Product ID:ALKYD SEMIGLOSS ENAMEL GRAY 26187
MSDS Date:11/01/1988
FSC:8010
NIIN:00-616-0017
MSDS Number: BHDQZ

Emergency Phone: 404-509-4400

Info Phone: 404-622-1326

Cage: OO269

Telephone: 404 622 1326

Cage: OO269

MINERAL SPIRITS

CAS: 8032-32-4

Fraction By Weight: 35-40%

OSHA PEL 500 PPM

ACGIH TLV: 100 PPM

Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Health Hazards Acute and Chronic:ASPIRATION OF MATERIAL INTO THE LUNGS
CAN CAUSE CHEMICAL PNEUMONITIS WHICH CAN BE FATAL.
Effects of Overexposure:EYES:SEVERE IRRITN.REDNESS,TEARING,BLURRED
VISION,SKIN:PROLONGED/REPEATED CON- TACT-MODERATE
IRRITATION.DEFATTG,DERMATITAS,INHALATN:CAN CAUSE NASAL
RESPIRATORYIRRITATN,DIZZINESS,WKNESS,FATIGUE,NAUSEA
,HEADACHE,POSSIBLE UNCONSCSNSS EVENASPHYXIATION.CAN CAUSE
GASTROINTESTINAL IRRITATION,NAUSEA,VOMITING & DIARRHEA.
Medical Cond Aggravated by Exposure:NONE

First Aid:SKIN:THOROUGHLY WASH EXPOSED AREA W/SOAP AND WATER.GET MED
ATTN.IF IRRITATION PERSISTS.EYES;FLUSH W/LARGE AMTS OF
WATER,LIFTING UPPER/LOWER LIDS;GET MEDICAL
ATTENTION.INHALATION;REMOVE INDIVIDUAL T O FRESH AIR.IF BREATHING
DIFF.,ADMINISTER OXYGEN. IF BREATHING STOPPED:ADMINISTER ARTIFICIAL
RESPIRATION.KEEP PERSON WARM,QUIET,AND GET MEDICAL ATTENTION.

Flash Point Method:TCC
Flash Point:105F/40.56C
Upper Limits:1.0
Extinguishing Media:FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:WEAR S.C.B.A. WITH FULL FACEPIECE OPERATED IN
PRESSURE-DEMAND OR OTHER POSITIVE PRESSURE MODE WHEN FIGHTING
FIRES.WATER SPRAY MAY BE INEFFECTIVE.
Unusual Fire/Explosion Hazard:CONTAINERS MAY EXPLODE WHEN EXPOSED TO
EXTREME HEAT.VAPORS TRAVEL ALONG GROUND MAY BE IGNITED BY IGNITION
SOURCES AT LOCATIONS DISTANT FROM MATRL HANDLG POINT.

Spill Release Procedures:ELIMINATE ALL SOURCES OF IGNITION.FOR SMALL
SPILLSABSORB LIQUID ON PAPER OR OTHER ABSORBENT MATERIALFOR LG
SPILLS STOP AT SOURCE, DIKE AREA, PUMP LIQUID TO SALVAGE
TANK,REMAINING INTO CONTAINERS.

Handling and Storage Precautions:AVOID STORING IN HIGH TEMPERATURE OR
NEAR OPEN FLAME, STORE DRUM OUT OF SUN AND AWAY FROM HEAT.
Other Precautions:DO NOT STORE/USE NEAR HEAT, SPARK, FLAME. DONOT
WELD/FLAM-CUT AN EMPTY DRUM.THEYSHOULD BE GROUNDED/BONDED WHEN
POURING.AVOID BREATHING SANDING DUST.KEEP CLOSURETIGHT.CONTAINER
UPRIGHT TO PREVENT LEAKA GE.CONTNRS MAY BE HAZARDOUS WHEN EMPTY.

Respiratory Protection:NIOSH/MSHA APPROVED AIR SUPPLIED RESPIRATOR OR
NIOSH/MSHA RESPIRATORS.
Ventilation:MECHANICAL OR LOCAL EXHAUST
Protective Gloves:NEOPRENE OR NITRILE RUBBER
Eye Protection:CHEM.SPLASH GOGGLES,OTHER SAFETY GLASSES
Other Protective Equipment:IMPERVIOUS CLOTHING AND BOOTS
Work Hygienic Practices:AVOID REPEATED/PROLONGED CONTACT W/SKIN, WASH
HANDS BEFORE EATING OR USING WASHROOM. SMOKE IN SMOKING AREAS
ONLY.
Supplemental Safety and Health
IF RUN OFF OCCURS NOTIFY PROPER AUTHORITIES AS REQUIRED.

Boiling Pt:B.P. Text:300
Vapor Density:>AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:48.0

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:AVOID HIGH TEMPERATURE,OPEN FLAME,AND
SPARKS.
Hazardous Decomposition Products:MAY FORM CARBON DIOXIDE,CARBON
MONOXIDE,AND VARIOUS HYDRO- CARBONS.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL,STATE AND
FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.