CONTAINS VINYL CHLORIDE, WHICH IS A

CAS: 25086-48-0

Fraction By Weight: 5-20%

VM&P NAPHTHA (LIGROINE)

CAS: 8032-32-4

RTECS: OI6180000

Fraction By Weight: <1%

OSHA PEL 300 PPM/400 STEL

ACGIH TLV: 300 PPM; 9192

C-TERT-AMYLPHENOL

CAS: 3279-27-4

Fraction By Weight: <1%

METHYL ALCOHOL (METHANOL) (SARA III)

CAS: 67-56-1

RTECS: PC1400000

Fraction By Weight: <1%

OSHA PEL S,200PPM/250STEL

ACGIH TLV: S,200PPM/250STEL; 93

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

2-BUTOXYETHANOL

CAS: 111-76-2

RTECS: KJ8575000

Fraction By Weight: <1%

OSHA PEL S, 50 PPM

ACGIH TLV: S, 25 PPM; 9293

PIGMENT DISPERSION-VIOLET (CONTAIN PROPYLENE GLYCOL

CAS: 108-65-6

Fraction By Weight: <1%

ACGIH TLV: 100 PPM

GLYCOL ETHER PM ACETATE (VAPOR PRESSURE 3.8 MM HG)

CAS: 108-65-6

RTECS: AI8925000

Fraction By Weight: <1%

TOLUENE (SARA III)

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: <1%

OSHA PEL 200 PPM/150 STEL

ACGIH TLV: 50 PPM; 9293

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:OVEREXPOSURE MAY PRODUCE ACUTE
TOXICITY, RESULTING IN HEADACHE, DIZZINESS, NAUSEA AND LOSS OF
CONSCIOUSNESS. EYE IRRITATION. IRRITATED MUCOUS MEMBRANES, VOMITING
DUE TO INGESTION. ASPIRATION TO LUNGS. DEFATTING AND DRYING OF THE
SKIN, IRRITATION & DERMATITIS. THIS PRODUCT HAS POTENTIAL FOR
SIGNIFICANT SKIN ABSORPTION.
Explanation of Carcinogenicity:CONTAINS VINYL CHLORIDE, WHICH IS A
CARCINOGEN.

First Aid:EYE: FLUSH W/WATER FOR 15 MIN, LIFT EYE LIDS. GET MEDICAL
AID. INHALE: REMOVE TO FRESH AIR, OXYGEN/ARTIFICIAL RESPIRATION AS
NEEDED. GET MEDICAL AID. KEEP VICTIM QUIET.NO LIQUIDS TO
UNCONSCIOUS PERSON . INGEST: IF VOMITING, KEEP HEAD BELOW HIPS. GET
MEDICAL AID. GIVE CONSCIOUS VICTIM LUKEWARM WATER. SKIN: FLUSH
W/WATER/REMOVE CONTAM CLOTHES. WASH W/SOAP & WATER. CLEAN
CLOTHES/SHOES BEFORE REUSE.

Flash Point Method:TOC
Flash Point:83.0F,28.3C
Lower Limits:0.8
Extinguishing Media:FOAM, CO2 OR DRY CHEMICAL.
Fire Fighting Procedures:WATER USED TO KEEP EXPOSED CONTAINERS COOL &
KEEP FLAMMABLE STRUCTURES WET. DO NOT ENTER FIRE AREA WITHOUT
PROPER PROTECTION-HAZARDOUS DECOMPOSITION MAY EXIST.
Unusual Fire/Explosion Hazard:WATER PRESSURE SPREADS FLAMMABLE LIQ
FIRE. SEALED CNTNRS MAY EXPLODE W/OVERHEAT. VAPORS MAY BE RELEASED
WHEN HEATED ABOVE FLASH POINT,MAY BURN/EXPLODE. VAPORS *

Spill Release Procedures:WARNING-FLAMMABLE. ELIMINATE ALL IGNITION
SOURCES. HANDLING EQUIPMENT MUST BE GROUNDED TO PREVENT SPARKING.
SOAK UP WITH AN ABSORBENT AND PLACE IN NON-LEAKING CONTAINERS. SEAL
TIGHTLY FOR PROPER DISPO SAL.

Handling and Storage Precautions:TREAT AS A HAZARDOUS-FLAMMABLE
MATERIAL. KNOW APPLICABLE DOT REGULATIONS BEFORE ATTEMPTING TO
TRANSPORT THIS MATERIAL.

Respiratory Protection:IMPORTANT-MUST PROVIDE ADEQUATE VENTILATION TO
MAINTAIN VAPOR CONCENTRATIONS BELOW THE ESTABLISHED TLV LIMIT AS
GIVEN BY OSHA. IN MORE CONFINED AREAS A NIOSH-MSHA APPROVED
RESPIRATOR EQUIPPED WITH ORG ANIC VAPOR CARTRIDGE SHOULD BE WORN.
Ventilation:MUST PROVIDE ADEQUATE VENTILATION.
Protective Gloves:USE RUBBER GLOVES.
Eye Protection:APPROVED SAFETY GOGGLES &/OR FACESHIELD
Other Protective Equipment:HAVE EYE BATH AVAILABLE
Supplemental Safety and Health
IF PEL'S ARE KNOWN, THEY ARE LISTED IN SECT II. WARNING-CARE MUST BE
TAKEN NOT TO EXCEED THE EXPOSURE LIMIT FOR THE LOWEST TLV SHOWN IN
SECTION II. WHEN IN DOUBT, WEAR AN APPROVED RESPIRATOR AND ORDER
AIR SAMPLING TESTS.

Boiling Pt:B.P. Text:148 TO 396F
Vapor Density:> THAN AIR
Evaporation Rate & Reference:0.93 (BU AC=1)
Appearance and Odor:THIN, BRIGHT GREEN LIQUID
Percent Volatiles by Volume:73.9

Stability Indicator/Materials to Avoid:YES
OXIDIZERS & STRONG ALKALIES. *HEAVIER THAN AIR,TRAVEL,IGNITE,FLASHBACK.
FINE SPRAYS COMBUSTIBLE AT TEMP BELOW FLASHPOINT
Stability Condition to Avoid:AVOID HEAT,SPARKS,OPEN FLAMES
&INCOMPATIBILITIES ABOVE HIGH TEMP, STRONG OXIDIZING CONDITIONS,
EXTEND CONTACT W/AIR/OXY.
Hazardous Decomposition Products:INCOMPLETE COMBUSTION FOR PRODUCTS
LIKE THIS MAY GENERATE HIGHLY POISONOUS CARBON MONOXIDE AND OTHER
TOXIC GASES.

Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH CURRENT
FEDERAL, STATE AND LOCAL REGULATIONS. CONTACT AN APPROVED DISPOSAL
FACILITY.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.