Product ID:PIGMENTED OIL SEALER-WHITE
MSDS Date:10/04/1989
FSC:8010
NIIN:00-165-8569
MSDS Number: BMPYN

DURON INC

10406 TUCKER ST
BELTSVILLE, MD 20705
US

Emergency Phone: 800-228-5635

Info Phone: 301-937-4600

Cage: 75734

DURON INC AMERICAN DIV

BELTSVILLE, MD 20705-2201 US

Telephone: 301-937-4600

Cage: 55652

POLYMERIZED SYNTHETIC OLEORESINOUS COMPLEX

Fraction By Weight: 1.00%

* AS THIS MATERIAL IS POLYMERIZED, IT CAN BE LOOKED UPON AS

RTECS: 9999999ZZ

PRE-WETTED PIGMENT EXTENDER COMPOSITE *

Fraction By Weight: 1.00%

PETROLEUM DISTILLATE (VAPOR PRESSURE 4 MM HG) (LEL 0.9 %)

CAS: 64742-65-0

RTECS: PY8038500

Fraction By Weight: 10.00%

OSHA PEL 100 PPM

ACGIH TLV: 525 MG/CUM

3.1 POUNDS/GALLON (372 GRAMS/LITER)

RTECS: 9999999VO

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:EYES: IRRIT. SKIN: IRRIT. INHAL:
NASAL, RESP IRRIT, ANESTHETIC, CENTRAL NERV SYS EFFECTS, DIZZY,
WEAK, FATIGUE, NAUSEA, HEADACHE. NEUROLOGICAL DAMAGE. SWALLOWING:
GASTROINTESTINAL IRRIT, NAUSEA, VOMIT ING, DIARRHEA. ASPIRATION OF
MATERIAL INTO LUNGS CAN CAUSE CHEMICAL PNEUMONITIS WHICH CAN BE
FATAL. REPEAT/PROLONGED
Explanation of Carcinogenicity:PIGMENT COMPOSITE MAY INCLUDE
CRYSTALLINE SILICA (IARC CLASS 2A CARCINOGEN). IN WETTED STATE,
DUST (HZD PART) UNLIKELY.
Effects of Overexposure:OVEREXPOSURE TO SOLVENTS MAY CAUSE PERMANENT
BRAIN & NERVOUS SYSTEM DAMAGE. CONCENTRATING & INHALING PRODUCT MAY
BE HARMFUL/FATAL. STUDIES HAVE SHOWN THAT MANY PETROLEUM
HYDROCARBONS & SYNTHETIC LUBRI CANTS POSE POTENTIAL HUMAN HEALTH
RISK WHICH MAY VARY FROM PERSON TO PERSON.

First Aid:EYES: FLUSH WITH LARGE QUANTITIES OF WATER 15 MIN, LIFTING
EYELIDS. SKIN: WASH W/SOAP & WATER 15 MIN. REMOVE CONTAM CLOTH.
INHAL: SEEK AIR FREE OF VAPORS. IF BREATHING STOPS, BEGIN AFTIF
RESPIRATION & SEEK IMMED MED ATTN. IF SWALLOWED: DO NOT INDUCE
VOMITING. KEEP PERSON WARM, QUIET AND GET MEDICAL ATTN. ASPIRATION
OF MATERIAL INTO LUNGS DUE TO VOMITING CAN CAUSE CHEM PNEUMONITIS
(CAN BE FATAL).

Flash Point:100 TO 110 F
Lower Limits:0.9%
Extinguishing Media:CLASS B EXTINGUISHER, USE FOAM, CARBON DIOXIDE, DRY
CHEMICAL.
Fire Fighting Procedures:VAPORS HEAVIER THAN AIR. MAY TRAVEL ALONG
GROUND, TRAVEL TO DISTANT IGNIT SOURCE. NEVER USE WELD/CUT TORCH
ON/NEAR CNTNR (EVEN EMPTY) AS PRODUCT MAY IGNITE.
Unusual Fire/Explosion Hazard:USE SCBA. WTR MAY BE UNSUITABLE AS AN
EXTINGUISHING MEDIA, BUT HELPFUL IN KEEPING ADJACENT CNTNRS COOL.
AVOID SPREADING BURNING LIQ WITH WATER USED FOR COOLING.

Spill Release Procedures:ELIMINATE IGNIT SOURCES. EVACUATE AREA OF
UNPROTECTED PERSONNEL. STOP SPILL AT SOURCE. DIKE. PUMP LIQ TO
STORAGE TANK. REMAINING LIQ MAY BE TAKEN UP W/ABSORBENT MAT'L &
SHOVEL INTO CONTAINERS. PREVENT RUN-OFF TO SEWERS, STREAMS & OTHER
WATER BODIES.

Handling and Storage Precautions:KEEP CNTNRS COOL, DRY, FROM IGNITION
SOURCES. USE & STORE PROD W/ADEQUATE VENTILATION. CNTNRS OF MAT'L
MAY BE HAZARDOUS WHEN EMPTIED.
Other Precautions:EMPTIED CNTNRS RETAIN RESIDUES (VAPORS, LIQUID,
SOLID), ALL HAZARDOUS PRECAUTIONS MUST BE OBSERVED. MINIMIZE
EXPOSURE TO LIQUIDS, VAPORS, MISTS, FUMES. READ/ADHERE TO ALL
WARNING STATEMENTS. KEEP OUT OF REACH OF CHILDREN.

Respiratory Protection:THE USE OF RESPIRATORY PROTECTION DEPENDS ON
VAPOR CONCENTRATION ABOVE THE TIME WEIGHTED TLV: USE NIOSH APPROVED
CARTRIDGE RESPIRATOR.
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL) AND/OR LOCAL
EXHAUST VENTILATION TO MAINTAIN EXPOSURE BELOW TLV.
Protective Gloves:WEAR RESISTANT GLOVES SUCH AS: BUNA-N
Eye Protection:SFTY GLASSES, CHEM GOGGLES, FACE SHIELDS
Other Protective Equipment:TO PREVENT REPEATED OR PROLONGED SKIN
CONTACT, WEAR IMPERVIOUS CLOTHING AND BOOTS.
Supplemental Safety and Health

HCC:F4
Boiling Pt:B.P. Text:313 TO 393F
Vapor Density:> AIR
Evaporation Rate & Reference:SLOWER THAN ETHER.
Percent Volatiles by Volume:47.3

Stability Indicator/Materials to Avoid:YES
THIS PRODUCT IS INCOMPATIBLE WITH STRONG OXIDIZING AGENTS, STRONG ACIDS
OR BASES AND SELECTED AMINES.
Stability Condition to Avoid:N/K 21FEB92
Hazardous Decomposition Products:THERMAL DECOMPOSITION IN THE PRESENCE
OF AIR MAY YIELD CARBON MONOXIDE AND/OR CARBON DIOXIDE.

Waste Disposal Methods:DISPOSE OF PRODUCT IN ACCORDANCE WITH LOCAL,
COUNTY, STATE AND FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.