Product ID:COATING COMPOUND METAL PRETREATMENT, (SUPDAT)
MSDS Date:01/09/1989
FSC:8030
NIIN:00-165-8577
MSDS Number: BDDYX

PRATT AND LAMBERT INC

16116 E 13TH ST
WICHITA, KS 67201
US

Emergency Phone: 716-873-6000 DOT EMER 8002553924

Info Phone: 316-733-1361

Cage: 61196

PRATT AND LAMBERT INC

6027 CLEVELAND, OH 44101-1027 US

Telephone: 216-566-2902

Cage: 61196

33 @20C.

CAS: 67-63-0

RTECS: NT8050000

Fraction By Weight: 65%

OSHA PEL 400 PPM/500 STEL

ACGIH TLV: 400 PPM/500STEL;9192

ZINC CHROMATE

CAS: 13530-65-9

RTECS: GB3290000

Fraction By Weight: 10%

OSHA PEL 0.1 MG/M3 (CRO3)

ACGIH TLV: 0.01MG/M3(CR)A1;9192

6 @20C.

CAS: 71-36-3

RTECS: EO1400000

Fraction By Weight: 15%

OSHA PEL 100 PPM

ACGIH TLV: S, C 50 PPM; 9293

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

TALC (POWDER) CONTAINING NO ASBESTOS FIBERS; (TALC)

CAS: 14807-96-6

RTECS: WW2710000

Fraction By Weight: <5%

OSHA PEL 2 MG/M3 RDUST

ACGIH TLV: 2 MG/M3 RDUST

VOLATILE ORGANIC COMPOUNDS. 696 G/L, 5.8 LB/GAL LESS WATER

RTECS: 9999999VO

OSHA PEL N/K

ACGIH TLV: N/K

TREATMENT THAT MIGHT BE REQUIRED FOR OVEREXP SHOULD

RTECS: 9999999ZZ

OSHA PEL N/K

ACGIH TLV: N/K

ABSORB. USE ONLY NON-SPARKING TOOLS. PLACE

RTECS: 9999999ZZ

OSHA PEL N/K

ACGIH TLV: N/K

CONTAMINATION OF SEWERS, STREAMS, AND GROUNDWATER

RTECS: 9999999ZZ

OSHA PEL N/K

ACGIH TLV: N/K

PROD, IF DISCARDED DIRECTLY, WOULD BE

RTECS: 9999999ZZ

OSHA PEL N/K

ACGIH TLV: N/K

I.E. HAS FLASH POINT OF 140 DEG. F., OR LESS. PROPER

RTECS: 9999999ZZ

OSHA PEL N/K

ACGIH TLV: N/K

RESTRICTED VENT AREAS A NIOSH/MSHA APPRVD CHEM

RTECS: 9999999ZZ

OSHA PEL N/K

ACGIH TLV: N/K

SUCH AS SPRAYING, A MECH PREFILTER MAY ALSO RE REQD.

RTECS: 9999999ZZ

OSHA PEL N/K

ACGIH TLV: N/K

RESP. IF TLV'S LISTED IN INGRED ARE EXCEEDED USE A

RTECS: 9999999ZZ

OSHA PEL N/K

ACGIH TLV: N/K

FACTOR. REFER TO OSHA 29 CFR 1910.134 "RESPIRATORY

RTECS: 9999999ZZ

OSHA PEL N/K

ACGIH TLV: N/K

GUIDELINE, AMERICAN INDUSTRIAL HYGIENE ASSOC."

RTECS: 9999999ZZ

OSHA PEL N/K

ACGIH TLV: N/K

IN INGREDIENTS BELOW THE LOWEST EXPOSURE LIMITS

RTECS: 9999999ZZ

OSHA PEL N/K

ACGIH TLV: N/K

WEAR FACE SHIELD AS NECESSARY WHEN SPRAYING.

RTECS: 9999999ZZ

OSHA PEL N/K

ACGIH TLV: N/K

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:INGEST:CAN CAUSE GI IRRIT, NAUS,
& VOMIT. ASPIR OF MATL INTO LUNG MAY CAUSE CHEM PNEUM WHICH CAN BE
FATAL. INHAL:MAY CAUSE NOSE/THROAT IRRIT. HIGH CONC MAY CAUSE ACUTE
CNS DEPRESS CHARACTERIZED BY HDCHS, DIZZ, NAUS & CONFUSN.
EYE:MAYCAUSE EYE IRRIT. SKIN:LIQ MATL MAY BE ABSORBED THRU SKIN IN
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:ZINC CHROMATE:IARC MONOGRAPHS SUPPLEMENT
ON EVAL OF CARCIN RISK OF CHEM TO MAN, VOL 49, PG 49, 1990:GROUP 1.
(SUPDAT)
Effects of Overexposure:HLTH HAZ: HARMFUL AMTS. MAY CAUSE DEFAT & IRRIT
OF SKIN. RPTD & PRLNGD OVEREXP TO RELATIVELY INSOL CHROMATES MAY
CAUSE LUNG CANCER. RPTS HAVE ASSOC PRLNGD & RPTD OCCUP OVEREXP TO
SOLV W/PERM BRAIN & N ERV SYS DMG. INTENTIONAL MISUSE BY
DELIBERATELY CONCENTRATING & INHALING CONTENTS MAY BE
HARMFUL/FATAL.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INGEST:DO NOT INDUCE VOMIT. CALL POIS CTL CTR, HOSPITAL EMER
ROOM/PHYS IMMED. INHAL:REMOVE TO FRESH AIR IMMED. IF BRTHG HAS
STOPPED, GIVE ARTF RESP. KEEP WARM & QUIET. GET MED ATTN IMMED.
EYE:FLUSH W/ LG AMTS OF WATER, LIFTING UPPER & LOWERLIDS OCCASNLY
FOR AT LEAST 15 MINS. GET MED ATTN. SKIN:REMOVE CONTAMD CLTHG. WASH
AFFECTED AREA W/SOAP & WATER. OBTAIN MED ATTN IF IRRIT PERSISTS.
(SUPDAT)

Flash Point:53.0F,11.7C
Extinguishing Media:NFPA CLASS B FIRE EXTINGS (CO*2, ALL PURPOSE DRY
CHEM/ALCOHOL FOAM) DESIGNED TO EXTING FLAM LIQ FIRES. POLYMER
(SUPDAT)
Fire Fighting Procedures:NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP .
H*20 MAY BE INEFTIVE, BUT MAY BE USED TO COOL EXPOS CNTNRS TO PVNT
PRESS BUILD UP & POSS AUTO-IGNIT OR (SUPDAT)
Unusual Fire/Explosion Hazard:DURING EMER CNDTNS, OVEREXP TO DECOMP
PROD MAY CAUSE HLTH HAZARD. SYMP MAY NOT BE IMMED APPARENT. OBTAIN
MED ATTN. WARNING! FLAMMABLE.

Spill Release Procedures:KEEP SPECTATORS AWAY. ELIM ALL IGNIT SOURCES
(FLAMES, HOT SURF, & SOURCES OF ELEC, STATIC/FRICTIONAL SPARKS).
DIKE & CONTAIN SPILL W/INERT MATL (E.G. SAND, EARTH). TRANSFER LIQS
TO COVERED METAL CNTNR S FOR RECOVERY/DISP, OR REMOVE W/INERT (ING
7)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:DO NOT STORE ABOVE 95 DEGREES F. STORE
LG QTYS IN COMPLIANCE W/OSHA 29 CFR 1910.106. DO NOT TAKE
INTERNALLY. CLOSE CNTNR AFTER EACH USE.
Other Precautions:KEEP AWAY FROM CHILDREN. EMPTY CNTNRS MUST BE WASHED
& RE-USED FOR ANY PURPOSE. CNTNRS SHOULD BE GROUNDED & BONDED TO
RECEIVING CNTNR. DO NOT WELD, BRAZE/CUT ON EMPTY CNTNR. NEVER USE
PRESS TO EMPTY. DRUM IS NOT A PRESSURE VESSEL.

Respiratory Protection:PROPER SELECTION OF RESP PROT DEPENDS UPON MANY
FACTORS INCL DURATION/LEV OF EXPOS & CNDTNS OF USE. IN GEN EXPOS TO
ORG CHEM SUCH AS THOSE CONTAINED IN THIS PROD MAY NOT REQ USE OF
RESP PROT IF USED I N WELL VENTILATED AREAS. IN (ING 11)
Ventilation:PROVIDE GEN DILUTION & LOC EXHAUST VENT IN SUFFICIENT VOL &
PATTERN TO MAINTAIN CONC OF HAZ SUBSTANCES LISTED (ING 16)
Protective Gloves:SOLVENT IMPERMEABLE GLOVES.
Eye Protection:SFTY SPECTACLES W/SIDE SHIELDS.(ING 17).
Other Protective Equipment:NOT LIKELY TO BE NEEDED.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MFR TRADE NAME/PART NO:COMPONENT I, MFR CODE 728013. EXTING MEDIA:FOAM
IS PREF FOR LG FIRES. FIRE FIGHT PROC:EXPLOSION WHEN EXPOS TO
EXTREME HEAT. IF WATER IS USED, FOG NOZZ ARE PREF. EXPLAN OF CARCIN
:NTP 7TH ANNUAL RPT ON CARCIN, 1994:KNOWN TO BE CARCINOGENIC.
ANIMAL LUNGS. FIRST AID PROC:NOTES TO PHYS:ANY (ING 6)

HCC:F2
Boiling Pt:B.P. Text:>180F,>82C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:0.875
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NOT KNOWN
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:89

Stability Indicator/Materials to Avoid:YES
STRONG ACIDS OR ALKALINE MATERIALS.
Stability Condition to Avoid:AVOID EXCESSIVE HEAT AND SOURCES OF
IGNITION.
Hazardous Decomposition Products:BURNING, INCL WHEN HEATED BY
WELDING/CUTTING, WILL PRDCE SMOKE, CO & CO*2. IN ADDN, OXIDES OF
CHROMIUM MAY BE GENERATED.

Waste Disposal Methods:DISPOSE I/A/W FED, STATE & LOCAL LAWS. INCIN
ONLY IN EPA PERMITTED FACILITY. DO NOT INCIN CLSD CNTNRS. OBSERVE
PRECAUTS FOR DISP OF FLAM MATLS. CONTAMD ABSORB MAY BE DISPOSED IN
HAZ WASTE LANDFILL. DI SPOSE ONLY I/A/W FED, STATE & LOC REGS.(ING
9)

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.