Product ID:T 161
MSDS Date:04/09/1993
FSC:8040
NIIN:00-247-7642
MSDS Number: BGWDZ

STABOND CORP

14010 S. WESTERN AVE
GARDENA, CA 90249-3008
US

Emergency Phone: 800-424-9300 CHEMTREC

Info Phone: 213-770-0591

Preparer: D. MARTINSON

Cage: 25670

STABOND CORPORATION

GARDENA, CA 90249-3008 US

Telephone: 213-770-0591/800-4249300

Cage: 25670

HEXANE (N-HEXANE)

CAS: 110-54-3

RTECS: MN9275000

Fraction By Weight: 30%

OSHA PEL 500 PPM

ACGIH TLV: 50 PPM; 9394

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

TOLUENE (SARA III)

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 41%

OSHA PEL 200 PPM; Z-2

ACGIH TLV: S, 50 PPM; 9394

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EXPOSURE MAY CAUSE EYE, SKIN &
RESPIRATORY TRACT IRRITATION. INGESTION MAY CAUSE CNS DEPRESSION.
CHRONIC: PROLONGED OR REPEATED EXPOSURE MAY CNS DEPRESSION THROUGH
INHALATION; LONG TERM SKIN CO NTACT MAY CAUSE IRRITATION/DRYING.
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
OR GREATER IS LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN.
Effects of Overexposure:INHALED: COUGHING, WHEEZING, SHORTNESS OF
BREATH. INHALED/INGESTED (CNS EFFECTS): HEADACHE, NAUSEA, VOMITING,
DIZZINESS. SKIN: REDNESS, DRYING. EYES: REDNESS, BLURRED VISION,
DISCOMFORT.
Medical Cond Aggravated by Exposure:EXISTING DERMATITIS. PREEXISTING
EYE & RESPIRATORY DISORDERS.

First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE MOUTH-TO-MOUTH
RESUSCITATION IF NOT BREATHING. GET MEDICAL ATTENTION IMMEDIATELY.
EYE: IMMEDIATELY FLUSH WITH RUNNING WATER FOR 15 MINUTES WHILE
HOLDING EYELID. G ET MEDICAL ATTENTION IMMEDIATELY. SKIN:WASH WITH
SOAP & WATER. REMOVE CONTAMINATED CLOTHING. INGESTION: DO NOT
INDUCE VOMITING. NOTHING BY MOUTH IF UNCONSCIOUS. GET MEDICAL
ATTENTION IMMEDIATELY.

Flash Point Method:TCC
Flash Point:=-23.3C, -10.F
Lower Limits:1.0
Upper Limits:7.0
Extinguishing Media:FOAM,CO2,DRY CHEMICAL,WATER FOG.
Fire Fighting Procedures:SELF-CONTAINED BREATHING APPARATUS IS REQUIRED
FOR FIREFIGHTING IN ENCLOSED AREAS.
Unusual Fire/Explosion Hazard:VOLATILE SOLVENT CONSISTENT CAN READILY
FORM EXPLOSIVE OR FLAMMABLE MIXTURES IN AIR.VAPORS CAN FLOW ALONG
TO DISTANT IGNITION SOURCES & FLASHBACK.

Spill Release Procedures:REMOVE ALL IGNITION SOURCES. SOAK UP WET
MATERIAL ON A NON-COMBUSTIBLE ABSORBENT & PLACE IN A CLOSED METAL
CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE IN COOL,WELL VENTILATED AREA
AWAY FROM ANY IGNITION SOURCES & STRONG OXIDIZING AGENTS. KEEP
CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE.
Other Precautions:GROUND & BOND CONTAINERS WHEN DISPENSING. NO SMOKING
IN AREAS OF STORAGE OR USE. USE ONLY NON-SPARKING TOOLS NEAR WET
ADHESIVE. SOLVENT VAPOR HEAVIER THAN AIR AND MAY COLLECT IN FLOOR
DRAINS OR LOW AR EAS.

Respiratory Protection:IF ENGINEERING CONTROLS FAIL OR NON-ROUTINE USE
OR EMERGENCY OCCURS; USE NIOSH/MSHA APPROVED RESPIRATOR OR SUPPLIED
AIR RESPIRATOR OR SCBA, AS REQUIRED. USE IAW 29 CFR 1910.134 AND
MANUFACTURER'S RECO MMENDATIONS.
Ventilation:USE EXPLOSION-PROOF MECHANICAL VENTILATION AND/OR LOCAL
EXHAUST TO KEEP BELOW TLV.
Protective Gloves:POLYETHYLENE OR NITRILE GLOVES.
Eye Protection:SAFETY GLASSES WITH SIDE SHIELDS.
Other Protective Equipment:EYE WASH STATION & SAFETY SHOWER.
Work Hygienic Practices:DO NOT USE CONTACT LENSES. WASH CONTAMINATED
CLOTHING BEFORE REUSE.
Supplemental Safety and Health

HCC:F2
Boiling Pt:=68.9C, 156.F
Vapor Density:>1
Spec Gravity:0.9
Evaporation Rate & Reference:<1 (ETHER=1)
Solubility in Water:NIL
Appearance and Odor:MEDIUM VISCOSITY SYRUP WITH SOLVENT ODOR.

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:KEEP AWAY FROM ALL SOURCES OF IGNITION &
HEAT.
Hazardous Decomposition Products:CO,CO2 & HCL.
Conditions to Avoid Polymerization:WILL NOT OCCUR.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL,STATE &
FEDERAL REGULATIONS FOR THE FLAMMABLE MIXTURE. SOLID INGREDIENTS
NOT CONSIDERED HAZARDOUS. DLA-HMIS: EPA/RCRA WASTE NUMBER D001 MAY
APPLY TO UNUSED/UNCONTAM INATED PRODUCT.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.