Product ID:SPAR VARNISH, 670
MSDS Date:05/23/1986
FSC:8010
NIIN:00N022305
MSDS Number: BLSGT

FARWEST PAINT MFG CO

4522 S 133 ST
TUKWILA, WA 98168
US

Emergency Phone: 206-941-1619

Info Phone: 206-244-8844

Cage: 6F266

FARWEST PAINT MANUFACTURING CO

TUKWILA, WA 98168 US

Telephone: 206-244-8844

Cage: 6F266

2.0

CAS: 64752-48-9

Fraction By Weight: 57-62%

OSHA PEL 500 PPM

ACGIH TLV: 500 PPM

2.0

Fraction By Weight: <1%

OSHA PEL 500 PPM

ACGIH TLV: 100 PPM

2.0

Fraction By Weight: <0.18%

OSHA PEL 500 PPM

ACGIH TLV: 100 PPM

ENGINEERING OR ADMINISTRATIVE CONTROLS SHOULD BE

RTECS: 9999999ZZ

ALKYD RESIN SOLUTION

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES: CAN CAUSE SEVERE IRRIT, REDNESS,
TEARING, BLURRED VISION. SKIN: PRLNGD/RPTD CONT CAN CAUSE MODERATE
IRRIT, DEFAT, DERMAT. INHAL: EXCESSIVE INHAL OF VAPS CAN CAUSE
NASAL & RESP IRRIT, DIZZ, WEAKN ESS, FATG, NAUS, HDCH, POSS UNCON &
EVEN ASPHY. INGEST: CAN CAUSE GI IRRIT, NAUS, VOMIT & DIARR. (SEE
EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: ASPIRATION OF MATERIAL INTO LUNGS CAN
CAUSE CHEMICAL PNEUMONITIS WHICH CAN BE FATAL.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:SKIN:THORO WASH EXPSD AREA W/SOAP & WATER. REMOVE CONTAM
CLTHG. LAUNDER CONTAM CLTHG BEFORE REUSE. EYES:FLUSH W/LRG AMTS OF
WATER, LIFTING UPPER & LOWER LIDS OCCASNLY. GET MD. INGEST:DO NOT
INDUCE VOM IT, KEEP PERSON WARM, QUIET & GET MD. ASPIR OF MATL IN
LUNGS DUE TO VOMIT CAN CAUSE CHEM PNEUM WHICH CAN BE FATAL.
INHAL:REMOVE INDIV TO FRESH AIR. IF BRTHG IS DFCLT, GIVE OXYGEN. IF
(SEE SUPP DATA)

Flash Point Method:TCC
Flash Point:100F,38C
Lower Limits:1.0%
Extinguishing Media:FOAM, DRY CHEMICAL, CO2.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NEVER USE NEAR OR AROUND WELDERS OR
CUTTING TORCHES. DRUM (EVEN EMPTY) BECAUSE PRODUCT (EVEN JUST
RESIDUE) CAN IGNITE EXPLOSIVELY.

Spill Release Procedures:LRG SPILL: ELIM ALL IGNIT SOURCES (FLARES,
FLAMES INCL PILOT LIGHTS, ELEC SPARKS). PERSONS NOT WEARING PROT
EQUIP SHOULD BE EXCLUDED FROM AREA OF SPILL UNTIL CLEAN-UP HAS BEEN
COMPLETED. STOP SPILL AT SOURCE, DIKE AREA OF SPILL TO PVNT (SUPP
DATA)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:CNTNRS OF THIS MATL MAY BE HAZ WHEN
EMPTIED, SINCE EMPTIED CNTNRS RETAIN PRODUCT RESIDUES (VAP, LIQ,
AND/OR SOLID), ALL HAZ PREC MUST BE OBSERVED.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.

Respiratory Protection:IF TLV OF THE PROD OR ANY COMPONENT IS EXCEEDED,
A NIOSH/MSHA APPROVED AIR SUPPLIED RESPIRATOR IS ADVISED IN ABSENCE
OF PROPER ENVIRONMENTAL CONTROL. OSHA REGS ALSO PERMIT OTHER
NIOSH/MSHA APPROVED RE SP UNDER SPECIFIED CNDTNS. (SEE ING 5)
Ventilation:PROVIDE SUFFICIENT MECH (GENERAL AND/OR LOCAL EXHST) VENT
TO MAINTAIN EXPOSURE BELOW TLV(S).
Protective Gloves:NITRILE RUBBER.
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:TO PREVENT REPEATED OR PROLONGED SKIN
CONTACT, WEAR IMPERVIOUS CLOTHING AND BOOTS.
Work Hygienic Practices:KEEP WORK AREA CLEAN & FREE FROM LEAKS &
SPILLS. ALWAYS WASH HANDS THORO W/SOAP & WATER BEFORE HNDLG FOOD &
DRINK.
Supplemental Safety and Health
FIRST AID PROC: BRTHG STOPS, GIVE ARTF RESP. KEEP PERSON, QUIET AND GET
MD. SPILL PROC: SPREADING, PUMP LIQ TO SALVAGE TANK. REMAINING LIQ
MAY BE TAKEN UP ON SAND, CLAY, EARTH, FLOOR ABSORB/ OTHER ABS ORB
MATL. PVNT RUN-OFF TO SEWERS, STREAMS, OR OTHER BODIES OF WATER. IF
RUN-OFF OCCURS, NOTIFY PROPER AUTHORITIES.

HCC:F4
Boiling Pt:B.P. Text:300F,149C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NIL
Appearance and Odor:CLEAR, YELLOW AMBER LIQUID WITH A MILD, SWEET
AROMATIC ODOR.
Percent Volatiles by Volume:<60

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:KEEP AWAY FROM OPEN FLAMES, SPARKS AND
HEAT. DO NOT WELD NEAR OR AROUND PRODUCT.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.

Waste Disposal Methods:DESTROY BY LIQUID INCINERATION. CONTAMINATED
ABSORBENT MAY BE DEPOSITED IN A LANDFILL IN ACCORDANCE WITH LOCAL,
STATE AND FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.