Product ID:ALKYD SEMI GLOSS ENAMEL
MSDS Date:11/01/1988
FSC:8010
NIIN:00-180-6274
MSDS Number: BNKPJ

Emergency Phone: 404-589-4400 POISON CONTROL CENTER

Info Phone: 404-622-1326

Cage: OO269

Telephone: 404 622 1326

Cage: OO269

MINERAL SPIRITS (VAPOR PRESSURE 2.0 MM HG)

CAS: 8032-32-4

RTECS: OI6180000

Fraction By Weight: 35-40%

OSHA PEL 500 PPM

ACGIH TLV: 100 PPM

LD50 LC50 Mixture:NO
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Health Hazards Acute and Chronic:N/K ELECTRIC MOTORS, STATIC DISCHARGE
OR OTHER IGNITION SOURCES AT LOCATIONS DISTANT FROM MATERIAL
HANDLING POINT. OVEREXPOSURE TO DECOMPOSITION PRODUCTS MAY CAUSE A
HEALTH HAZARD. CONTAINERS MAY EXPL ODE WHEN EXPOSED TO EXTREME
HEAT.
Effects of Overexposure:EYE: SEVERE IRRIT/REDNESS/TEARING/BLURRED
VISION. SKIN: PROLONG/REPEAT CONTACT-MOD
IRRIT/DEFATTING/DERMATITIS. INHAL: EXCESS INHAL OF
VAPORS-NASAL/RESP IRRIT/DIZZINESS/WEAKNESS/FATIGUE/NAUSEA/ HEADACH
E/POSSIBLE UNCONSCIOUSNESS/ASPHYXIATION. INGEST: GASTROINTESTINAL
IRRIT/NAUSEA/VOMITING/DIARRHEA. ASPIR OF MAT'L INTO
Medical Cond Aggravated by Exposure:NONE EXPECTED. THE LUNGS CAN CAUSE
CHEMICAL PNEUMONITIS WHICH CAN BE FATAL.

First Aid:SKIN: WASH W/SOAP & WTR. RMV CONTAM CLOTHES/ LAUNDER BEFORE
REUSE. GET MED AID IF IRRIT PERSISTS. EYE: FLUSH W/LG AMTS OF WTR,
LIFT LIDS OCCASIONALLY, GET MED AID. INGEST: DO NOT INDUCE
VOMITING, KEEP PERSON WARM/QUIET, GET MED AID. ASPIR OF MAT'L INTO
LUNGS FROM VOMITING CAN CAUSE CHEM PNEUMONITIS (FATAL). INHAL: RMV
TO FRESH AIR. IF BREATHING DIFFICULT-ADMIN OXYGEN, IF STOPPED-GIVE
ARTIFICIAL

Flash Point Method:TCC
Flash Point:105F,41C
Lower Limits:1.0
Extinguishing Media:FOAM, CO2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR SCBA WITH A FULL FACEPIECE OPERATED IN
PRESSURE-DEMAND OR OTHER POSITIVE PRESSURE MODE WHEN FIGHTING
FIRES. WATER SPRAY MAY BE INEFFECTIVE.
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR AND MAY
TRAVEL ALONG THE GROUND OR MAY BE MOVED BY VENTILATION AND IGNITED
BY PILOT LIGHTS, OTHER FLAMES, SPARKS, HEATERS, SMOKING,

Spill Release Procedures:ELIM ALL SOURCES OF IGNIT (FLARE/FLAME/PILOT
LIGHT/ELECT SPARK). SM: ABSORB LIQ ON PAPER/VERMICULITE/FLOOR
ABSORB/OTHER ABSORB & TRANSFER TO HOOD. LG: EVAC AREA UNTIL
CLEAN-UP COMPLETE. STOP SPILL AT SOURCE, DIKE AREA TO PREVENT
SPREADING,PUMP LIQ#
Neutralizing Agent:N/K RESPIRATION. KEEP PERSON WARM, QUIET AND GET MED
ATTENTION.

Handling and Storage Precautions:AVOID STORING IN HIGH TEMPERATURE OR
NEAR OPEN FLAME. STORE DRUM OUT OF SUN AND AWAY FROM HEAT.
Other Precautions:DONT WELD/FLAME-CUT EMPTY DRUM. GROUND/BOND DRUM WHEN
POURING. AVOID BREATHING SANDING DUST. KEEP CNTNR CLSD
TIGHT/UPRIGHT TO PREVENT LEAKAGE. DONT STORE/USE NEAR
HEAT/SPARK/FLAME. MAY BE HAZARDOUS WH EN EMPTIED AS CNTNRS RETAIN
RESIDUES##

Respiratory Protection:IF TLV EXCEEDED-NIOSH/MSHA JOINT APPROV AIR
SUPPLIED RESP IS ADVISED. OSHA REG PERMITS OTHER NIOSH/MSHA RESP
UNDER SPECIFIED CONDITIONS. (SEE SFTY EQUIP SUPPLIER)
ENGINEERING/ADMINISTRATIVE CONTROLS S HOULD BE IMPLEMENTED TO
REDUCE EXPOSURE.
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL AND/OR LOCAL EXHAUST
VENTILATION) TO MAINTAIN EXPOSURE BELOW TLV(S).
Protective Gloves:NITRILE RUBBER, NEOPRENE.
Eye Protection:CHEM SPLASH GOGGLES, SAFETY GLASSES.
Other Protective Equipment:WEAR IMPERVIOUS CLOTHING AND BOOTS.
Work Hygienic Practices:AVOID REPEATED OR PROLONGED CONTACT WITH SKIN,
WASH HANDS BEFORE EATING OR USING WASHROOM, SMOKE IN SMOKING AREAS
ONLY.
Supplemental Safety and Health
##(VAPOR, LIQUID, AND/OR SOLID), ALL HAZARD PRECAUTIONS GIVEN IN THE
DATA SHEET MUST BE OBSERVED.

HCC:F4
Boiling Pt:B.P. Text:300 F
Vapor Density:> THAN AIR
Spec Gravity:11.06 (+/-) 0.1
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:48.0

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:AVOID HIGH TEMPERATURES, OPEN FLAME AND
SPARKS.
Hazardous Decomposition Products:MAY FORM TOXIC MATERIALS SUCH AS:
CARBON DIOXIDE, CARBON MONOXIDE, AND VARIOUS HYDROCARBONS.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS. #TO SALVAGE TANK. REMAINING INTO CNTNRS.
PREVENT RUN-OFF TO SEWERS, STREAMS, OTHER BODIES OF WATER. IF
RUN-OFF OCCURS, NOTIFY PROPER AUTH ORITIES AS REQUIRED, THAT A
SPILL HAS OCCURED.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.