Product ID:03-Y-30 BASE,YELLOW 33538,POLYURETHANE
MSDS Date:01/01/1985
FSC:8010
NIIN:00-181-8302
Kit Part:Y
MSDS Number: BDGVP

DEFT INC CHEMICAL COATING DIV

17451 VON KARMAN AVE
IRVINE, CA 92714-6205
US

Emergency Phone: 800-424-9300 CHEMTREC

Info Phone: 714-474-0400

Cage: 33461

DEFT, INC.

IRVINE, CA 92614 US

Telephone: 949-474-0400

Cage: 33461

METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 13.1%

OSHA PEL 200 PPM/300 STEL

ACGIH TLV: 200 PPM/300STEL 9192

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

2-ETHOXYETHYL ACETATE (CELLOSOLVE ACETATE) (EGEEA)

CAS: 111-15-9

RTECS: KK8225000

Fraction By Weight: 18.1%

OSHA PEL S,100 PPM

ACGIH TLV: S, 5 PPM; 9192

ETHYL ACETATE (CAS #141-78-6)

RTECS: AH4250000

Fraction By Weight: 11.1%

ACGIH TLV: 400 PPM

LEAD CHROMATE (OSHA PEL FOR LEAD FROM 29CFR

CAS: 7758-97-6

RTECS: GB2975000

Fraction By Weight: 17.6%

OSHA PEL 0.05 MG/M3 (PB)

ACGIH TLV: 0.05MG/M3(CR)A2;8990

POLYESTER RESIN *-SEE SUPPLEMENTAL DATA FOR OTHER HAZ

Fraction By Weight: 29.2%

Effects of Overexposure:EYES:MODERATE IRRIT;SKIN:POSSIBLE IRRIT BY
SOLVENTS;INH:SOLVENT VAPORS CAN CAUSE IRRIT OR NARCOSIS

First Aid:SKIN:WIPE OFF WITH A RAG THEN THOROUGH RINSING W/H*2O &
WASHING W/MILD SOAP AND WATER;EYES:FLUSH W/WATER FOR AT LEAST 10
MIN & CONSULT AN EYE PHYSICIAN;INH:REMOVE TO FRESH AIR.GIVE
CPR/OXYGEN IF NEEDE D.

Flash Point:28F(-2.2C)-OC
Lower Limits:1.6
Extinguishing Media:CO*2,DRY CHEM,FOAM
Fire Fighting Procedures:DO NOT USE H+2O STREAM ON FIRE.H*2O SPRAY/FOG
IS MORE EFFCTV
Unusual Fire/Explosion Hazard:CAUTION AGAINST APPLICATION TO HOT
SURFACES & USE IN AREAS WHERE COURCES OF IGNITION MAY BE PRESENT.

Spill Release Procedures:EVACUATE UNPROTECTED PERSONS.ELIM IGN
SOURCES.USE SAFETY EQUIP.VENTLATE AREA.STOP LEAK W/O RISK.ABSORB SM
SPILL W/OIL ABSORBNG COMPD/RAGS;DIKE LG SPILL.PUMP LIQ TO SALVAGE
TANK.SHOVEL UP RESIDUE INTO COVRD DRUMS;PER MFR,FLUSH AREA W/LG
AMTH+2O.

Handling and Storage Precautions:STORE IN COOL,DRY WELL VENTILATED,LOW
FIRE RISK AREA.KEEP CONTNRS TIGHTLY CLOSED KEEP AWAY FM HEAT,SPARK
OR OPEN FLAME.
Other Precautions:AVOID PROLONGED INHALATION OF VAP.PER MFR,WATER SPRAY
OR FOG CAN BE USED EFFECTIVELY ON FIRE AND TO COOL HEAT/FIRE
EXPOSED CONTNRS.

Respiratory Protection:GOOD VENTILATION IS NEEDED.HOWEVER USE NIOSH
APPRVD SCBA FOR PAINTS.
Ventilation:USE ADEQUATE VENTILATION USING EXHAUST FAN.
Protective Gloves:IMPERVIOUS
Eye Protection:SAFETY/CHEM GOGGLES.
Other Protective Equipment:AS REQD TO PREVENT PROLONGED OR REPEATED
CONTACT.
Supplemental Safety and Health
TWO PART KIT:THIS DATA IS FOR BASE: SEE P/N IND"B" FOR CTLYST;ALSO
CONTANS;0.7% TOLUENE; 0.9% TITANIUM DIOXIDE: 8.3% SILICA:0.3%
ANTI-SETTLING AGENT: 3% DISPERSION AID* NOW SEE ADDITIONAL DATA*
KEY 1: F3

HCC:F2
Boiling Pt:B.P. Text:169-331F
Vapor Density:>1.0
Spec Gravity:1.19
Evaporation Rate & Reference:<1(SLOWR THAN ETHR
Solubility in Water:NEGLIGIBLE
Appearance and Odor:YELLOW PAINT,ODOR PLEASANT-PUNGENT
Percent Volatiles by Volume:59.1

Stability Indicator/Materials to Avoid:YES
OXIDIZING & CORROSIVE MATERIALS.
Stability Condition to Avoid:SOURCE OF IGN,SPARK,HEAT & OPEN FLAME

Waste Disposal Methods:KEEP IN CLOSED CONTNRS PENDING DISPOSAL.MFR
SUGGESTED,DISPOSE IN TIGHTLY CLOSED CONTAINERS & FINALLY DISPOSE BY
SANITARY LANDFILL IAW APPLICABLE REGS;HANDLE & DISPOSE IN FULL
COMPLIANCE Q/ALL FED,STAT E,& LOCAL REGULATIONS CONCERNING WASTE
DISPOSAL

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.