Product ID:02-GN-39 BASE,GREEN,EPOXY PRIMER
MSDS Date:01/01/1985
FSC:8010
NIIN:00K001211
Kit Part:Y
MSDS Number: BCCJY

DEFT CHEMICAL COATINGS

17451 VON KARMAN AVE
IRVINE, CA 92714-6205
US

Cage: EO418

DEFT, INC.

IRVINE, CA 92614 US

Telephone: 949-474-0400

Cage: 33461

METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 15.0%

OSHA PEL 200 PPM/300 STEL

ACGIH TLV: 200 PPM/300STEL 9192

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

2-METHOXYETHANOL (EGME) (SARA III)

CAS: 109-86-4

RTECS: KL5775000

Fraction By Weight: 5.0%

OSHA PEL S, 25 PPM

ACGIH TLV: S, 5 PPM; 9192

METHYL PROPYL KETONE (2-PENTANONE)

CAS: 107-87-9

RTECS: SA7875000

Fraction By Weight: 15.0%

OSHA PEL 200 PPM/250 STEL

ACGIH TLV: 200 PPM/250STEL;9192

N-BUTYL ALCOHOL (SARA III)

CAS: 71-36-3

RTECS: EO1400000

Fraction By Weight: 5.0%

OSHA PEL 100 PPM

ACGIH TLV: S, C 50 PPM; 9293

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

TOLUENE (SARA III)

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 5.0%

OSHA PEL 200 PPM/150 STEL

ACGIH TLV: 50 PPM; 9293

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

Effects of Overexposure:INH:CAUSES WEAKNESS,DIZZ;SKIN:IRRIT,MODRATE
PAIN,DERMITITIS/DEFATTG;EYES:SEV IRRIT;ING:GIIRRIT VOMT

First Aid:SKIN:WASH W.SOAP & H*2O EYES:FLUSH W. H*2O. INGESTED:GIVE 2
GLASSES H*2O; INDUCE VOMITING.CALL A PHYSICIAN. INHALE:REMOVE TO
FRESH AIR. GIVE CPR/OXYGEN IF NEED. KEEP WARM & QUIET. REMOVE
CONTAMINATED CLOTHING. IF UNCONS DO NOT ANTHING BY MOUTH.

Flash Point:26F(-3.3C)-TOC
Lower Limits:1.5
Upper Limits:11.5
Extinguishing Media:CO*2, FOAM, DRY CHEM.
Fire Fighting Procedures:USE SCBA W/FULL FACE PIECE OPRATD IN PRESSURE
DEMAND MODE.
Unusual Fire/Explosion Hazard:FLASHBACK ALONG VAPOR TRAIL MAY OCCUR;
VAP MAY EXPL. IF IGNITED IN AN ENCLOSED AREA.

Spill Release Procedures:ELIMINATE IGNITION SOURCES. STOP LEAK.
EVACUATE AREA.DO NOT TOUCH SPILLAGE. SM SPILL:ABSORB W. INERT
ABSORBENT. PLACE IN CLOSED CONTAINER. FLUSH AREA W. WATER. LG.
SPILL:DIKE AHEAD FOR LATER DISPOSAL. NOTIFY AUTHORITIES.

Handling and Storage Precautions:STORE UNDER CONTROLLD TEMPERATURE &
WHERE ADEQUATE FORCED VENTILATION IS PROVIDED;KEEP CONTNRS TIGHTLY
CLOSED;STORE IN LOW FIRE RISK STG AREA.
Other Precautions:STORAGE AREA & HANDLING EQUIP SHOULD BE FREE OF
SOURCE OF IGNITION/HEATD SURFACES;NEVER USE CUTTNG/WELDNG TORCH
ON/OR NEAR MATL CONTNRS.

Respiratory Protection:NIOSH/MSHA/MESA APPROVD SCBA
Ventilation:MECHANICAL VENT TO MAINTN EXPOS BELOW TLV(S)
Protective Gloves:IMPERVIOUS
Eye Protection:CHEM SPLASH GOGGLES
Other Protective Equipment:WEAR IMPERVIOUS CLOTHING/BOOTS.
Supplemental Safety and Health
MSDS DATED: 1/10/80: TWO PART KIT: SEE P/N IND "B" FOR CATLST: THIS IS
BASE: ALSO CONTAINS: STRONTIUM CHROMATE 5%: LEAD CHROMATE <5%,
MAGNESIUM ILICATE 20%, EPOXY RESIN 20% & XYLENE <5.0%. KEY1; J1.

Boiling Pt:B.P. Text:209F
Vapor Pres:UNK
Vapor Density:>1.0
Spec Gravity:1.2821
Evaporation Rate & Reference:<1(SLWR THAN ETHR)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:GREEN PAINT
Percent Volatiles by Volume:61.9

Stability Indicator/Materials to Avoid:YES
OXIDIZERS, CORROSIVES
Stability Condition to Avoid:HEAT, IGNITION SOURCES
Hazardous Decomposition Products:MAY FORM CO,CO*2 & VARIOUS
HYDROCARBONS.

Waste Disposal Methods:SM & LG SPL: DEPOSIT IN A TOXIC SUBT LANDFILL
IAW LOCAL, STATE & FED REGS.ELIM IGN SOURC OR INCIN ALONE OR AFTER
DISSOLV IT IN FLAMM SOLVENTS UNDER CONTRO CONDS USING A SCRUBBER &
AFTERBURNER IAW LO CAL,STATE & FED. REGS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.