Product ID:MIL-L-19538C CL2 GRAY 36622 PC 700A85
MSDS Date:06/19/1988
FSC:8010
NIIN:00-900-0739
MSDS Number: BRNPW

GRIGGS PAINT

3602 SOUTH 16TH PLACE
PHOENIX, AZ 85040-1319
US

Emergency Phone: 602-243-3293 800-424-9300(CHEMTREC)

Info Phone: 602-243-3293

Preparer: ROBERT COMMISSO

Cage: DO312

GRIGGS PAINT

PHOENIX, AZ 85040-1319 US

Telephone: 602-243-3293

Cage: DO312

METHYL ISOBUTYL KETONE (SARA 313) (VAPOR PRESSURE 16.0 MM

CAS: 108-10-1

RTECS: SA9275000

Fraction By Weight: 2%

OSHA PEL 100 PPM/75 STEL

ACGIH TLV: 50 PPM/75 STEL; 9293

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

METHYL ETHYL KETONE (2-BUTANONE) (SARA 313) (VAPOR PRESSURE

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 10%

OSHA PEL 200 PPM

ACGIH TLV: 200 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

TITANIUM DIOXIDE

CAS: 13463-67-7

RTECS: XR2275000

Fraction By Weight: 20 - 25%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST; 9293

MAGNESIUM SILICATE

CAS: 14807-96-6

RTECS: MW2700000

Fraction By Weight: 10%

ACGIH TLV: 2 MG/M3

XYLENE (SARA 313) (VAPOR PRESSURE 5.1 MM HG @ 68F)

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: 8%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

CELLULOSE NITRATE

CAS: 9004-70-0

RTECS: FJ6000000

Fraction By Weight: 10%

DIOCTYL PHTHALATE (SARA 313) (VAPOR PRESSURE 1.2 MM HG @

CAS: 117-81-7

RTECS: TI0350000

Fraction By Weight: 2%

OSHA PEL 5 MG/M3

ACGIH TLV: 5 MG/M3

EPA Report Quantity: 100 LBS

DOT Report Quantity: 100 LBS

CYCLOHEXANONE (SARA 313) (VAPOR PRESSURE 2.0 MM HG @ 68F)

CAS: 108-94-1

RTECS: GW1050000

Fraction By Weight: 1%

OSHA PEL S, 50 PPM

ACGIH TLV: S, 25 PPM; 9293

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

ACRYLIC POLYMER (VAPOR PRESSURE 30.0 MM HG @ 68F)

Fraction By Weight: 15%

OSHA PEL 300 PPM

3.88 LB/GL; 464 G/L

RTECS: 9999999VO

Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:YES
Health Hazards Acute and Chronic:DIRECT CONTACT TO EYES MAY CAUSE
IRRITATION. REPEATED/PROLONGED CONTACT MAY CAUSE SKIN IRRITATION.
INHALATION OF HIGH CONCENTRATIONS OF VAPORS MAY LEAD TO LUNG
CHANGES, NAUSEA, VOMITING, COUGH, PULMON ARY IRRITATION, & CNS
DEPRESSION. INGESTION MAY CAUSE GASTROINTESTINAL DISTURBANCES.
ASPIRATION OF THIS PRODUCT INTO....
Effects of Overexposure:...THE LUNGS MAY CAUSE PNEUMONITIS, PULMONARY
EDEMA & HEMORRAGE. BREATHING OF HIGH VAPOR CONCENTRATIONS MAY CAUSE
DROWSINESS, DIZZINESS, FATIGUE, FOLLOWED BY COMA. EYE: DIRECT
CONTACT &/OR CONTACT W/V APORS MAY CAUSE IRRITATION. SKIN:
REPEATED/PROLONGED CONTACT MAY CAUSE IRRITATION, DERMATITIS. MAY BE
ABSORBED THRU SKIN
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH PRE-EXISTING
DISEASES IN OR HISTORY OF AILMENTS INVOLVING SKIN CENTRAL NERVOUS
SYSTEM (CNS) LIVER & KIDNEY.

First Aid:EYE CONTACT: IMMEDIATELY FLUSH WITH LARGE AMOUNTS OF WATER
FOR 15 MINUTES. SEEK MEDICAL AID. SKIN: WASH THOROUGHLY WITH SOAP &
WATER. SEEK MEDICAL AID IF IRRITATION PERSISTS. INGESTION:
IMMEDIATELY SE EK MEDICAL AID. DO NOT INDUCE VOMITING.DO NOT
ATTEMPT TO GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.

Flash Point Method:TOC
Flash Point:26.0F,-3.3C
Autoignition Temp:Autoignition Temp Text:474 F
Lower Limits:0.3 %
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, WATER FOG
Fire Fighting Procedures:APPROVED GAS MASK REQUIRED FOR FIRE FIGHTING
PERSONNEL. WATER MAY BE INEFFECTIVE. WATER MAY BE USED TO COOL
CONTAINERS. IF WATER USED, FOG NOZZLES ARE PREFERRED
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM HEAT, ELECTRICAL EQUIPMENT, SPARKS, & OPEN FLAME. CLOSED
CONTAINERS MAY EXPLODE WHEN EXPOSED TO HEAT.

Spill Release Procedures:STOP LEAK IF NO RISK INVOLVED. REMOVE ALL
SOURCES OF IGNITION. STAY UPWIND. ABSORB WITH INERT MATERIAL. FLUSH
AREA WITH WATER. VENTILATE AREA FOR AT LEAST 24 HOURS OR UNTIL AREA
HAS BEEN DECLARED SAFE .

Handling and Storage Precautions:KEEP CONTAINERS CLOSED & UPRIGHT TO
PREVENT LEAKAGE. AVOID FLAMES, WELDING, OPEN PILOT LIGHTS, ETC.
AVOID BREATHING OF VAPORS & SPRAY MISTS.
Other Precautions:AVOID SKIN & EYE CONTACT. MAINTAIN GOOD PERSONAL
HYGIENE. DO NOT USE IN CONFINED AREAS, TANK OR PIT, WITHOUT
ADEQUATE VENTILATION.

Respiratory Protection:IF VENTILATION DOES NOT MAINTAIN INHALATION
EXPOSURES BELOW TLV(PEL), USE MSHA/NIOSH APPROVED UNITS. USE UNITS
PER CURRENT 29 CFR 1910.134 & FOLLOW MANUFACTURERS' INSTRUCTIONS &
WARNINGS. IF WITHIN OS HA PROTECTION FACTOR, AIR PURIFYING OK.
Ventilation:LOCAL AND MECHANICAL EXHAUST
Protective Gloves:RUBBER GLOVES
Eye Protection:SAFETY GLASSES W/SIDE SHIELDS OR GOGGLES
Other Protective Equipment:EYE BATH AND SAFETY SHOWER
Work Hygienic Practices:MAINTAIN GOOD PERSONAL HYGIENE. DO NOT USE IN
CONFINED AREAS WITHOUT ADEQUATE VENTILATION.
Supplemental Safety and Health

Boiling Pt:B.P. Text:172 TO 724F
Vapor Density:< AIR
Spec Gravity:1.3 WATER = 1
Viscosity:*
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:ESSENTIALLY NIL.
Appearance and Odor:VISCOUS LIQUID WITH STRONG SOLVENT ODOR
Percent Volatiles by Volume:58.3%

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:FLAMES, SPARKS, SMOKING AND HEAT.
Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE

Waste Disposal Methods:USE INERT ABSORBENT MATERIALS ON SPILLS. DISPOSE
OF IN ACCORDANCE WITH ALL LOCAL, STATE & FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.