Product ID:DYNASOLVE 710/DYNASOLVE 711/DYNASOLVE 750
MSDS Date:09/01/1989
FSC:6850
NIIN:01-371-1614
MSDS Number: BTTPM

DYNALOY, INC.

7 GREAT MEADOW LANE
HANOVER, NJ 07936
US

Emergency Phone: 201-887-9270

Info Phone: 201-887-9270

Preparer: JAY W. PARTON

Cage: 27908

DYNALOY, INC.

INDIANAPOLIS, IN 46203 US

Telephone: 317-788-9925;703-527-3887

Cage: 27908

PROPYLENE GLYCOL MONOMETHYL ETHER

CAS: 107-98-2

RTECS: UB7700000

Fraction By Weight: 40 - 70%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM/150STEL;9394

METHYL ALCOHOL (METHANOL) (SARA III)

CAS: 67-56-1

RTECS: PC1400000

Fraction By Weight: 2 - 5%

OSHA PEL S, 200 PPM

ACGIH TLV: S,200PPM/250STEL; 94

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

POTASSIUM HYDROXIDE (SARA III)

CAS: 1310-58-3

RTECS: TT2100000

Fraction By Weight: 1 - 5%

OSHA PEL C, 2 MG/M3

ACGIH TLV: C 2 MG/M3; 9394

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYE, SKIN, RESPIRATORY &
GI TRACTS. ACUTE- TOXIC & CORROSIVE. MAY CAUSE EYE, SKIN,
RESPIRATORY & GI TRACT IRRITATION & BURNS, HEADACHE, DIZZINESS,
NAUSEA, VOMITING, COMA, BREATHING DIFFI CULTIES. CHRONIC- PROPYLENE
GLYCOL MONOMETHYL ETHER HAS PRODUCED LIVER & KIDNEY ENLARGEMENT IN
LABORATORY ANIMALS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES, SKIN, RESPIRATORY AND GASTROINTESTINAL
TRACTS IRRITATION, NAUSEA, VOMITING, HEADACHES, DIZZINESS,
DROWSINESS, INCOORDINATION, COMA, BREATHING DIFFICULTIES
Medical Cond Aggravated by Exposure:NONE CURRENTLY KNOWN.

First Aid:CALL A DOCTOR IF SYMPTOMS PERSIST. EYE:IMMEDIATELY FLUSH WITH
WATER FOR 15 MINUTES, HOLDING EYELIDS OPEN. SKIN:WASH WITH SOAP &
WATER. INHALED:REMOVE TO FRESH AIR. PROVIDE CPR/OXYGEN IF NEEDED.
ORAL:I F CONSCIOUS, DRINK 2 GLASSES OF WATER &INDUCE VOMITING. CALL
A PHYSICIAN/POISON CONTROL CENTER IMMEDIATELY.

Flash Point Method:CC
Flash Point:105F,41C
Lower Limits:1.6
Upper Limits:11.8
Extinguishing Media:ALCOHOL FOAM, WATER FOG, CARBON DIOXIDE/DRY
CHEMICAL. WATER MAY BE USED TO KEEP FIRE-EXPOSED CONTAINERS COOL.
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING AND
NIOSH-APPROVED SELF-CONTAINED BREATHING APPARATUS WITH FULL
FACEPIECE OPERATED IN THE POSITIVE PRESSURE MODE.
Unusual Fire/Explosion Hazard:VAPOR IS HEAVIER THAN AIR AND CAN TRAVEL
CONSIDERABLE DISTANCE TO A SOURCE OF IGNITION AND FLASH BACK.
CONTAINERS MAY EXPLODE DUE TO VAPOR PRESSURE BUILDUP.

Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. ELIMINATE SOURCES
OF IGNITION. VENTILATE AREA. CONTAIN SPILL. PICK UP SPILL WITH
NON-FLAMMABLE ABSORBENT SUCH AS SAND, EARTH/USE PUMP (EXPLOSION
PROOF). GROUND ALL HANDLING EQUIPMENTS. PREVENT LIQUID FROM
ENTERINGSEWERS.
Neutralizing Agent:WEAK ACID

Handling and Storage Precautions:STORE IN COOL, VENTILATED AREA, AWAY
FROM HEAT, FLAMES, SPARKS, HOT SURFACES & INCOMPATIBLE MATERIALS.
KEEP CONTAINER TIGHTLY CLOSED.
Other Precautions:WARNING. TOXIC AND CORROSIVE. AVOID BREATHING VAPORS.
DO NOT GET IN EYES, ON SKIN OR ON CLOTHING. WASH THOROUGHLY AFTER
HANDLING. DO NOT USE WELDING TORCH ON THIS CONTAINER (EVEN EMPTY).
KEEP OUT OF R EACH OF CHILDREN. READ LABEL.

Respiratory Protection:NIOSH APPROVED SELF-CONTAINED BREATHING
APPARATUS SHOULD BE WORN IN THE ABSENCE OF ADEQUATE VENTILATION.
Ventilation:MECHANICAL (GENERAL AND/OR LOCAL EXHAUST, EXPLOSION-PROOF)
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
Protective Gloves:NITRILE RUBBER, NEOPRENE
Eye Protection:CHEMICAL SPLASH GOGGLES/FACE SHIELD
Other Protective Equipment:IMPERVIOUS PROTECTIVE CLOTHING SHOULD BE
WORN TO PREVENT SKIN CONTACT. EYE WASH AND SAFETY EQUIPMENT SHOULD
BE AVAILABLE
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health

HCC:F7
NRC/State Lic Num:NOT RELEVENT
Boiling Pt:=120.C, 248.F
Vapor Pres:8 @ 68F
Vapor Density:3.12
Spec Gravity:0.983 - 0.996
pH:13.7
Evaporation Rate & Reference:0.66 (N-BUTYL ACETATE=1)
Solubility in Water:100%
Appearance and Odor:BLUE-GREEN LIQUID, SLIGHT PLEASANT ODOR
Percent Volatiles by Volume:100

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT, FLAMES, SPARKS, STATIC DISCHARGE,
OTHER SOURCES OF IGNITION
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE

Waste Disposal Methods:WASTE DISPOSAL TO BE PERFORMED IN COMPLIANCE
WITH ALL CURRENT LOCAL, STATE AND FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.