Product ID:CURING SOLN(CA-97) FOR 463-6 RESIN/IN KIT
MSDS Date:10/31/1988
FSC:1615
NIIN:01-115-3616
Kit Part:Y
MSDS Number: BGWFS

AKZO COATINGS INC./AEROSPACE FINISHES DIV.

434 W. MEATS AVE
ORANGE, CA 92665
US

Emergency Phone: 45 PM E.S.T.)

Info Phone: 313-855-7313 AFTER HOURS

Cage: 98502

BOEING HELICOPTERS, DIV OF THE BOEING CO

RIDLEY PARK, PA 19078 US

Telephone: 215-591-3010

Cage: 77272

ISOPROPYL ALCOHOL (SARA III)

CAS: 67-63-0

RTECS: NT8050000

Fraction By Weight: 40.-55%.

OSHA PEL 400 PPM/500 STEL

ACGIH TLV: 400 PPM/500STEL;9192

TOLUENE (SARA III)

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 45.-60%.

OSHA PEL 200 PPM/150 STEL

ACGIH TLV: 50 PPM; 9293

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYE IRRITANT,CONTACT MAY CAUSE
EYE BURNS OR CORNEAL INJURY. EXCESSIVE INHALATION OF VAPORS CAN
CAUSE NASAL & RESPIRATORY
IRRITATION,DIZZINESS,WEAKNESS,FATIGUE,NAUSEA,ETC.; CHRONIC:REPEATED
OVERE XPOSURE MAY RESULT IN DELAYED KIDNEY INJURY, ALSO POSSIBLE
LIVER ABNORMALITIES.
Effects of Overexposure:EYE:IRRITANT,TEARING,BLURRED
VISION,REDNESS,BURN OR CORNEAL INJURY; SKIN: DERMATITIS & MILD
IRRITATION; INHAL: NASAL & RESPIRATORY IRRITATION, DIZZINESS,
WEAKNESS, HEADACHE, POSSIBLE UNCONSCIOUSNESS & EVEN ASPHYXIATION;
INGEST: MAY CAUSE G.I. IRRITATION, NAUSEA, VOMITING & DIARRHEA.
Medical Cond Aggravated by Exposure:NONE EXPECTED.

First Aid:EYE: FLUSH W/WATER FOR AT LEAST 15 MINS.GET MEDICAL ATTN.;
SKIN: WASH W/ SOAP & WATER; INHAL:MOVE TO FRESH AIR. GIVE
ARTIFICIAL RESPIRATION IF NECESSARY; INGEST: DRINK ONE OR TWO
GLASSES OF WATER TO D ILUTE. DONOT INDUCE VOMITING. GET MEDICAL
ATTN IMMEDIATELY. TREAT SYMPTOMATICALLY.

Flash Point Method:TCC
Flash Point:40F/4.4C
Lower Limits:1.2
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICALS.
Fire Fighting Procedures:WATER MAY BE INEFFECTIVE. WATER SHOULD BE USED
TO COOL CONTAINERS EXPOSED TO FIRE. FIRE FIGHTING PERSONNEL SHOULD
WEAR SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM HEAT, SPARKS,ELECTRICAL EQUIPMENT & OPEN FLAME. CLOSED
CONTAINERS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT.

Spill Release Procedures:REVIEW: A)FIRE & EXPLOSION HAZARD;
B)REACTIVITY; C)HEALTH HAZARD; D)SAFE HANDLING & USE INFORMATION; &
E)SPECIAL PRECAUTION SECTORS. REMOVE ALL IGNITION SOURCES. AVOID
BREATHING VAPORS. VENTILATE AREA . REMOVE SPILLED MATERIAL W/ INERT
ABSORBENT.

Handling and Storage Precautions:STORE CONTAINERS OUT OF SUN & AWAY
FROM HEAT, SPARKS & OPEN FLAMES. CLOSE CONTAINERS AFTER EACH USE.
CONSULT N.F.P.A. CODE FOR ADDITIONAL STORAGE REQS
Other Precautions:DONOT TAKE INTERNALLY. USE APPROVED BONDING &
GROUNDING PROCEDURES. OBSERVE LABEL PRECAUTIONS. KEEP CLOSURES
TIGHT & CONTAINER UPRIGHT TO PREVENT LEAKAGE. NEVER USE PRESSURE TO
EMPTY-DRUM IS NOT A PRE SSURE VESSEL.DONOT WELD OR FLAME CUT!

Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR DEVICE. SEE
YOUR SAFETY EQUIPMENT SUPPLIER FOR EVALUATION & RECOMMENDATION. IN
CONFINED AREAS, USE NIOSH/MSHA APPROVED AIRLINE RESPIRATOR OR HOOD.
Ventilation:PROVIDE SUFFICIENT VENTILATION TO KEEP VAPOR CONCENTRATION
BELOWS GIVEN TLV & LEL.FOR BAKING FINISHES, EXHAUST VAPORS.
Protective Gloves:NON-PERMEABLE TYPE FOR TASK AT HAND.
Eye Protection:TYPE DESIGNED TO PROTECT AGAINST SPLASH.
Other Protective Equipment:EYE BATH & SHOWER SHOULD BE AVAILABLE. USE
CHEMICAL RESISTANT APRON, BOOTS OR OTHER CLOTHING TO AVOID SKIN
CONTACT.
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING OR PERFORMING
OTHER DUTIES.
Supplemental Safety and Health
MFR CODE: CA97; HAZ CHAR CODE IS FOR OVERALL KIT, FOR THIS PART KEY1:
F2; PART 4 OF 9 PARTS PUT TOGETHER BY BOEING HELICOPTERS UNDER MFR
DRAWING 114RK651-2.

HCC:F2
Boiling Pt:=82.2C, 180.F
B.P. Text:180-498F(RG
Vapor Density:>1.
Spec Gravity:0.84
Evaporation Rate & Reference:(ETHER=1);SLOWER THAN
Percent Volatiles by Volume:92.2

Stability Indicator/Materials to Avoid:YES
NONE REASONABLY FORESEEABLE.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE, SMOKE
& OXIDES OF NITROGEN.(DURING EMERGENY,OVEREXPOSURE TO PRODUCTS MAY
AFFECT HEALTH)

Waste Disposal Methods:INCINERATE IN AN APPROVED FACILITY; DONOT
INCINERATE CLOSED CONTAINERS. DISPOSE OF I/A/W FEDERAL,STATE &
LOCAL POLLUTION CONTROL REQUIREMENTS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.