Product ID:35-R-1 BASE,RED 11136,POLYURETHANE
MSDS Date:01/01/1985
FSC:8010
NIIN:00K001226
Kit Part:Y
MSDS Number: BCCLF

DEFT CHEMICAL COATINGS

17451 VON KARMAN AVE
IRVINE, CA 92714-6205
US

Cage: EO418

DEFT, INC.

IRVINE, CA 92614 US

Telephone: 949-474-0400

Cage: 33461

ETHYLENE GLYCOL ETHYL ETHER ACETATE;CELLOSOLVE ACETATE; CAS

RTECS: KK8225500

Fraction By Weight: 32.2%

ACGIH TLV: (S) 50 PPM

NAPHTHA (PETROLEUM SPIRITS OR BENZIN)

CAS: 8030-30-6

RTECS: SE7555000

Fraction By Weight: 8.6%

OSHA PEL 100 PPM

N-BUTYL ACETATE (SARA III)

CAS: 123-86-4

RTECS: AF7350000

Fraction By Weight: 9.4%

OSHA PEL 150 PPM/200 STEL

ACGIH TLV: 150 PPM/200STEL;9192

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

LEAD-MOLYBDENUM CHROMATE (OSHA PEL FOR LEAD FROM 29CFR

CAS: 12709-98-7

RTECS: OG1625000

Fraction By Weight: 10.4%

OSHA PEL 0.05 MG/M3 (PB)

ACGIH TLV: 0.05MG/M3(CR)A2;8990

POLYESTER RESIN *-SEE SUPPLEMENTAL DATA FOR OTHER HAZ

Fraction By Weight: 25.5%

Effects of Overexposure:EYES:MODERATE IRRIT;SKIN:POSSIBLE IRRIT BY
SOLVENTS;INH:SOLVENT VAPORS CAN CAUSE IRRIT OR NARCOSIS

First Aid:SKIN:WIPE OFF WITH A RAG THEN THOROUGH RINSINGW/MILD SOAP AND
WATER;EYES:FLUSH W/WATER FOR AT LEAST 10 MIN & CONSULT AN EYE
PHYSICIAN;INH:REMOVE TO FRESH AIR.GIVE CPR/OXYGEN IF NEEDED.

Flash Point:28F(-2.2C)-OC
Lower Limits:1.6
Extinguishing Media:CO*2,DRY CHE,FOAM
Fire Fighting Procedures:DO NOT USE H*2O STREAM ON FIRE.H*2O SPRAY/FOG
IS MORE EFFCTV
Unusual Fire/Explosion Hazard:CAUTION AGAINST APPLICATION TO HOT
SURVACES & USE IN AREASWHERE SOURCES OF IGNITION MAY BE PRESENT.

Spill Release Procedures:EVACUATE UPROTECTED PERSONS.ELIM IGN
SOURCES.USE SAFETY EQUIP.VENTLATE AREA.STOP LEAK W/O RISK.ABSORB SM
SPILL W/OIL ABSORBNG COMPD/RAGS;DIKE LG SPILL.PUMP LIQ TO SALVAGE
TANK. SHOVEL UP RESIDUE INTO COVRD DRUMS;PER MFR,FLUSH AREA W/LG
AMOH*2O

Handling and Storage Precautions:STORE IN COOL,DRY WELL VENTILATED,LOW
FIRE RISK AREA.KEEP CONTRS TIGHTLY CLOSED.KEEP AWAY FM HEAT,SPARK
OR OPENFLAME
Other Precautions:AVOID PROLONGED INHALATION OF MAP.PER MFR,WATER SPRAY
OR FOG CAN BE USED EFFECTIVELY ON FIRE AND TO COOL HEAT/FIRE
EXPOSED CONTNRS.

Respiratory Protection:GOOD VENTILATION IS NEEDED.HOWEVER USE NIOSH
APPRVD SCBA FOR PAINTS.
Ventilation:USE ADEQUATE VENTILATION USING EXHAUST FAN.
Protective Gloves:IMPERVIOUS
Eye Protection:SAFETY/CHEM GOGGLES.
Other Protective Equipment:AS REQD TO PREVENT PROLONGED OR REPEATED
CONTACT.
Supplemental Safety and Health
TWO PART KIT. THIS IS BASE. SEE P/N IND "B" FOR CTLST; ALSO CONTAINS:
AROMATIC HYDROCARBON (SC-150) 1.6%: 2.5% PERMANENT RED-2BMANGANESE,
0.6% QUINACRIDONE VIOLET, 1.0% THIXATROPE (1):*-SEE ADDL DATA- *.
KEY1: J1.

Boiling Pt:B.P. Text:175-332F
Vapor Pres:3.6
Vapor Density:>1.0
Spec Gravity:1.12
Evaporation Rate & Reference:<1(SLWR THAN ETHR)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:RED PAINT-ODOR PLEASANT-PUNGENT
Percent Volatiles by Volume:68.4

Stability Indicator/Materials to Avoid:YES
OXIDIZING & CORROSIVE MATERIALS
Stability Condition to Avoid:SOURCE OF IGN,SPARK,GEAT & OPEN FLAME

Waste Disposal Methods:KEEP IN CLOSED CONTRS PENDING DISPOSAL.MFR
SUGGESTED,DISPOSE IN TIGHTLY CLOSED CONTAINERS & FINALLY DISPOSE BY
SANITARY LANDFILL IAW APPLICABLE REGS;HANDLE & DISPOSE IN FULL
COMPLIANCE W/ALL FED,STATE ,&LOCAL REGULATIONS CONCERNING WASTE
DISPOSAL.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.