Product ID:TECTYL 910
MSDS Date:11/21/1994
FSC:9150
NIIN:00-111-0208
MSDS Number: BWGWZ

VALVOLINE OIL CO SUBSIDIARY OF ASHLAND OIL INC.

200 E MAIN ST
LEXINGTON, KY 40512
US

Emergency Phone: 800-ASHLAND/800-274-5263

Info Phone: 606-264-7000

Cage: 72527

VALVOLINE OIL CO

14000 LEXINGTON, KY 40512 US

Telephone: 606-357-7206 / 800-274-5263

Cage: 72527

DETERGENT & DISPERSANT ENGINE OIL PACKAGE (INGREDIENT # 4

Fraction By Weight: 10 - 15%

SOLVENT DEWAXED HEAVY PARAFFINIC PETROLEUM DISTILLATE

Fraction By Weight: 40 - 55%

OSHA PEL 5 MG/M3 AS OIL MIST

ACGIH TLV: 5 MG/M3 AS OIL MIST

HYDROCARBON OILS

CAS: 68410-95-7

Fraction By Weight: 25 - 40%

OSHA PEL 5 MG/M3 AS OIL MIST

ACGIH TLV: 5 MG/M3 AS OIL MIST

ZINC COMPOUND (MAXIMUM 30%)

Fraction By Weight: SEE # 1%

LD50 LC50 Mixture:TLV: 5 MG/M3 AS OIL MIST.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYE, SKIN, RESPIRATORY &
GASTROINTESTINAL TRACTS. ACUTE- EYE/SKIN/INHALATION:MAY CAUSE
IRRITATION. ORAL:SINGLE DOSE ORAL TOXICITY IS LOW. SWALLOWING SMALL
AMOUNTS DURING NORMAL HANDLING IS NOT LIKELY TO CAUSE HAMFUL
EFFECTS; SWALLOWING LARGE AMOUNTS MAY BE HARMFUL. CHRONIC- UNKNOWN.
Explanation of Carcinogenicity:WARNING! USED MOTOR OILS WERE SHOWN TO
CAUSE SKIN CANCER WHEN REPEATEDLY APPLIED TO MICE WITHOUT CLEANING
SKIN.
Effects of Overexposure:EYES, SKIN, RESPIRATORY AND GASTROINTESTINAL
TRACTS IRRITATION; NAUSEA, VOMITING, HEADACHES, STINGING, TEARING,
REDNESS AND SWELLING OF EYES; REDNESS AND BURNING OF SKIN, DIARRHEA
Medical Cond Aggravated by Exposure:ASTHMA-LIKE CONDITIONS

First Aid:GET MEDICAL ATTENTION IF SYMPTOMS PERSIST. SKIN:REMOVE
CONTAMINATED CLOTHING. WIPE OFF EXCESS. WASH SKIN WITH SOAP &
WATER. EYE:FLUSH WITH WATER FOR 15 MINUTES. HOLD EYELIDS OPEN.
INHALED:REMOVE TO FR ESH AIR. PROVIDE OXYGEN/CPR IF NEEDED. ORAL:DO
NOT INDUCE VOMITING. CALL A PHYSICIAN. KEEP PERSON WARM AND QUIET.

Flash Point Method:PMCC
Flash Point:205F,96C
Lower Limits:1.0%
Extinguishing Media:CARBON DIOXIDE, FOAM/DRY CHEMICAL. NEVER POUR WATER
OVER HOT, BURNING OIL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
NIOSH-APPROVED SELF CONTAINED BREATHING APPARATUS. COOL FIRE
EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:WATER MAY CAUSE FROTHING.

Spill Release Procedures:ELIMINATE SOURCES OF IGNITION. STOP LEAK. DIKE
SPILLS. USE PUMP TO TRANSFER LARGE SPILLS TO CONTAINER FOR
DISPOSAL. REMAINING LIQUID/SMALL SPILLS CAN BE TAKEN UP ON SAND,
CLAY, EARTH & SHOVELD INTO CO NTAINERS. PREVENT RUN-OFF TO ENTER
WATERWAYS.
Neutralizing Agent:NOT RELEVANT

Handling and Storage Precautions:STORE IN A DRY PLACE AWAY FROM
INCOMPATIBLE MATERIALS. KEEP CONTAINER CLOSED.
Other Precautions:"EMPTY" CONTAINERS RETAIN RESIDUE. ALL PRECAUTIONS
SHOULD BE OBSERVED. WASH THOROUGHLY AFTER HANDLING. KEEP OUT OF
REACH OF CHILDREN. AVOID BREATHING MISTS/VAPORS. AVOID REPEATED
SKIN CONTACT. DO NOT GET IN EYES. DO NOT INGEST.

Respiratory Protection:NON REQUIRED UNDER NORMAL CONDITIONS. IF HIGH
VAPOR OR MIST CONCENTRATIONS EXPECTED, USE NIOSH APPROVED CHEMICAL
CARTRIDGE RESPIRATOR FOR ORGANIC VAPORS AND MISTS. REFER TO 29 CFR
1910.134.
Ventilation:ADEQUATE TO MEET PERMISSIBLE CONCENTRATIONS
Protective Gloves:NEOPRENE IF FREQUENT CONTACT EXPECTED
Eye Protection:SAFETY GOGGLES IF SPLASHING ANTICIPATED
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
FORMULA CHANGED. FOR PREVIOUS FORMULATION, SEE PNI A, SAME NSN.

HCC:V6
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:500F,260C
Vapor Pres:0.10 @ 68F
Vapor Density:>1
Spec Gravity:0.882
Evaporation Rate & Reference:<1 (ETHER=1)
Appearance and Odor:LIQUID - OIL ODOR

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:EXTREME HEAT
Hazardous Decomposition Products:MAY FORM CARBON MONOXIDE, CARBON
DIOXIDE AND OTHER HYDROCARBONS.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL STATE AND
FEDERAL REGULATIONS. PRODUCT IS AN OIL. SPILLS TO US SURFACE WATERS
OR WATERCOURSE OR SEWER THAT CAUSE A VISIBLE SHEEN MUST BE REPORTED
TO THE NATIONAL RE SPONSE CENTER. RCRA PHONE: 800-424-9346.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.