Product ID:V-114L (X-20132)
MSDS Date:12/23/1986
FSC:8030
NIIN:00-149-0647
MSDS Number: BDCNJ

STABOND CORPORATION

14010 S. WESTERN AVE.
GARDENA, CA 90249-3008
US

Emergency Phone: 213-770-0591

Info Phone: (213)-770-0591

Cage: GO049

STABOND CORPORATION

GARDENA, CA 90249-3008 US

Telephone: (213) 770-0591

Cage: GO049

METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 80 - 85%

OSHA PEL 200 PPM/300 STEL

ACGIH TLV: 200 PPM/300STEL 9192

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

PHENOL

CAS: 108-95-2

RTECS: SJ3325000

Fraction By Weight: 0.15%

OSHA PEL S, 5 PPM

ACGIH TLV: S, 5 PPM; 8990

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:BELOW TLV,VAPORS MAY CAUSE IRRITATION
TO NOSW AND THROAT.ABOVE TLV,IRRITATION OF MUCOUS
MEMBRANES,HEADACHE,UPSET STOMACH,DIZZINESS,VOMITING-HIGH
CONCENTRATIONS CAN CAUSE UNCONSCIOUSNESS.LIQUID CONTACT WILL DEFAT
SKIN AND MAY CAUSE IRRITATION AND BURNING SENSATION.
Effects of Overexposure:SEE HEALTH HAZARDS
Medical Cond Aggravated by Exposure:NONE IDENTIFIED.

First Aid:INHALATION:REMOVE TO FRESH AIR.RESTORE BREATHING IF REQUIRED.
KEEP WARM.GET MEDICAL ATTENTION.EYE CONTACT:WASH WITH LARGE AMOUNT
OF WATER.IF IRRITATION PERSISTS,GET MEDICAL ATTENTION.INGESTION:IF
CONS CIOUS DRINK 3 GLASSES OF WATER OR MILK AND INDUCE VOMITING.GET
MEDICAL HELP.SKIN CONTACT:WASH WITH SOAP AND WATER.IF IRRITATION
PERSISTS,GET MEDICAL ATTENTION.

Flash Point:20F,-6.7C
Lower Limits:1.8
Upper Limits:11.5
Extinguishing Media:FOAM,ALCOHOL FOAM,CO*2,DRY CHEMICAL
Fire Fighting Procedures:WEAR SCBA IN ENCLOSED AREAS.
Unusual Fire/Explosion Hazard:VOLATILE SOLVENT CONSTITVENT CAN READILY
FORM EXPLOSIVE OR FLAMMABLE MIXTURES IN AIR.VAPORS CAN FLOWALONG
SURFACES TODISTANT IGNITION SOURCES AND FLASH BACK.

Spill Release Procedures:HANDLE AS A FLAMMABLE LIQUID.REMOVE ALL
IGNITION SOURCES.SOAK UP WET MATERIAL ON A NON-COMBUSTIBLE
ABSORBENT AND PLACE IN A CLOSED METAL CONTAINER.

Handling and Storage Precautions:STORE IN COOL, WELL VENTILATED AREAS,
AWAY FROM IGNITION SOURCES AND STRONG OXIDIZING AGENTS.KEEP
CONTAINERS CLOSED.DONOT TRANSFER TO PLASTIC CONTAINR
Other Precautions:GROUND & BOND METAL CONTAINERS WHEN DISPENSING.NO
SMOKING IN AREAS OF USE OR STORAGE.USE ONLY NON-SPARKING TOOLS NEAR
WET ADHESIVE OR SOLVENT VAPORS.SOLVENT VAPOR MUCH HEAVIER THAN AIR
& CAN COLLECT I N DANGEROUS CONCENTRATIONS IN LOW AREAS.

Respiratory Protection:MATERIAL NOT SUITED FOR SPRAY IN RESTRICTED OR
NON-VENTILATED AREAS WHERE VAPOR EXPOSURE MAY BE ENCOUNTERED,USE
RESPIRATOR WITH ORGANIC SOLVENT VAPOR ADSORBING FILTER OR
INDEPENDENT AIR SUPPLY.
Ventilation:LOCAL IF SMALL AREA.MECHANICAL IF LARGE AREA
Protective Gloves:POLYETHYLENE
Eye Protection:GLASSES WITH SIDE SHIELDS
Other Protective Equipment:EYE WASH FOUNTAIN OR BOTTLES.SOLVENT
INSOLUBLE BARRIER HAND CREAM.
Work Hygienic Practices:DO NOT USE CONTACT LENSES.WASH CONTAMINATED
CLOTHING BEFORE REUSE
Supplemental Safety and Health

HCC:F2
Boiling Pt:=80.C, 176.F
Vapor Pres:199MM@100F
Vapor Density:1.4
Spec Gravity:0.86
Evaporation Rate & Reference:<1 (ETHER=1)
Solubility in Water:APPRECIABLE
Appearance and Odor:BLUE LIQUID-KETONE-PHENOLIC RESIN ODOR
Percent Volatiles by Volume:81.48

Stability Indicator/Materials to Avoid:YES
STRONG OXIDATING AGENTS.
Stability Condition to Avoid:KEEP AWAY FROM ALL SOURCES OF IGNITION AND
HEAT.
Hazardous Decomposition Products:NITROUS OXIDE,PHENOLS,CO*2,HCN,CO.

Waste Disposal Methods:DISPOSE OF IAW FEDERAL,STATE AND LOCAL
REGUALTIONS FOR MEK. SOLID INGREDIENTS NOT CONSIDERED HAZARDOUS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.