Product ID:AKZ FLUID VULCANIZING,CAT NO 760 THRU 767
MSDS Date:11/02/1988
FSC:2640
NIIN:00-138-8322
MSDS Number: BJJNH

Emergency Phone: 800-424-9300 (CHEMTREC)

Info Phone: 800-433-8324/OH 800-336-8324

Cage: 5U567

Telephone: 740-967-9015; 800-433-8324

Cage: 5U567

NO INGREDIENT FOR THIS FORMULATION_INGREDIENT

LD50 LC50 Mixture:N/K
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EXCESSIVE INHALATION OF VAPORS CAN
CAUSE ASPHYXIATION.ASPIRATION OF MATERIAL INTO THE LUNGS CAN CAUSE
CHEMICAL PNEUMONITIS WHICH CAN BE FATAL.OVEREXPOSURE TO COMPONENTS
HAS BEEN SUGGESTED AS A CAUSE O F THE FOLLOWING EFFECTS IN
HUMANS:LIVERABNORMALITIES,ANEMIA,LUNG DAMAGE.PROLONGED/REPEATED
CONT CAN CAUSE DERMATITIS.
Explanation of Carcinogenicity:TRICHLOROETHYLENE:INAD EVID FOR CARCIN
IN HUM/LTD EVID FOR CARCIN IN ANIM (IARC,1987).KNOWN CARCIN (CAL
PROP 65,1988).
Effects of Overexposure:EYES:SEVERE IRRIT,REDNESS,TEARING,BLURRED
VISION.SKIN:PRLNG/RPTD CONTACT-MODERATE
IRRIT,DEFATTING,DERMATITIS.INGESTION:GI
IRRIT,NAUS,VOMIT,DIARR,ASPIR INTO LUNGS CAN CAUSE CHEM PNEUMONITIS
WHICH CAN B E FATAL.INHALATION:EXCESSIVE INHAL OF VAP-NASAL & RESP
IRRIT,DIZZ,WEAK,FTG,NAUS,HEADACHE,POSSIBLE UNCON & ASPHYXIATION.
Medical Cond Aggravated by Exposure:N/K

First Aid:EYES:FLUSH W/ LGE AMTS OF H*2O,MINIMUM 15 MIN,WHILE LIFTING
LIDS OCCASNLLY .GET MED ATTN.SKIN:THORO WASH W/ SOAP & H*2O.REMOVE
CONTAM CLTHG.INGEST:DO NOT INDUCE VOMIT.KEEP WARM & QUIET.GET MED A
TTN.ASPIR OF VOMIT INTO LUNGS CAN BE FATAL.INHAL:MOVE TO FRESH
AIR.IF BRTHG DFCLT,GIVE O*2.IF BRTHG STOPPED,GIVE ARTF RESP.KEEP
WARM & QUIET.GET MED ATTN.DO NOT GIVE STIMULANTS.EPINEPHRINE/ (SUP
DA)

Lower Limits:N/K
Upper Limits:N/K
Extinguishing Media:WATER FOG.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS WITH A
FULL FACEPIECE OPERATED IN PRESSURE-DEMAND OR OTHER POSITIVE
PRESSURE MODE WHEN FIGHTING FIRES.
Unusual Fire/Explosion Hazard:VAP HEAVIER THAN AIR,MAY TRAVEL ALONG
GROUND/MOVE BY VENT & BE IGNITED BY HEAT,PILOT LIGHT,OTHER
FLAME/IGNIT SOURCE AT LOCATION DISTANT FROM USE POINT. (SUP DA)

Spill Release Procedures:SM SPILL-ABSORB LIQ ON PAPER/VERMICULITE/FLOOR
ABSORB/ABSORB MATL.TRANSFER TO HOOD.LG SPILL-ELIM ALL IGNIT SOURCES
(FLARE,FLAME,PILOT LIGHT,ELEC SPARK).PROT EQUIP REQ FOR
PERS,EXCLUDE ALL OTHERS.STOP SPILL AT SOURCE.DIKE.PUMP LIQ TO
SALVAGE (SUP DA)
Neutralizing Agent:N/K

Handling and Storage Precautions:CONTAINERS OF THIS MATERIAL MAY BE
HAZARDOUS WHEN EMPTIED DUE TO RETENTION OF PRODUCT RESIDUES
(VAPOR,LIQUID &/OR SOLIDS).OBSERVE ALL PRECAUTIONS.
Other Precautions:N/K

Respiratory Protection:IF PROD/COMPONENT EXCEEDS TLV,A NIOSH/MSHA
APPROVED RESP IS ADVISED.OSHA REGS ALSO PERMIT OTHER NIOSH/MSHA
RESP UNDER SPICIFIED CONDITIONS.SEE YOUR SAFETY EQUIPMENT
SUPPLIER.IMPLEMENT ENGINEERING/ADMI NISTRATIVE CONTROLS TO REDUCE
EXPOSURE.
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL &/OR LOCAL EXHAUST)
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
Protective Gloves:WEAR IMPENETRABLE GLOVES.
Eye Protection:CHEM SPLASH GOGG IAW OSHA (SEE ING 3)
Other Protective Equipment:IMPERVIOUS CLOTHING AND BOOTS TO PREVENT
REPEATED/PROLONGED SKIN CONTACT.
Work Hygienic Practices:LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
EXPLO HAZ:NEVER USE A WELDING/CUTTING TORCH NEAR DRUM (EVEN IF
EMPTY).PROD/RESIDUE CAN IGNITE EXPLO.FIRST AID PROC:EPHEDRINE MAY
ADVERSELY AFFECT HEART W/ FATAL RESULTS.SPILL
PROC:TANK.REMAINDER-TAKE UP ON ABSORB.SHOVEL TO CONTRS.WASTE DISP
METH:CLEAR HOOD.REMAINDER-DISP IAW APPLIC REGS.LRG SPILL-LIQ INCIN
(SEE ING 3)

Boiling Pt:B.P. Text:185F,85C
Melt/Freeze Pt:M.P/F.P Text:N/K
Decomp Temp:Decomp Text:N/K
Vapor Pres:60 MMHG
Vapor Density:>1 (AIR=1)
Spec Gravity:>1 (WATER=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:N/K
Appearance and Odor:N/K
Percent Volatiles by Volume:97

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS AND STRONG ALKALIES.
Stability Condition to Avoid:N/K
Hazardous Decomposition Products:N/K
Conditions to Avoid Polymerization:CANNOT OCCUR.

Waste Disposal Methods:DISP MUST BE IAW FED,STATE & LOC
REGS.COORDINATION W/ SUPPORTING INSTALLATION &/OR MACOM
ENVIRONMENTAL COORDINATION PRIOR TO DISP IS REC TO DETERMINE APPROP
DISP METH .SM SPILL:EVAP VOLAT PART I N HOOD.ALLOW SUFFICIENT TIME
FOR VAP TO(SUP DA)

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.