Product ID:LACQUER C/N GLOSS CLEAR 786800
MSDS Date:11/04/1986
FSC:8010
NIIN:00-166-3164
MSDS Number: BDFCP

PRATT AND LAMBERT INC

16116 E 13TH ST
WICHITA, KS 67201
US

Emergency Phone: 716-873-6000 DOT EMER 8002553924

Info Phone: 316-733-1361

Cage: 61196

PRATT AND LAMBERT INC

6027 CLEVELAND, OH 44101-1027 US

Telephone: 216-566-2902

Cage: 61196

TOLUENE (SARA III)

CAS: 108-88-3

RTECS: XS5250000

OSHA PEL 200 PPM/150 STEL

ACGIH TLV: 50 PPM; 9293

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

ISOBUTYL ALCOHOL (SARA III)

CAS: 78-83-1

RTECS: NP9625000

OSHA PEL 100 PPM

ACGIH TLV: 50 PPM; 9293

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

ISOPROPYL ALCOHOL (SARA III)

CAS: 67-63-0

RTECS: NT8050000

OSHA PEL 400 PPM/500 STEL

ACGIH TLV: 400 PPM/500STEL;9192

NITROCELLULOSE

CAS: 9004-70-0

RTECS: QW0970000

Fraction By Weight: <5.0%

ACGIH TLV: 100 PPM

NAPHTHA (PETROLEUM SPIRITS OR BENZIN)

CAS: 8030-30-6

RTECS: SE7555000

Fraction By Weight: <5.0%

OSHA PEL 100 PPM

N-DIOCTYLPHTHALATE (SARA III)

CAS: 117-84-0

RTECS: TI1925000

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

ISOPROPYL ACETATE

CAS: 108-21-4

RTECS: AI4930000

OSHA PEL 250 PPM/310 STEL

ACGIH TLV: 250 PPM/310STEL;9192

N-HEPTANE

CAS: 142-82-5

RTECS: MI7700000

OSHA PEL 500 PPM/500 STEL

ACGIH TLV: 400 PPM/500STEL;9293

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INGEST:GI
IRRITATION,NAUSEA&VOMITING,ASPIRATION INTO LUNG MAY CAUSE CHEM
PNEUMONITIS,WHICH CAN BE FATAL.INHALE:ANESTHETIC,IRRITATION TO
NOSE&THROAT,ACUTE NERVOUS SYSTEM DEPRESS.CHAR BY:HEADACHE,DIZZIN
ESS,CONFUSION,NAUSEA,UNCONSCIOUSNESS,AND ASPHYXIATION.EYE:MAY CAUSE
IRRIT.SKIN:PRIMARY IRRITANT.DEFATTING&IRRIT OF SKIN.
Effects of Overexposure:RPTED OVEREXPOSURE TO TOULENE MAY CAUSE LIVER
DAMAGE.RPTS HAVE ASSOC PRLNGD/RPTED OCCUPATIONAL OVEREXPOSURE TO
SOLVENTS W/PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE.INTENTIONAL
MISUSE BY DILIBERTELY CONC ENTRATING AND INHALING THE CONTENTS
MAYHARMFUL OR FATAL.
Medical Cond Aggravated by Exposure:TOULENE HAS BEEN FOUND TO CAUSE
KIDNEY,LUNG AND SPLEEN DAMAGE IN LABORATORY ANIMALS.

First Aid:INGEST:CALL POISON CNTRL CENT,ER,OR PHYSICIAN
IMMED.INHALE:RME TO FRESH AIR IMMED.IF BREATHING HAS STOPPED,GIVE
ART RESP,KEEP WARM&QUIET,GET MED ATTN IMMED.EYE:FLUSH W/LRG AMTS OF
H*2O,LIFTING LIDS OC CASIONLLY.CONT FOR 15MIN.GET MED
ATTEN.SKIN:IMMED FLUSH THE CONTAMINATED AREA W/LRG AMTS OF H*2O.RME
CONTAMINATED CLOTHING AS H*2O IS APPLIED.GET MEDICAL ATTENTION IF
IRRITATION PERSISTS.

Flash Point:20F/-6.6C CAL
Extinguishing Media:CO*2,DRY CHEM,ALCOHOL FOAM, POLYMER FOAM IS
PREFERRED FOR LARGE FIRES.
Fire Fighting Procedures:FIREFIGHTERS SHOULD WEAR SCBA.H*2O MAY BE
INEFFECTIVE,MAY BE USED TO COOL EXPOSD CONTS TO PVNT PRESSURE
BUILDUP & POSS AUTOIGNTION OR EXPLO WHEN (SEE SUPP DATA)
Unusual Fire/Explosion Hazard:DURING EMER CONDITIONS,OVEREXPOS TO
DECOMP PRODT MAY CAUSE A HLTH HZD.SYMPTOMS MAY NOT BE IMMED
APPARENT.OBTAIN MEDICAL ATTENTION.

Spill Release Procedures:WEAR PPE APPROPRIATE FOR EXPOSURE OF
CONCERN.ELIMINATE SOURCES OF IGNITION.DIKE AND CONTAIN SPILL
W/INERT MATERIAL TRANS LIQUID TO COVERED METAL CONTAINER FOR
RECOVERY OR DISPOSAL,OR RME W/INERT ABSOR BENTS.USE NONSPRK
TOOLS.PLACE ABS (SEE SUPP DATA)

Handling and Storage Precautions:DO NOT STORE ABOVE 95 F/35 C.STORE
LARGE QUANTITIES IN COMPLIANCE WITH OSHA 29CFR1910.106.
Other Precautions:DO NOT TAKE INTERNALLY.CLOSE CONTAINERS AFTER
USE.EMPTY CONTAINERS MUST NOT BE WASHED AND REUSED FOR ANY
PURPOSE.CONTAINERS SHOULD BE GROUNDED AND BONDED TO THE RECEIVING
CONTAINER.DO NOT WELD,BRAZE,O R CUT ON EMPTY CONTAINER.(SEE SUPP
DATA)

Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN
Ventilation:VOL&PATTERN TO KEEP CONC.OF HZDUS INGED BELOW THE LOWEST
LEVEL LISTED.RME DECOMP PROD GENERATED WHEN HEATING.VENT VAPORS
Protective Gloves:SOLVENT IMPERMABLE GLOVES
Eye Protection:CHEMICAL WORKER GOGGLES
Other Protective Equipment:EYEWASH FACILITY,SAFETY SHOWER
Supplemental Safety and Health
BP:82-220C FIRE FGHTS EXPOSED TO EXTREME HEAT.IF WATER IS USED FOG
NOZZLES ARE PREFERRABLE. SPILL:ORBENT MATERIAL IN CLSD METAL
CONTAINER FOR DISPOSAL. PVT CONTAMINATED OF SEWER,STREAM,AND GROUND
WATE R W/SPILLED MATERIAL OR USED ABSORBENT.OTHER PREC:NEVER USE
PRESSURE TO EMPTY DRUM IS NOT A PRESSURE VESSEL.KEY1:F3

HCC:F2
Boiling Pt:B.P. Text:180F-428F
Vapor Density:>AIR
Spec Gravity:0.91
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:79

Stability Indicator/Materials to Avoid:YES
STRONG ACIDS OR ALKALINE MATERIALS. OXIDIZING MATERIALS.
Stability Condition to Avoid:AVOID EXCESSIVE HEAT AND SOURCES OF
IGNITION.
Hazardous Decomposition Products:BURNING,INCL WHEN HEATED BY WELDING OR
CUTTING,WILL PROD SMOKE,CO,CO*2,&OXIDES OF NITRGEN MAY BE
GENERATED.
Conditions to Avoid Polymerization:KEEP AWAY FROM HEAT SPARKS AND
FLAME.

Waste Disposal Methods:DISPOSE OF IAW FED,STATE & LOCAL LAWS.INCINERATE
ONLY IN EPA APPRVD FACILITY.DO NOT INCINERATE CLSD
CONTAINER.CONTAMINATED ABSORBENT MAY BE DISPOSED OF IN A HAZARDOUS
WASTE LANDFILL.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.