Product ID:TECH RUB-O-MATIC
MSDS Date:10/01/1985
FSC:2640
NIIN:00-052-6724
MSDS Number: BPZGT

TECHNICAL RUBBER COMPANY,INC.

200 EAST COSHOCTON STREET
JOHNSTOWN, OH 43031
US

Emergency Phone: 800-424-9300 (CHEMTREC)

Info Phone: 614-967-9015,800-433-8324

Cage: 5U567

TECHNICAL RUBBER COMPANY

486 JOHNSTOWN, OH 43031-1041 US

Telephone: 740-967-9015; 800-433-8324

Cage: 5U567

CHLORINATED HYDROCARBON (TRADE SECRET)

Fraction By Weight: 10-30%

AROMATIC HYDROCARBON (TRADE SECRET)

CAS: 70995-17-8

Fraction By Weight: >60%

CHLORINATED HYDROCARBON (TRADE SECRET)

Fraction By Weight: 1-10%

LD50 LC50 Mixture:NOT KNOWN
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:PROLONGED OR REPEATED CONTACT CAN
CAUSE DERMATITIS.OVEREXPOSURE TO COMPONENT CAN RAISE LEVEL OF
CARBON MONOXIDE IN BLOOD CAUSING CARDIOVASCULAR STRESS.OVEREXPOSURE
TO COMPONENTS HAS APPARENTLY BEEN FO UND AS CAUSE OF CARDIAC &
LIVER ABNORMALITY,KIDNEY,LUNG, BRAIN,& SPLEEN DAMAGE.
Explanation of Carcinogenicity:PERCHLOROETHYLENE:INADE EVID FOR CARCIN
IN HUM,SUFF EVID FOR CARCIN IN ANIMALS (IARC,1987).SUSPECTED HUMAN
(SEE SUPP)
Effects of Overexposure:EYES:SEVERE IRRITATION,REDNESS,TEARING, BLURRED
VISION.SKIN:PROLONGED/REPEATED CONTACT CAN CAUSE MODERATE
IRRITATION,DEFATTING.INGESTION:CAN CAUSE GI
IRRITATION,NAUSEA,VOMITING,& DIARRHEA.ASPIRATION O F MATERIAL INTO
LUNGS CAN CAUSE CHEMICAL PNEUMONITIS WHICH CAN BE FATAL.
Medical Cond Aggravated by Exposure:NOT KNOWN

First Aid:EYES:FLUSH W/ LARGE AMTS OF WATER FOR AT LEAST 15 MIN,LIFTING
EYE LIDS OCCASNLY.GET MD. SKIN:THOROUGHLY WASH EXPOSED AREA W/ SOAP
& WATER.INGEST:DO NOT INDUCE VOMITING,KEEP PERS WARM,QUIET,& GET
MD. I NHAL:IF AFFECTED,REMOVE TO FRESH AIR.IFBRTHING IS
DIFFICULT,ADMIN ARTF RESP.KEEP PERS WARM,QUIET & GET MD.DO NOT GIVE
STIMULANTS.EPINEPHRINE/ EPHEDRINE MAY ADVERSELY AFFECT HEART W/
FATAL RESULTS.

Flash Point Method:PMCC
Flash Point:>200F,>93C
Lower Limits:NOT KNOWN
Upper Limits:NOT KNOWN
Extinguishing Media:USE WATER FOG,CARBON DIOXIDE,DRY CHEMICAL,OR
REGULAR FOAM.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS WITH A
FULL FACE-PIECE OPERATED IN PRESSURE-DEMAND OR OTHER POSITIVE
PRESSURE MODE WHEN FIGHTING FIRES.
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR & MAY TRAVEL
ALONG GROUND OR BE MOVED BY VENTILATION & IGNITED BY HEAT,PILOT
LIGHTS, OTHER FLAMES & IGNITION SOURCES AT (SEE SUPP)

Spill Release Procedures:SMALL SPILL:ABSORB LIQ ON ABSORBENT & TRANSFER
TO HOOD.LARGE:ELIMINATE IGNITION SOURCES.STOP SPILL AT SOURCE,DIKE
AREA,PUMP LIQ TO SALVAGE TANK.REMAINING LIQ TAKEN UP ON
SAND,CLAY,EARTH, FLOOR ABSORBE NT,OR OTHER ABSORBENT MATL &
SHOVELED INTO CONTRS.
Neutralizing Agent:NOT KNOWN

Handling and Storage Precautions:CONTAINERS OF THIS MATERIAL MAY BE
HAZARDOUS WHEN EMPTIED.SINCE EMPTY CONTAINERS RETAIN PRODUCT
RESIDUES,ALL HAZARDOUS PRECAUTIONS MUST BE OBSERVED.
Other Precautions:NOT KNOWN

Respiratory Protection:IF TLV IS EXCEEDED,NIOSH/MSHA APPROVED AIR
SUPPLIED RESPIRATOR IS ADVISED.OSHA REGS ALSO PERMIT OTHER
NIOSH/MSHA REPIRATORS UNDER SPECIFIED CONDITIONS.ENGINEERING/ADMIN
CONTROLS SHOULD BE IMPLEMENTED TO REDUCE EXPOSURE.
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL &/OR LOCAL EXHAUST)
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
Protective Gloves:POLYVINYL ALCOHOL OR NITRILE RUBBER
Eye Protection:CHEMICAL SPLASH GOGGLES
Other Protective Equipment:WEAR IMPERVIOUS CLOTHING AND BOOTS TO
PREVENT REPEATED OR PROLONGED SKIN CONTACT.
Work Hygienic Practices:REMOVE CONTAMINATED CLOTHING.LAUNDER
CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
PRODUCT CONTAINS PERCHLOROETHYLENE.EXPLO HAZ:LOCATIONS DISTANT FROM
MATL HANDLING POINT.NEVER USE WELDING OR CUTTING TORCH ON OR NEAR
DRUM (EVEN EMPTY) BECAUSE PRODUCT (EVEN JUST RESIDUE) CAN IGNITE E
XPLOSIVELY.EXPLAN OF CARCIN:CARCINOGEN.KNOWN ANIMAL CARCINOGEN
(NTP,1991).KNOWN TO CAUSE CANCER (CAL PROP 65,1987).

HCC:T4
Boiling Pt:B.P. Text:103F,39C
Melt/Freeze Pt:M.P/F.P Text:NOT KNOWN
Decomp Temp:Decomp Text:NOT KNOWN
Vapor Pres:340 MMHG
Vapor Density:>1
Spec Gravity:>1 (WATER=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NOT KNOWN
Appearance and Odor:LIQUID
Percent Volatiles by Volume:100

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NOT KNOWN
Hazardous Decomposition Products:NOT KNOWN
Conditions to Avoid Polymerization:CAN NOT OCCUR.

Waste Disposal Methods:DISP MUST BE IAW FED,STATE,& LOCAL
REGS.COORDINATE W/ SUPPORT INSTALL &/OR MACOM ENVIRON OFC PRIOR TO
DISP .SMALL SPILL: ALLOW VOLAT PORTIONS TO EVAP IN
HOOD.LARGE:DESTROY BY LIQ INCIN W/ OFF-GA S SCRUBBED.CONTAM
ABSORBENT DEPOSITED IN LANDFILL.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.