Product ID:CLEANING AND LUBRICATING COMPOUND
MSDS Date:10/29/1990
FSC:6850
NIIN:00-003-1194
MSDS Number: BJFCF

CHEMTRONICS INC.

8125 COBB CENTER DRIVE
KENNESAW, GA 30144
US

Emergency Phone: 404-424-4888

Info Phone: 404-424-4888

Preparer: MICHAEL S. WATKINS

Cage: 0CG91

CHEMTRONICS INC.

KENNESAW, GA 30152 US

Telephone: 770-424-4888/800-645-5244

Cage: 0CG91

METHYL CHLOROFORM (1,1,1-TRICHLOROEHANE) (SARA III)

CAS: 71-55-6

RTECS: KJ2975000

Fraction By Weight: 65.00%

OSHA PEL 350 PPM/450 STEL

ACGIH TLV: 350 PPM/450STEL;9192

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

SILICONE FLUID

CAS: 93148-62-9

Fraction By Weight: 5.00%

DICHLORODIFLUOROMETHANE (SARA III)

CAS: 75-71-8

RTECS: PA8200000

Fraction By Weight: 35.00%

OSHA PEL 1000 PPM

ACGIH TLV: 1000 PPM; 9192

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE-EYES:SEVERE IRRITATION.
SKIN:IRRITATION. INHALATION:SUFFOCATION. INGESTION:IRRITATION OF
THE MOUTH AND GI TRACT. CHRONIC-EYES:SEVERE IRRITATION.
SKIN:IRRITATION. INHALATION:SUFFOCATION. INGESTIO N:IRRITATION.
Explanation of Carcinogenicity:NOT CONSIDERED TO BE CARCINOGENIC BY
NTP, IARC, OR OSHA.
Effects of Overexposure:EYES:EXTREME IRRITATION. SKIN:IRRITATION OR
REDDENING. INHALATION:LIGHT-HEADEDNESS, GIDDINESS, SHORTNESS OF
BREATH, HEADACHE, NARCOSIS, CARDIAC IRREGULARITIES, CIRCULATORY
SYSTEM DEPRESSION, POSSIBLE CNS DAMAGE, UNCONSCIOUSNESS OR DEATH.
INGESTION:NAUSEA AND VOMITING.
Medical Cond Aggravated by Exposure:CARDIOVASCULAR DISEASE.

First Aid:EYES:IMMEDIATELY FLUSH WITH WATER FOR 15 MIN. SEEK MEDICAL
ATTENTION. SKIN:FLUSH WITH WATER. INHALATION:REMOVE TO FRESH AIR
AND CALL A PHYSICIAN. IF NOT BREATHING, GIVE ARTIFICIAL
RESPIRATION. INGESTI ON:IF CONSCIOUS, GIVE LARGE QUANTITIES OF
WATER. DO NOT INDUCE VOMITING.*BECAUSE OF THE POSSIBLE INCREASED
RISK OF ELICITING CARDIAC DYSRYTHMIAS, CATECHOLINAMINE DRUGS SHOULD
ONLY BE AVOIDED.

Flash Point:NONE
Lower Limits:8.0
Upper Limits:15.0
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, OR DRY CHEMICAL.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:PRESSURIZED AEROSOL CONTAINERS MAY VENT,
RUPTURE OR EXPLODE AND ADD TO FLYING AND FALLING DEBRIS.
DECOMPOSITION MAY OCCUR.

Spill Release Procedures:VENTILATE AREA. REMOVE OPEN FLAMES OR OTHER
SOURCES OF IGNITION. COLLECT SPILLED PRODUCT WITH ABSORBENT
MATERIAL AND PLACE IN CLOSED STEEL DRUMS FOR PROPER DISPOSAL.

Handling and Storage Precautions:DO NOT STORE NEAR SOURCES OF HEAT, IN
DIRECT SUNLIGHT, OR WHERE TEMPERATURES EXCEED 120F. DO NOT PUNCTURE
OR DAMAGE CONTAINERS. ROTATE STOCK.
Other Precautions:VOMITING AND SUBSEQUENT ASPIRATION OF SOLUTION INTO
THE LUNGS CAN RESULT IN CHEMICAL PNEUMONIA AND PULMONARY EDEMA.

Respiratory Protection:NOT NORMALLY NECESSARY. IN CONFINED AREAS WITH
POOR VENTILATION, USE AN APPROVED RESPIRATOR.
Ventilation:GOOD VENTILATION TO KEEP EXPOSURE LIMITS BELOW TLV.
Protective Gloves:LINED NEOPRENE RUBBER
Eye Protection:CHEMICAL SPLASH GOGGLES
Other Protective Equipment:EYE BATH AND PROTECTIVE CLOTHING.
Work Hygienic Practices:NORMAL VENTILATION FOR STANDARD MANUFACTURING
PROCEDURES IS GENERALLY ADEQUATE. LOCAL EXHAUST SHOULD BE USED WHEN
NEEDED
Supplemental Safety and Health
WASH HANDS AFTER CONTACT WITH THIS MATERIAL. DO NOT EAT, DRINK, OR
SMOKE NEAR THIS PRODUCT.

HCC:T4
Boiling Pt:B.P. Text:165F,74C
Vapor Pres:120
Vapor Density:4.54
Spec Gravity:1.31
Evaporation Rate & Reference:>1(N-BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:COLORLESS LIQUID, ETHEREAL ODOR.

Stability Indicator/Materials to Avoid:YES
ALKALI AND ALKALINE EARTH METALS, POWDERED AL, ZN, BE, OR MG. ALSO
REACTS WITH STRONG CAUSTICS.
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, AND OPEN FLAMES
Hazardous Decomposition Products:HYDROCHLORIC ACID, HYDROFLUORIC ACID,
AND CARBONYL HALIDES.

Waste Disposal Methods:COMPLY WITH ALL FEDERAL, STATE, AND LOCAL
REGULATIONS. DO NOT PUNCTURE OR INCINERATE CANS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.