Product ID:H I PLUS GREASE 105,BARIUM GREASE 105/NO 2
MSDS Date:04/22/1994
FSC:9150
NIIN:01-345-6145
MSDS Number: BTRBQ

SOUTHWESTERN PETROLEUM CORP

534 N MAIN ST
FORT WORTH, TX 76106
US

Emergency Phone: 817-332-2336/800-424-9300(CHEMTREC)

Info Phone: 817-332-2336

Cage: 14392

SOUTHWESTERN PETROLEUM CORP

961005 FORT WORTH, TX 76106 US

Telephone: 817-348-7235

Cage: 14392

PETROLEUM LUBRICATING OIL BASE STOCK

CAS: 64742-57-0

Fraction By Weight: >=70%

OSHA PEL 5 MG/M3 AS OIL MIST

ACGIH TLV: 5 MG/M3 AS OIL MIST

MINERAL OIL, PETROLEUM DISTILLATE, SOLVENT REFINED (MILD),

CAS: 64741-96-4

RTECS: PY8040000

Fraction By Weight: <=30%

COMPLEX BARIUM SALT CONTAINING ACETATE AND TALLOWATE

CAS: 13701-59-2

Fraction By Weight: <8%

LD50 LC50 Mixture:TLV FOR OIL MIST IS 5 MG/M3.
Routes of Entry: Inhalation:NO Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYE, SKIN, RESPIRATORY
TRACT. ACUTE- NOT EXPECTED TO PRESENT A SIGNIFICANT HEALTH HAZARD
UPON SHORT TERM EXPOSURE. VAPORS MAY IRRITATE EYES, NOSE & THROAT
CAUSING HEADACHE, DIZZINESS. EY E/SKIN CONTACT MAY CAUSE
IRRITATION. INGESTION MAY CAUSE NAUSEA, VOMITING, DIZZINESS.
CHRONIC- MILD SKIN IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES, SKIN, RESPIRATORY TRACT IRRITATION,
HEADACHE, DIZZINESS, NAUSEA, VOMITING
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN DISORDERS MAY BE
MORE SUSCEPTIBLE TO THIS MATERIAL.

First Aid:CALL A DOCTOR IF SYMPTOMS PERSIST. EYE:IMMEDIATELY FLUSH WITH
WATER FOR 15 MINUTES, HOLDING EYELIDS OPEN. SKIN:WASH WITH SOAP &
WATER. INHALED:REMOVE TO FRESH AIR. PROVIDE CPR/OXYGEN IF NEEDED.
ORAL:I F CONSCIOUS, DRINK WATER & INDUCE VOMITING. CALL A
PHYSICIAN/POISON CONTROL CENTER IMMEDIATELY. NEVER GIVE FLUID OR
INDUCE VOMITING IF PATIENT IS UNCONSCIOUS OR HAS CONVULSIONS.

Flash Point Method:COC
Flash Point:>354F,>179C
Autoignition Temp:Autoignition Temp Text:>649F
Lower Limits:0.9
Upper Limits:7
Extinguishing Media:USE CARBON DIOXIDE, FOAM, WATER SPRAY OR DRY
CHEMICAL. WATER SPRAY MAY BE USED TO FLUSH SPILLS AWAY FROM
EXPOSURES.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:WATER OR FOAM MAY CAUSE FROTHING.

Spill Release Procedures:ELIMINATE SOURCES OF IGNITION. STOP LEAK. DIKE
SPILLS. USE PUMP TO TRANSFER LARGE SPILLS TO CONTAINER FOR
DISPOSAL. REMAINING LIQUID/SMALL SPILLS CAN BE TAKEN UP ON SAND,
CLAY, EARTH & SHOVELD INTO CO NTAINERS. PREVENT RUN-OFF TO ENTER
WATERWAYS.
Neutralizing Agent:NOT RELEVANT

Handling and Storage Precautions:STORE IN A COOL, DRY PLACE AWAY FROM
OXIDIZERS. DO NOT TRANSFER TO AN UNMARKED CONTAINER.
Other Precautions:USE ONLY IN WELL VENTILATED AREAS. AVOID PROLONGED/
REPEATED BREATHING OF FUMES/MISTS. AVOID CONTACT WITH EYES AND
SKIN. DO NOT TAKE INTERNALLY. WASH THOROUGHLY AFTER USING. KEEP OUT
OF REACH OF CHILD REN.

Respiratory Protection:USE ONLY IN WELL VENTILATED AREA. IF EXCESSIVE
MISTING PRESENT, USE NIOSH-APPROVED SELF-CONTAINED BREATHING
APPARATUS.
Ventilation:ADEQUATE
Protective Gloves:RUBBER OR LATEX
Eye Protection:GOGGLES OR FACE SHIELD
Other Protective Equipment:EYE WASH STATION AND PROTECTIVE CLOTHING
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health
ANTIDOTE:DRINK A SOLUTION OF SODIUM SULFATE OR GLAUBER'S SALTS TO
CONVERT BARIUM ION TO THE INSOLUBLE, HARMLESS BARIUM SULFATE.
CONTAINS CHEMICAL THAT IS SUBJECT TO REPORTING REQMTS OF SEC 313 OF
TITL E III OF SARA & 40 CFR 372 AS BARIUM CMPD.

HCC:T6
NRC/State Lic Num:NOT RELEVANT
Vapor Density:>5
Spec Gravity:0.9
Evaporation Rate & Reference:NOT RELEVANT
Solubility in Water:INSOLUBLE
Appearance and Odor:AMBER COLOR - LUBE OIL ODOR
Percent Volatiles by Volume:NONE

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT AND IGNITION SOURCES

Waste Disposal Methods:LAND FILL OR INCINERATE IN ACCORDANCE WITH ALL
APPLICABLE LOCAL, STATE AND FEDERAL REGULATIONS. DO NOT ALLOW
MATERIAL ENTERS SEWERS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.