Product ID:MT STARTER (NP), RP607
MSDS Date:01/31/1990
FSC:6850
NIIN:00N040535
MSDS Number: BSJDY

MINOLTA CORP

101 WILLIAMS DR
RAMSEY, NJ 07446
US

Emergency Phone: 800-424-9300(CHEMTREC)

Info Phone: 201-825-4000

Cage: GO339

MINOLTA CORPORATION

RAMSEY, NJ 07446 US

Telephone: 201-825-4000

Cage: 23736

CARBON BLACK

CAS: 1333-86-4

RTECS: FF5800000

OSHA PEL 3.5 MG/M3

ACGIH TLV: 3.5 MG/M3

AMORPHOUS SILICA

CAS: 7631-86-9

TONER (CONSISTING OF INGREDIENTS 7-9)

Fraction By Weight: <10%

STYRENE ACRYLATE COPOLYMER (2 KINDS)

CARBON BLACK

CAS: 1333-86-4

RTECS: FF5800000

OSHA PEL 3.5 MG/M3

ACGIH TLV: 3.5 MG/M3

AMORPHOUS SILICA

CAS: 7631-86-9

CARRIER (CONSISTING OF INGREDIENTS 2-5)

Fraction By Weight: >90%

FERRITE

POLYESTER RESIN

LD50 LC50 Mixture:LD50 (ORAL,RAT): >5.0 G/KG.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: MINIMAL RESPIRATORY TRACT
IRRITATION MAY OCCUR AS WITH EXPOSURE TO LARGE AMOUNTS OF ANY
NONTOXIC DUST. MAY CAUSE COUGH AND RAISE PHLEGM. TONER PRESENTS LOW
HAZARD FOR USUAL OCCUPATIONAL SETTING S. BASED ON AVAILABLE DATA,
HUMAN EXPOSURE TO TONER HAS BEEN SHOWN TO CAUSE MINIMAL RESPIRATORY
TRACT (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HEALTH HAZARDS: IRRITATION AS MAY OCCUR WITH
LARGE AMOUNTS OF ANY NON-TOXIC DUSTS. AT HIGHER LEVELS A SLIGHT
DEGREE OF FIBROSIS WAS OBSERVED DUE TO EXCESSIVE AMOUNTS OF DUST
RETAINED IN LUNGS FOR PROL ONGED INTERVAL. CHRONIC: NONE.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INHALATION: WASH NOSTRILS, RINSE MOUTH. INGESTION: DILUTE
STOMACH CONTENTS WITH SEVERAL GLASSES OF WATER. EYE: FLUSH WITH
WATER FOR AT LEAST 15 MINUTES. SKIN: WASH WITH SOAP AND WATER.

Extinguishing Media:WATER, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . AVOID INHALATION OF SMOKE.
Unusual Fire/Explosion Hazard:TONER, A COMPONENT OF STARTER, IS
COMBUSTIBLE POWDER. WHEN DISPERSED IN AIR, IT FORMS EXPLOSIVE
MIXTURES.

Spill Release Procedures:SWEEP UP OR VACUUM.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:NONE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.

Respiratory Protection:NONE REQUIRED WHEN USED AS INTENDED IN MINOLTA
EQUIPMENT. WEAR NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Ventilation:GENERAL VENTILATION SUFFICIENT TO KEEP AIRBORNE
CONCENTRATION BELOW CURRENT EXPOSURE LIMITS .
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APPROVED SAFETY GLASSES .
Other Protective Equipment:NONE REQUIRED WHEN USED AS INTENDED IN
MINOLTA EQUIPMENT.
Work Hygienic Practices:NONE.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.

Spec Gravity:3 (H*2O=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK POWDER, FAINT ODOR.

Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:PRODUCTS OF COMBUSTION ARE TOXIC.
AVOID BREATHING OF SMOKE.

Waste Disposal Methods:DO NOT INCINERATE. NO SPECIAL TECHNIQUES BEYOND
NORMAL PRACTICE. ENSURE CONFORMITY WITH FEDERAL, STATE, AND LOCAL
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.