Product ID:SKL-LO SPOTCHECK PENETRANT(SEE SUPPL DATA)
MSDS Date:05/07/1987
FSC:6850
NIIN:00-145-0255
Kit Part:Y
MSDS Number: BDCFP

MAGNAFLUX CORPORATION

7300 W. LAWRENCE AVENUE
CHICAGO, IL 60656
US

Emergency Phone: 708-867-8000/800-424-9300(CHEMTREC)

Info Phone: 708-867-8000

Preparer: BRUCE C. GRAHAM

Cage: 37676

ILLINOIS TOOL WORKS INC MAGNAFLUX DIV

GLENVIEW, IL 60025 US

Telephone: 847-657-5300/

Cage: 37676

DISTILLATES(PETROLEUM),CATALYTIC REFORMER FRACTIONATER

CAS: 68477-31-6

Fraction By Weight: 10.0%

PARAFFIN OILS

CAS: 64771-72-8

Fraction By Weight: 40.0%

ACGIH TLV: 5MG/CUM (OIL MIST)

CARBON DIOXIDE

CAS: 124-38-9

RTECS: FF6400000

Fraction By Weight: <5.0%

OSHA PEL 5000 PPM

ACGIH TLV: 5000PPM/30000STEL;93

Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE:IRRITATING TO SKIN &
EYES;SIGNIFICANT AMOUNT OF VAPOR INHALATION CAN RESULT IN
CLUMSINESS & POOR JUDGEMENT,WITH RESULTING TO THE VICTIM,MUCH LIKE
ALCOHOL EFFECT.
Explanation of Carcinogenicity:PER MFR,CONTAINS NO KNOWN OR SUSPECTED
CARCINOGEN IN THE SKL-LO(LOW ODOR PENETRANT).
Effects of Overexposure:INHALATION:CAUSES
DIZZINESS,NAUSEA,DROWSINESS,FROM INHALATION OF SPRAY MIST;
SKIN:CAUSES IRRITATION,DISSOLVES SKIN OILS.POSSIBLE DERMATITIS ON
FREQUENT OR PROLONGED EXPOSURE; EYES:MODERATE IRRITATION BY
CONTACT OF LIQUID OR SPRAY; INGESTION:LOW TOXICITY,BUT HAZARDOUS IF
ASPIRATED INTO LUNGS BY INGESTION OR VOMITING.
Medical Cond Aggravated by Exposure:NOT STATED BY MANUFACTURER.

First Aid:INHALATION:REMOVE TO FRESH AIR.IF NOT BREATHING,GIVE CPR.IF
BREATHING IS DIFFICULT,GIVE OXYGEN; SKIN:WASH OFF IN FLOWING WATER
OR SHOWER.RMV CONTAMINATED CLOTHING AND WASH BEFORE REUSE.USE
SOOTHING LO TION; EYES:FLUSH EYES WITH A STEADY,GENTLE FLOW OF
WATER.GET MEDICAL ASST; INGESTION:DO NOT INDUCE VOMITING.IF VOMIT
IS INHALED,IT MAY CAUSE ASPHYXIATION.GET MED ATTN IMMEDIATELY; IN
EMERGENCY CALL MD

Flash Point:NONE(AEROSOLS)
Extinguishing Media:CARBON DIOXIDE,FOAM
Fire Fighting Procedures:KEEP CONTAINERS COOL WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:AEROSOL CANS CAN BURST IF HEATED ABOVE
130F(54.4C).

Spill Release Procedures:LESS THAN ONE QUART:WIPE UP BUT DO NOT BREATHE
VAPORS;ONE QUART OR MORE:WEAR ALL PERSONAL SAFETY EQUIPMENT TO
AVOID VAPOR/LIQ CONTACT OR BREATHING.EVACUATE UNPROTECTED
PERSONS.ELIMINATE IGN SOURCES.DI KE LIQ.PLACE IN COVERED DRUMS.SEND
TO RECLAIMER.

Handling and Storage Precautions:STORE AWAY FROM HEAT SOURCES TO
MINIMIZE THE DANGER FROM EXPOSURE TO FIRES.STORE IN
DRY,COOL,VENTILATED AREA.
Other Precautions:DO NOT USE AROUND FLAMES/RED HOT SURFACES.DO NOT HEAT
ABOVE 130F.AVOID BREATHING VAPORS.AVOID FREQUENT/PROLONGED EXPOSURE
TO SKIN.

Respiratory Protection:IN POORLY VENTILATED AREAS,WEAR A RESPIRATOR
WITH CHEMICAL CARTRIDGE.IN CONFINED OR UNVENTILATED SPACES,WEAR A
FULL MASK WITH SEPARATE AIR SUPPLY.
Ventilation:GENERAL VENTILATION TO KEEP BELOW LIMITS OF TLV.
Protective Gloves:NITRILE RUBBER GLOVES
Eye Protection:CHEMICAL SPLASH/FULL GOGGLES
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP & WATER AFTER
HANDLING/USE OF:SKL-LO PENETRANT.
Supplemental Safety and Health
NSN FOR A KIT OF 3 PARTS.PER MIL-I-25135D,TYPE II,METHOD C AND
QPL-25135-15,THE PARTS ARE:PENETRANT(SKL-HF/S OR SKL-LO),DEVELOPER
(SKD-NF/ZP-9B ONLY),&
CLEANER/REMOVER(SKC-NF/ZC-7B);REFERENCE:DGSC-SLM CASE HISTORY
#88281H FOR DETAILS;KEY1:J7;THIS ENTRY DESCRIBES:PENETRANT SKL-LO
WHICH IS TYPE II,METH C ITEM.

HCC:V2
NRC/State Lic Num:NOT RELEVANT
Spec Gravity:1.3 (OF LIQUID)
Evaporation Rate & Reference:0.7 (ETHER=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:DARK RED LIQUID BEFORE FILLING IN AEROSOL CANS.
Percent Volatiles by Volume:90.0

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING MATERIAL
Stability Condition to Avoid:HEAT/HIGH TEMPERATURES.
Hazardous Decomposition Products:OXIDES OF CARBON & NITROGEN.

Waste Disposal Methods:DISPOSE OF AS EPA HAZARDOUS WASTE #D001;MAY BE
SENT TO SOLVENT RECLAIMER.INSURE THAT AEROSOL CANS ARE EMPTY AND
DEPRESSURIZED BEFORE DISCARDING,UNLESS A WASTE TREATMENT FACILITY
IS APPROVED TO ACCEPT THEM AS IS.COMPLY WITH FED,ST,& LOCAL REGS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.