Product ID:CLOSE TO GOLD SPRAY, GC-60
MSDS Date:07/25/1990
FSC:8010
NIIN:00N019309
MSDS Number: BLCTL

GENERAL PAINT & CHEMICAL

201 JANDUS ROAD
CARY, IL 60013
US

Emergency Phone: 800-228-5635

Info Phone: 708-639-5383

Cage: GENEA

GENERAL PAINT & CHEMICAL

CARY, IL 60013

Telephone: (312) 639-5383

Cage: GENEA

TOLUENE (SARA III)

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 24-28%

OSHA PEL 200 PPM/150 STEL

ACGIH TLV: 50 PPM; 9293

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

ACETONE (SARA III)

CAS: 67-64-1

RTECS: AL3150000

Fraction By Weight: 30-35%

OSHA PEL 1000PPM

ACGIH TLV: 750PPM/1000STEL;9293

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

80

CAS: 68476-86-8

Fraction By Weight: 27-32%

OSHA PEL 1000 PPM (MFR)

ACGIH TLV: 1000 PPM (MFR)

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE OVEREXP:SEVERE EYE IRRITATION,
DRYING OF SKIN, EXCESSIVE INHALATION, CAUSES HEADACHE, DIZZINESS &
NAUSEA. CHRONIC OVEREXP:REPORTS HAVE ASSOCIATED REPEATED &
PROLONGED OVEREXPOSURE TO SOLVENTS WI TH PERMANENT BRAIN & NERVOUS
SYSTEM DAMAGE.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE KNOWN TO GENERAL PAINT &
CHEMICAL CO.

First Aid:EYES:WASH W/FRESH WATER FOR AT LEAST 15 MINUTES. SKIN:WASH
W/WARM WATER & SOAP. INHAL:REMOVE TO FRESH AIR. APPLY ARTF RESP IF
NECESSARY. GET MD. INGEST:DO NOT INDUCE VOMIT. KEEP PERSON WARM &
QUIET. G ET MD.

Flash Point:<20F,<-7C
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, WATER FOG. OSHA CLASS 1A.
Fire Fighting Procedures:TREAT AS VOLAT FIRE. H20 SPRAY MAY BE
INEFTIVE. IF H20 SPRAY IS USED, FOG NOZZ ARE PREF. H20 MAY BE USED
TO COOL SEALED CNTNRS TO PVNT PRESS BUILD-UP(SUPDAT)
Unusual Fire/Explosion Hazard:CLOSED CNTNRS MAY EXPLODE WHEN EXPOSED TO
HEAT. ISOLATE FROM HEAT, SPARKS & OPEN FLAME.

Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. CONTAIN SPILL,
ABSORB LIQUID WITH CLAY, SAND OR FLOOR ABSORBENT. PREVENT RUN-OFF
TO SEWERS, STREAMS OR OTHER BODIES OF WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:HANDLE AS EXTREMELY FLAMM MATL. KEEP
AWAY FROM HEAT, SPKS & OPEN FLAMES. FOR STOR CNDTNS SEE OSHA
1910.106. DO NOT EXPOSE/STORE @ TEMPS OVER 120F.
Other Precautions:DO NOT TAKE INTERNALLY. AVOID PROLONGED CONTACT WITH
SKIN. PRODUCT SUBJ TO SARA TITLE III SEC 313.

Respiratory Protection:NIOSH/MSHA JOINTLY APPROVED AIR SUPPLIED
RESPIRATOR IF TLV LIMITS ARE EXCEEDED. NIOSH/MSHA APPROVED
MECHANICAL FILTER TO REMOVE SOLID AIRBORNE PARTICLE OF OVER-SPRAY
DURING SPRAY APPLICATION.
Ventilation:PROVIDE SUFFICIENT MECH (GEN &/OR LOC EXHST) VENT TO MAINT
EXPOS BELOW TLV. DO NOT USE IN BASEMENT/OTHER UNVENTED AREAS.
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:IMPERVIOUS CLTHG & BOOTS ARE SUGGESTED TO
PVNT PRLNG OR RPTD SKIN CONTACT. EMER EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING OR USING
BATHROOM. DO NOT REUSE CONTAMINATED CLOTHING.
Supplemental Safety and Health
FIRE FIGHT PROC:& POSSIBLE EXPLOSION & AUTO- IGNITION WHEN EXPOSED TO
HEAT OF FIRE.

HCC:V3
Boiling Pt:B.P. Text:<0F,<-18C
Vapor Pres:SEE INGRED
Vapor Density:>AIR
Evaporation Rate & Reference:SLOWER THAN ETHER.
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:90

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:ISOLATE FROM HEAT & OPEN FIRE,
TEMPERATURES ABOVE 120F.
Hazardous Decomposition Products:CO2 & CO FROM BURNING.

Waste Disposal Methods:CONTAMINATED ABSORBENT MAY BE DEPOSITED IN
LANDFILL I/A/W LOCAL, STATE & FEDERAL REGULATIONS. DISPOSE OF EMPTY
CANS IN NON-INCINERATED TRASH ONLY.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.