Product ID:PETROFLUID 822
MSDS Date:01/01/1985
FSC:9150
NIIN:00-149-7432
MSDS Number: BDCPQ

Emergency Phone: 800-245-3952

Info Phone: 800-245-3952

Cage: JO941

Telephone: 800-245-3952

Cage: 86459

SYNTHETIC OIL

DIBASIC ACID ESTER

Effects of Overexposure:EYE: IRRIT: SKIN: IRRIT. INGEST: LOCAL IRRIT OF
MUC MEMB OF THOAT,MOUTH,ESOPHAGUS,STOMACH.

First Aid:EYE: WASH IMMED W/WATER FOR 15 MIN. CALL PHYSICIAN. SKIN:WASH
W/SOAP & WATER. REMOVE CONTAMINATED CLOTHING & WASH BEFORE REUSE.
INGEST: DO NOT INDUCE VOMITING (ASPIRATION HAZARD)

Flash Point Method:COC
Flash Point:424F,218C
Extinguishing Media:CO*2,DRY CHEM, FOAM
Fire Fighting Procedures:WATER MAY BE USED TO COOL HEAT-EXPOSED CANS.
Unusual Fire/Explosion Hazard:PROD OF COMBUSTION:CO,CO*2,SMOKE.
MATERIAL MUST BE HEATED ABOVE FLASH POINT TO BE A FIRE HAZARD.

Spill Release Procedures:SPREAD OIL DRY MATERIAL ON SPILL & SWEEP UP OR
DILUTE SPILL W/PETROLEUM SOLVENT & WIPE UP. PROVIDE ADEQUATE VENT &
AVOID SOURCES OF IGNITION. STORE IN COVERED MARKED METALLIC
CONTAINERS AND DISPOSE OF AS SOON AS POSSIBLE.

Handling and Storage Precautions:STORE IN COVERED MARKED METALLIC
CONTAINERS. STORE IN COOL WELL VENTED AREA. CONTROL IGNITION
SOURCES. GROUND CANS PRIOR TO PUMPING OR TRANSFERRING.
Other Precautions:FIRE EXTINGUISHERS MUST BE KEPT READILY AVAILABLE &
ALL PERSONNEL TRAINED PROPERLY. DO NOT MIX W/STRONG OXIDANTS. DO
NOT TRANSFER TO UNMARKED CONTAINERS. AUTOIGNITION TEMP: 630F;332C.

Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR FOR PARTICULAR
EXPOS OF CONCERN.(MFR)
Ventilation:TO KEEP CONCENTRATION BELOW TLV. USE EXPLOSION-PROOF EQUIP.
Protective Gloves:POLYETHYLENE
Eye Protection:SFTY GOG W/FACE SHIELD
Other Protective Equipment:IMPERVIOUS POLYETHYLENE BOOTS/APRON ETC.
Supplemental Safety and Health
TLV=5 MG/CUM FOR MIST & 500 PPM FOR VAPORS GENERATED UPON HEATING.
CONTAINER: 1 GALLON.

HCC:V6
Vapor Pres:<1
Vapor Density:>1
Spec Gravity:0.85
Evaporation Rate & Reference:<1 (ETHYL ETHER=1)
Solubility in Water:NEGLIBLE
Appearance and Odor:RED TRANSPARENT FLUID.
Percent Volatiles by Volume:0

Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS

Waste Disposal Methods:MFR RECOMMENDS INCINERATION. DISPOSAL METHOD
MUST BE IAW FED, STATE & LOCAL CODES.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.