Product ID:SUPERGARD,SAE 10 W-30
MSDS Date:04/17/1989
FSC:9150
NIIN:00-186-6703
MSDS Number: BMBTB

CITGO PETROLEUM CORP

6100 S YALE BLDG 1 WARREN PL
TULSA, OK 74102
US

Emergency Phone: 318-491-6215/TULSTAR VENDOR 0F2M5

Info Phone: 918-495-5933

Cage: 7X110

CITGO PETROLEUM CORP

3758 TULSA, OK 74102 US

Telephone: 918-495-5933

Cage: 7X110

REFINED HEAVY PARAFFINIC DISTILLATES/REFINED PETROLEUM

CAS: 64741-88-4

Fraction By Weight: >75%

OSHA PEL 5 MG/M3 (OIL MIST)

ACGIH TLV: 5 MG/M3 (OIL MIST)

ANTIWEAR AGENTS (MAY CONTAIN ZINC DIALKYLDITHIOPHOSPHATE)

Fraction By Weight: <10%

NON-HAZARDOUS INGREDIENTS (INERT)/VI-IMPROVER

Fraction By Weight: <15%

LD50 LC50 Mixture:ORAL LD50 (RAT) IS > 15000 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE-EYE:PRACTICALLY
NON-IRRITANT.SKIN:SLIGHT
IRRITATION.INJECTION,SUBCUTANEOUS/INTRAMUSCULAR,MAY CAUSE
IRRITATION,ERYTHEMA,EDEMA.INHALED:MISTS OR FUMES MAY CAUSE
DIZZINESS,HEADACHE,NAUSEA,RESPIRATOR Y IRRITATION/CHEMICAL
PNEUMONITIS.ORAL:ONLY LARGE QUANTITIES MAY CAUSE DIARRHEA &
HEADACHE.CHRONIC-MAY CAUSE DRY SKIN.
Explanation of Carcinogenicity:USED MOTOR OIL HAS BEEN SHOWN TO CAUSE
SKIN CANCER IN MICE;BUT IS NOT EXPECTED TO CAUSE CANCER IN MAN IF
SKIN IS WASHED.
Effects of Overexposure:PRACTICALLY NON-IRRITANT TO EYES. SLIGHT SKIN
IRRITATION. INJECTION, SUBCUTANEOUS/INTRAMUSCULAR, MAY CAUSE SKIN
IRRITATION, ERYTHEMA, EDEMA. MISTS OR FUMES MAY CAUSE DIZZINESS,
HEADACHE, NAUSEA, RESPI RATORY IRRITATION/CHEMICAL PNEUMONITIS.ONLY
LARGE QUANTITIES IF INGESTED, MAY CAUSE DIARRHEA & HEADACHE.
Medical Cond Aggravated by Exposure:NONE

First Aid:GET MEDICAL ATTENTION IF SYMPTOMS PERSIST.SKIN:WASH WITH SOAP
& WATER.EYE:FLUSH WITH WATER FOR 15 MINUTES,HOLDING EYELIDS
OPEN.INHALED:REMOVE TO FRESH AIR & PROVIDE OXYGEN/CPR IF
NEEDED.ORAL:IF CONSCI OUS,INDUCING VOMITING & SEEK MEDICAL
ADVICE.NOTE TO PHYSICIAN:AT A SAYBOLT VISCOSITY OF 390 AT 100F,THE
ASPIRATION RISK IS LOW.IF >1 OZ INGESTED,EMESIS/LAVAGE MAY BE
CONSIDERED.TREAT INJECTED QUICKLY.

Flash Point Method:COC
Flash Point:428F,220C
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL. WATER MAY CAUSE FROTHING.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:MAY FORM WATER VAPOR, CARBON MONOXIDE,
CARBON DIOXIDE.

Spill Release Procedures:SMALL SPILLS:TAKE UP WITH NONCOMBUSTIBLE
ABSORBENT SUCH AS FULLERS EARTH OR SAND & PLACE INTO CONTAINER FOR
DISPOSAL.LARGE SPILLS:CONTAIN IN EARTHEN DIKES FOR LATER
RECOVERY.CONTROL IGNITION SOURCES A ROUND SPILL AREA.REPORT TO
APPROPRIATE AUTHORITIES

Handling and Storage Precautions:STORAGE-STORE IN COOL,DRY,VENTILATED
AREA IN CLOSED CONTAINER AWAY FROM HEAT,FLAMES & OXIDIZERS.
Other Precautions:DO NOT GENERATE MISTS. AVOID BREATHING VAPORS OR
MISTS. AVOID EYE OR SKIN CONTACT. WASH WITH SOAP AND WATER BEFORE
EATING OR DRINKING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
THIS IS AN OIL. KEEP OUT OF SURFACE WATERS AND SEWERS.

Respiratory Protection:IN SITUATION WHERE VAPOR CONCENTRATIONS MAY
EXCEED THE RECOMMENDED EXPOSURE LIMITS, A NIOSH-APPROVED ORGANIC
VAPOR CARTRIDGE RESPIRATOR SHOULD BE WORN. USE SELF-CONTAINED
SUPPLIED-AIR RESPIRATOR FOR E MERGENCIES.
Ventilation:USE ADEQUATE VENTILATION TO KEEP OIL MISTS OF THIS MATERIAL
BELOW APPLICABLE STANDARD(S).
Protective Gloves:POLYMER, IF DIRECT CONTACT EXPECTED.
Eye Protection:CHEMICAL SPLASH GOGGLES
Other Protective Equipment:EYE WASH STATION, BODY-COVERING WORK CLOTHE
Work Hygienic Practices:DO NOT TAKE INTERNALLY. LAUNDER SOILED WORK
CLOTHES BEFORE REUSE.
Supplemental Safety and Health

HCC:V6
Boiling Pt:B.P. Text: 760F,404C
Vapor Pres:NEGLIGIBLE
Vapor Density:>1
Spec Gravity:0.89
Evaporation Rate & Reference:<1 (N-BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:AMBER OIL, SLIGHT PETROLEUM ODOR
Percent Volatiles by Volume:NEGLIG

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS SUCH AS CHLORATES, NITRATES, PEROXIDES, ETC.,
STRONG ACIDS, CAUSTICS
Stability Condition to Avoid:HIGH HEAT, FLAMES
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
TRACES OF OXIDES OF CALCIUM, MAGNESIUM, PHOSPHORUS, SULFUR AND ZINC

Waste Disposal Methods:PLACE CONTAMINATED MATERIALS IN DISPOSABLE
CONTAINERS AND DISPOSE OF IN A MANNER CONSISTENT WITH ALL
APPLICABLE LOCAL, STATE AND FEDERAL LAWS AND REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.