Product ID:MIL-H-46170 B (AMEND 1)
MSDS Date:02/01/1995
FSC:9150
NIIN:01-119-8149
MSDS Number: BXFSG

Emergency Phone: 708-298-9000

Info Phone: 708-298-9000

Preparer: N. R. NETZEL

Cage: VELSI

Telephone: 847-298-9000

Cage: VELSI

SYNTHETIC HYDROCARBON OIL (DIESTER)

LD50 LC50 Mixture:TLV FOR OIL MIST IS 5 MG/M3.
Routes of Entry: Inhalation:NO Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYES, SKIN, RESPIRATPORY
AND GASTROINTESTINAL TRACTS. ACUTE- LOW ORAL AND DERMAL TOXICITY.
MISTS OR FUMES FROM EXCESSIVE HEATING MAY CAUSE EYE AND RESPIRATORY
TRACT IRRITATION. DIRECT CO NTACT WITH LIQUID MAY CAUSE EYES AND
SKIN IRRITATION. INGESTION MAY CSUSE NAUSEA, VOMITING, DIARRHEA.
CHRONIC- UNKNOWN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, NAUSE, VOMITING, DIARRHEA
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS MAY BE MORE SUSCEPTIBLE TO THE EFFECTS OF THIS PRODUCT.

First Aid:CALL A DOCTOR IF SYMPTOMS PERSIST. EYE:FLUSH WITH WATER FOR
15 MINUTES, HOLDING EYELIDS OPEN. SKIN:WIPE EXCESS. WASH SKIN WITH
SOAP & WATER. INHALED:REMOVE TO FRESH AIR. PROVIDE CPR/OXYGEN IF
NEEDED. ORAL:DO NOT INDUCE VOMITING. CALL A PHYSICIAN. NOTE TO
PHYSICIAN: TREAT SYMPTOMATICALLY.

Flash Point Method:COC
Flash Point:450F,232C
Extinguishing Media:WATER FOG, FOAM, DRY CHEMICAL/CARBON DIOXIDE. DON'T
USE A DIRECT STREAM OF WATER; IT WILL SPREAD FIRE.
Fire Fighting Procedures:DO NOT ENTER ANY ENCLOSED OR CONFINED AREA
WITHOUT PROPER PROTECTIVE EQUIPMENT AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:WILL PRODUCE TOXIC FUMES.

Spill Release Procedures:STOP LEAK. DIKE SPILLS. USE PUMP TO TRANSFER
SPILLS TO CONTAINER FOR DISPOSAL. REMAINING LIQUID/SMALL SPILLS CAN
BE TAKEN UP ON SAND, CLAY, EARTH & SHOVELD INTO CONTAINERS. PREVENT
RUN-OFF TO ENTER WA TERWAYS.
Neutralizing Agent:NOT RELEVANT

Handling and Storage Precautions:STORE IN DRY, VENTILATED PLACE AWAY
FROM EXCESSIVE HEAT AND STRONG OXIDIZERS. KEEP OUT OF REACH OF
CHILDREN.
Other Precautions:AVOID CONTACT WITH EYES AND SKIN. WASH THOROUGHLY
AFTER HANDLING. LAUNDER CLOTHING BEFORE REUSE. AVOID INHALING
MISTS. EMPTY CONTAINERS OF THIS PRODUCT MAY BE HAZARDOUS DUE TO THE
RETENTION OF RESIDUE S.

Respiratory Protection:IF WORKING IN CONFINED AREAS, IF EXCESSIVE
MISTING IS EXPECTED OR IF EXPOSURE MAY OR DOES EXCEED RECOMMENDED
PERMISSIBLE EXPOSURE LIMITS (PEL), WEAR NIOSH-APPROVED RESPIRATORY
PROTECTION (REFER TO 29 CFR 1910.134).
Ventilation:LOCAL EXHAUST FAN IS RECOMMENDED TO MAINTAIN CONCENTRATION
OF OIL MIST IN AIR BELOW RECOMMENDED TLV.
Protective Gloves:NITRILES RECOMMENDED
Eye Protection:SAFETY GOGGLES/FACE SHIELD
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DISCARD CONTAMINATED LEATHER GLOVES AND
SHOES.
Supplemental Safety and Health
FORMULA CHANGED. FOR PREVIOUS FORMULATION, SEE PNI A, SAME NSN.

HCC:V6
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:>600F,>316C
Spec Gravity:<1
Evaporation Rate & Reference:<1 (N-BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR LIQUID - MILD ODOR

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:EXCESSIVE HEAT
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE, TOXIC
FUMES MAY BE FORMED.

Waste Disposal Methods:DISPOSE OF IN AN APPROPRIATE DISPOSAL FACILITY
IN COMPLIANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.