Product ID:H*2 OFF PAINT & VARNISH REMOVER
MSDS Date:08/01/1988
FSC:8010
NIIN:00N001341
MSDS Number: BCHPM

SAVOGRAN

NORWOOD, MA 02062
US

Emergency Phone: 617-762-5400

Info Phone: 617-762-5400

Cage: 86885

SAVOGRAN

130 NORWOOD, MA 02062 US

Telephone: 617-762-5400

Cage: 86885

INDUCE VOMITING. GET MED ATTN PROMPTLY.

RTECS: 9999999ZZ

MOVEMENT AT FLOOR LEVEL. DO NOT OPERATE

RTECS: 9999999ZZ

FLAMES/HEAT UNTIL ALL VAPORS (ODORS) ARE GONE.

RTECS: 9999999ZZ

BURN WIPING MATL W/SLUDGE IN APPRVD INCIN

RTECS: 9999999ZZ

BE ADEQUATELY VENTD AT FLOOR LEVEL. PERS MUST

RTECS: 9999999ZZ

NIOSH/MSHA APPRVD POS PRESS, SCBA W/FULL FACE PIECE

RTECS: 9999999ZZ

OBSERVER MUST NOT ENTER HAZ AREA

RTECS: 9999999ZZ

EXTREME HEAT. NEVER USE INTERNAL GAS/AIR PRESS TO

RTECS: 9999999ZZ

PROD RESIDUES. ALL PRECS GIVEN MUST BE OBSERVED

RTECS: 9999999ZZ

BE COMPLETELY DRAINED BEFORE DISP. IF POSS GIVE TO

RTECS: 9999999ZZ

TORCHES ON/NEAR CONTAINERS (EMPTY/FULL) BECAUSE

RTECS: 9999999ZZ

PRESSURE MODE IS ADVISED.

RTECS: 9999999ZZ

FRESH AIR MOVEMENT AT FLOOR LEVEL BY NORMAL CROSS

RTECS: 9999999ZZ

METHANE, DICHLORO-; (METHYLENE CHLORIDE) (SARA III)

CAS: 75-09-2

RTECS: PA8050000

Fraction By Weight: >80%

OSHA PEL 500 PPM, C; 1000

ACGIH TLV: 50 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

METHANOL; (METHYL ALCOHOL) (SARA III)

CAS: 67-56-1

RTECS: PC1400000

Fraction By Weight: <10%

OSHA PEL S,200PPM/250STEL

ACGIH TLV: S,200PPM/250STEL; 93

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

TOLUENE; (TOLUOL) (SARA III)

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: <3%

OSHA PEL 200 PPM/150 STEL

ACGIH TLV: 50 PPM; 9293

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

PARAFFIN; (PARAFFIN WAX)

CAS: 8002-74-2

RTECS: RV0350000

Fraction By Weight: <2%

OSHA PEL 2 MG/M3 (FUME)

ACGIH TLV: 2 MG/M3 (FUME)

ASPIR OF MATL INTO LUNGS CAN CAUSE CHEM

RTECS: 9999999ZZ

INTENTIONAL

RTECS: 9999999ZZ

HARMFUL/FATAL. RPTS HAVE ASSOC RPTD/PRLGND OVEREXP TO

RTECS: 9999999ZZ

EXCESSIVE EXPOS MAY CAUSE CARBOXYHEMOGLOBINEMIA &

RTECS: 9999999ZZ

ALLERGY DEVELOP (BRTHG DFCLTY/EYE ITCHING/PRLNGD

RTECS: 9999999ZZ

DRINKING ALCOHOL

RTECS: 9999999ZZ

CAUSE UNDESIRABLE EFFECTS.

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:NOTE: TOLUENE 108-88-3 APPEARS ON NAVY
LISTING OF OCCUP CHEMICAL REPROD HAZARDS. CONSULT WITH APPROP HLTH
PROFESSIONALS CONCERNING LATEST HAZ LIST INFO & SAFE HNDLNG & EXPOS
RECOMMENDATIONS . CH LOROCARBON MATLS HAVE PRDCED SENSIT OF
MYOCARDIUM TO EPINEPHRINE IN LAB ANIMALS & COULD HAVE SIMILAR (EFTS
OF OVEREXP)
Explanation of Carcinogenicity:DICHLOROMETHANE: GROUP 2B, IARC VOL
7,P.194,1987; ANTIC TO BE CARCINOGENS, NTP 6TH ANNUAL REPORT ON
CARCINOGENS.
Effects of Overexposure:HLTH HAZ:EFT IN HUMANS. ADRENOMIMETICS (E.G.
EPINEPHRINE) MAY BE CONTRAINDICATED EXCEPT FOR LIFE-SUSTAINING USES
IN HUMANS ACUTELY/CHRONICALLY EXPOSED TO CHLOROCARBONS . ACUTE:
EYES:CAN CAUSE SE V IRRIT, REDNESS, TEARING & BLURRED VISION. MAY
CAUSE TRANSIENT INJURY TO CORNEA. SKIN:MAY CAUSE SLIGHT (SUPP DATA)
Medical Cond Aggravated by Exposure:PERSONS THOUGHT TO HAVE HEART OR
RESPIRATORY PROBLEMS SHOULD SEEK MEDICAL ADVICE BEFORE USING
SOLVENTS OF ANY KIND.

First Aid:SKIN:WASH THORO W/SOAP & WATER. THORO LAUNDER CONTAMD CLTHG
BEFORE REUSE. EYE:FLOOD W/PLENTY OF WATER W/EYELIDS OPEN FOR AT
LEAST 15 MINS & GET MED ATTN PROMPTLY. INHAL:IF ILLNESS OCCURS,
REMOVE TO FR ESH AIR. IF BRTHG IS DFCLT, GIVE OXYGEN. IF BRTHG HAS
STOPPED, START ARTF RESP. CALL MD IMMED. INGEST:IMMED GIVE 1 OR 2
GLASSES OF WATER & CALL MD, HOSP EMER ROOM OR POIS CTL CTR FOR WAY
TO (ING 12)

Flash Point Method:TOC
Flash Point:NONE TO BOIL
Extinguishing Media:WATER FOG, REGULAR FOAM, CARBON DIOXIDE & DRY
CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED PRESSURE DEMAND SCBA
& FULL PROTECTIVE EQUIPMENT . STRAIGHT WATER STREAM WILL SPREAD
FIRE.
Unusual Fire/Explosion Hazard:THERMAL DECOMP PRODS MAY INCL
HCL/PHOSGENE . VAPS ARE HVR/AIR. MAY MOVE FAR FROM HNDLNG LOCATION.
THERMAL DECOMP PRODS ARE HAZ & MAY FORM CORR MATLS.

Spill Release Procedures:WEAR PROPER PROT EQUIP. STOP SPILL AT SOURCE.
KEEP OUT OF GROUND WATER/STREAMS. TRANSFER MATL TO METAL CONTRS.
ABSORB REMAINDER W/ABSORB MATL & SHOVEL INTO CONTRS. THEN WASH AREA
THORO W/WATER & DETER GENT. VENT ADEQUATELY W/GOOD FRESH AIR (ING
13)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE IN COOL PLACE, OUT OF HOT SUN &
BELOW 90F. DO NOT STORE WHERE VAPORS MAY COME IN CONTACT W/FLAMES,
SPARKS & HEAT.
Other Precautions:NO SMOKING IN AREA OF USE. DO NOT USE IN GEN VICINITY
OF ARC WELDING, OPEN FLAMES OR HOT SURF. HEAT &/OR UV RADIA MAY
CAUSE FORMATION OF HCL &/OR PHOSGENE . THIS PROD MUST NOT BE STORED
IN BELOW GROUND AREAS THAT CANNOT (ING 16)

Respiratory Protection:FOR LEVEL UP TO 2% FOR 1/2 HR OR LESS, A
NIOSH/MSHA APPRVD FULL-FACE MASK W/CANISTER FOR ORG VAPS & METHANOL
SHOULD BE USED. ABOVE 2% & EMERGENCIES, A NIOSH/MSHA APPRVD SCBA
W/FULL FACEPIECE OPERATED IN A PRESS DEMAND OR OTHER POS (ING 23)
Ventilation:CARE MUST BE EXCERCISED TO PVNT VAPS FROM COLLECTING IN
LOW, UNVENTD AREAS. ADEQ VENT MUST BE PROVIDED W/GOOD (ING 24)
Protective Gloves:COTTON LINED NEOPRENE GLOVES.
Eye Protection:CHEM WORK GOG & FULL LNTH FCSHLD .
Other Protective Equipment:EYEWASH STATION W/SAFETY SHOWERS. WEAR LONG
SLEEVED SHIRTS & LONG PANTS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EFTS OF OVEREXP:REDDENING. PROLONGED/REPEATED CONTACT CAN CAUSE
IRRITATION, DEFATTING, DERM & MAY RESULT IN ABSORPTION OF HARMFUL
AMOUNTS & SYMPTOMS SIMILAR TO INGESTION. INHAL:INHALATION OF VAPORS
CA N CAUSE NASAL & RESP IRRITATION, DIZZINESS, WEAKNESS, FATIGUE,
HEADACHE, NAUSEA, UNCONSCIOUSNESS & ASPHYXIATION. (ING 5)

HCC:T6
Boiling Pt:B.P. Text:104F,40C
Vapor Pres:RETARDED
Vapor Density:>1
Spec Gravity:1.2
Evaporation Rate & Reference:< ETHER
Solubility in Water:APPRECIABLE
Appearance and Odor:THICKENED WHITE TO CLEAR LIQUID; SWEET, PUNGENT
ODOR.
Percent Volatiles by Volume:>90

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ALKALIES & STRONG ACIDS. MAY REACT
W/ALUMINUM.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
VARIOUS HYDROCARBONS, HYDROGEN CHLORIDE, SMALL AMOUNTS OF PHOSGENE
& CHLORINE.

Waste Disposal Methods:CANNOT BE NEUTRALIZED. MUST NOT BE DUMPED ON
GROUND OR BE ALLOWED TO CONTAM GROUND WATER/STREAMS/OTHER BODIES OF
WATER. SOLIDS COLLECTED FROM STRIPPING SHOULD BE SCREENED OUT. DISP
OF CONTAMD REMOVER AS SPENT SOLV TO A LICENSED RECLAIMER. (ING 15)

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.