Product ID:TECH FLOW SEAL VULCANIZING FLUID
MSDS Date:11/02/1988
FSC:6850
NIIN:00F015319
MSDS Number: BKCYJ

TECHNICAL RUBBER COMPANY, INC.

200 EAST COSHOCTON STREET
JOHNSTOWN, OH 43031

Emergency Phone: (800) 433-8324

Info Phone: (614) 967-9015

Cage: 5U567

TECHNICAL RUBBER COMPANY

486 JOHNSTOWN, OH 43031-1041 US

Telephone: 740-967-9015; 800-433-8324

Cage: 5U567

TRICHLOROETHYLENE (SARA III)

CAS: 79-01-6

RTECS: KX4550000

Fraction By Weight: >95%

OSHA PEL 100 PPM/100 STEL

ACGIH TLV: 50 PPM/100,A5STEL;93

EPA Report Quantity: 100 LBS

DOT Report Quantity: 100 LBS

N-ETHYLCYCLOHEXYLAMINE

CAS: 5459-93-8

RTECS: GX1225000

Fraction By Weight: <1%

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:SKIN: IRRITATION, DEFATTING, &
DERMATITIS. EYE: IRRITATION, REDNESS, TEARING, & BLURRED VISION.
INHALATION: NASAL, RESPIRATORY IRRITATION, DIZZINESS, WEAKNESS,
FATIGUE, NAUSEA, HEADACHE, UNCONSCIOUSNE SS, & ASPHYXIATION.
INGESTION: GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING, DIARRHEA,
CHEMICAL PNEUMONITIS, & FATAL.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:SKIN: IRRITATION, DEFATTING & DERMATITIS. EYE:
IRRITATION, REDNESS, TEARING, & BLURRED VISION. INHALATION: LIVER
ABNORMALITIES, ANEMIA, & LUNG DAMAGE. INGESTION: GASTROINTESTINAL
IRRITATION, NAUSEA, V OMITING & DIARRHEA. ASPIRATION OF
MATERIALINTO THE LUNGS CAN CAUSE CHEMICAL PNEUMONITIS, & FATAL.

First Aid:EYES: FLUSH W/PLENTY OF WATER. SKIN: WASH W/SOAP & WATER.
INHALATION: REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF NEEDED. KEEP
WARM/QUIET. DON'T GIVE STIMULANTS. EPINEPHRINE/EPHEDRINE MAY
ADEVERSELY AFFEC T THE HEART W/FATAL RESULTS. INGESTION:DON'T
INDUCE VOMITING. KEEP WARM/QUIET. ASPIRATION INTO THE LUNGS MAY
CAUSE CHEMICAL PNEUMONITIS WHICH CAN BE FATAL. OBTAIN MEDICAL
ATTENTION IN ALL CASES.

Extinguishing Media:WATER FOG
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS W/A
FULL FACEPIECE OPERATED IN PRESSURE DEMAND OR OTHER POSITIVE
PRESSURE MODE WHEN FIGHTING FIRES.
Unusual Fire/Explosion Hazard:VAPORS >AIR, MAY TRAVEL ALONG THE GROUND
OR BE MOVED BY VENTILATION & IGNITED BY HEAT/PILOT
LIGHTS/FLAMES/IGNITION SOURCES AT AREAS AWAY FROM HANDLING POINT.

Spill Release Procedures:ABSORB LIQUID ON PAPER/VERMICULITE/FLOOR
ABSORBENT & TRANSFER TO HOOD. ELIMINATE IGNITION SOURCES. EVACUATE
AREA. STOP SPILL AT SOURCE, DIKE AREA TO PREVENT SPREADING, PUMP
LIQUID TO SALVAGE TANK. REM AINDER USE SAND/CLAY/EARTH & SHOVEL IN
CONTAINERS.

Handling and Storage Precautions:MAY BE HAZARDOUS WHEN EMPTIED, THEY
RETAIN PRODUCT RESIDUES (VAPOR, LIQUID, &/OR SOLIDS). AVOID SKIN
CONTACT.
Other Precautions:ALLOW VOLATILE PORTIONS TO EVAPORATE IN HOOD. ALLOW
SUFFICIENT TIME FOR VAPORS TO COMPLETELY CLEAR HOOD DUCT WORK.
NEVER USE WELDING OR CUTTING TORCH ON OR NEAR DRUM (EVEN EMPTY)
BECAUSE PRODUCT (EVEN JUST RESIDUE) CAN IGNITE EXPLOSIVELY.

Respiratory Protection:IF >TLV, USE A NIOSH/MSHA JOINTLY APPROVED AIR
SUPPLIED RESPIRATOR IN ABSENCE OF PROPER ENVIRONMENTAL CONTROL.
ENGINEERING OR ADMINISTRATIVE CONTROLS SHOULD BE IMPLEMENTED TO
REDUCE EXPOSURE.
Ventilation:PROVIDE SUFFICIENT MECHANICAL/LOCAL EXHAUST VENTILATION TO
KEEP Protective Gloves:IMPERMEABLE
Eye Protection:CHEMICAL SPLASH GOGGLES, SAFETY GLASSES
Other Protective Equipment:IMPERVIOUS CLOTHING & BOOTS.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
THE NATIONAL CANCER INSTITUTE HAS CONCLUDED FROM THE RESULT OF BIOASSAY
THAT TRICHLOROETHYLENE IS A LIVER CARCINOGEN WHEN GIVEN ORALLY TO
LABORATORY TEST MICE.

Boiling Pt:B.P. Text:185F
Vapor Pres:60
Vapor Density:>AIR
Spec Gravity:>WATER
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:97%

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS & STRONG ALKALIES.
Stability Condition to Avoid:HEAT, PILOT LIGHTS, FLAMES, IGNITION
SOURCES, FLARES, & ELECTRICAL SPARKS.

Waste Disposal Methods:SMALL SPILL: DISPOSE OF REMAINING MATERIAL IN
ACCORDANCE W/APPLICABLE REGULATIONS. LARGE SPILL: DESTROY BY LIQUID
INCINERATION W/OFF-GAS SCRUBBED. CONTAMINATED ABSORBENT MAY BE
DEPOSITED IN A LANDFILL IN ACCORDANCE W/LOCAL/STATE/FEDERAL
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.