Product ID:MACS DEGREASING COMPOUND (CONCENTRATE)
MSDS Date:02/10/1995
FSC:9150
NIIN:00N069404
MSDS Number: BZQMY

VALVOLINE INC

LEXINGTON, KY 40512
US

Emergency Phone: 800-274-5263

Info Phone: 606-357-7847

Cage: GO029

VALVOLINE OIL CO

14000 LEXINGTON, KY 40512 US

Telephone: 606-357-7206 / 800-274-5263

Cage: 72527

KEROSENE

CAS: 8008-20-6

RTECS: OA5500000

Fraction By Weight: 62-72%

OSHA PEL N/K

ACGIH TLV: N/K

SOLVENT NAPHTHA; (AROMATIC PETROLEUM DISTILLATES)

CAS: 64742-94-5

RTECS: WF3100000

Fraction By Weight: 11-21%

OSHA PEL N/K

ACGIH TLV: N/K

COMPLETED. STOP SPILL AT SOURCE. PVNT FROM

RTECS: 9999999ZZ

PVNT FROM SPREADING. IF RUNOFF OCCURS, NOTIFY AUTH

RTECS: 9999999ZZ

CLEAN CONTRS FOR RECOVERY. ABSORB UNRECOVERABLE

RTECS: 9999999ZZ

CONTRS FOR DISP. PVNT RUNOFF TO SEWERS,

RTECS: 9999999ZZ

AUTHORITIES AS REQUIRED, THAT A SPILL HAS OCCURRED.

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE: IRRIT. SYMP MAY INCL
STINGING, TEARING, REDNESS & SWELL. SKIN: MAY CAUSE MILD IRRIT.
PRLNG/RPTD EXPOS MAY DRY SKIN. SYMP MAY INCL REDNESS, BURNING,
DRYING & CRACKING, & SKIN BURNS. INGEST: SINGLE DOSE ORAL TOX LOW.
INGEST SML AMTS DURING NORM HNDLG NOT LIKELY TO CAUSE HARMFUL EFTS.
INGEST (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: LGE AMTS MAY BE HARMFUL. MATL CAN
ENTER LUNGS DURING INGEST/VOMIT & CAUSE LUNG INFLAMM &/DMG. MAY
CAUSE GI IRRIT (NAUS, VOMIT, DIARR), IRRIT (NOSE, THROAT, RESP
TRACT), CNS DEPRESS (DIZZ, DR OW, WEAK, FATG, NAUS, HDCH, UNCON), &
DEATH.
Medical Cond Aggravated by Exposure:PREEXISTING SKIN DISORDERS.
PREEXISTING LUNG DISORDERS (E.G., ASTHMA-LIKE CONDITIONS).

First Aid:EYE: IMMED MOVE INTO FRESH AIR. FLUSH GENTLY W/WATER FOR AT
LEAST 15 MIN WHILE HOLDING EYELIDS APART. SEEK IMMED MED ATTN.
SKIN: REMOVE CONTAM CLTHG. WASH EXPOSED AREA W/SOAP & WATER. IF
SYMP PERSIST, SEEK MED ATTN. LAUNDER CLTHG BEFORE REUSE. INGEST:
DO NOT INDUCE VOMIT. THIS MATL IS AN ASPIR HAZ. IF DROWSY/UNCON,
PLACE ON LEFT SIDE W/HEAD DOWN. SEEK MED ATTN. IF POSS, DO NOT
LEAVE PERS (SUP DAT)

Flash Point Method:TCC
Flash Point:>140F,>60C
Lower Limits:0.7%
Extinguishing Media:USE REGULAR FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. WATER/FOAM MAY CAUSE FROTHING WHICH CAN BE VIOLENT & POSS
ENDANGER LIFE OF FIREFIGHTER. REFER TO (SUP DAT)
Unusual Fire/Explosion Hazard:NEVER USE WELDING OR CUTTING TORCH ON OR
NEAR DRUM (EVEN EMPTY) BECAUSE PRODUCT (EVEN JUST RESIDUE) CAN
IGNITE EXPLOSIVELY.

Spill Release Procedures:SML SPILL: ABSORB LIQ ON VERMICULITE, FLOOR
ABSORB/OTHER ABSORB MATL. LGE SPILL: ELIM ALL IGNIT SOURCES
(FLARES, FLAMES INCL PILOT LIGHTS, ELEC SPARKS). PERS NOT WEARING
PROT EQUIP SHOULD BE EXCLUDED FROM AREA OF SPILL UNTIL CLEAN-UP
HAS BEEN (ING 3)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:CONTRS OF THIS MATL MAY BE HAZ WHEN
EMPTIED. SINCE EMPTIED CONTRS RETAIN PROD RESIDUES (VAP, LIQ
&/SOLID) ALL HAZ PREC GIVEN IN MSDS MUST BE OBSERVED.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.

Respiratory Protection:IF WORKPLACE EXPOS LIM OF PROD/ANY COMPONENT IS
EXCEEDED, A NIOSH/MSHA APPRVD AIR SUPP RESP IS ADVISED IN ABSENCE
OF PROPER ENVIRON CTL. OSHA REGS ALSO PERMIT OTHER NIOSH/MSHA RESP
(NEG PRESS TYPE) UN DER SPECIFIED CNDTNS (CONSULT (SUP DAT)
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL AND/OR LOCAL
EXHAUST) VENTILATION TO MAINTAIN EXPOSURE BELOW TLV.
Protective Gloves:NEOPRENE, NITRILE RUBBER.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGS .
Other Protective Equipment:WEAR IMPERVIOUS CLOTHING AND BOOTS.
EMERGENCY EYEWASH & DELUGE SHOWER MEETING ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRE FIGHT PROC:PERS PROT EQUIP SECTION IN THIS MSDS. FIRST AID
PROC:UNATTENDED. INHAL:IMMED MOVE INTO FRESH AIR. SEEK IMMED MED
ATTN. KEEP PERS WARM & QUIET. IF PERS NOT BRTHG, BEGIN ARTF RESP.
IF BR THG DFCLT, ADMIN OXYGEN. RESP PROT:YOURINDUS HYGIENIST).
ENGINEERING/ADMIN CTLS SHOULD BE IMPLEMENTED TO REDUCE EXPOS.

Boiling Pt:B.P. Text:>300F,>149C
Vapor Pres:5 @ 77F
Vapor Density:1
Spec Gravity:0.867
Evaporation Rate & Reference:SLOWER THAN ETHYL ETHER
Appearance and Odor:CLEAR AMBER LIQUID
Percent Volatiles by Volume:85-100

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:MAY FORM CARBON DIOXIDE AND CARBON
MONOXIDE, SULFUR COMPOUNDS, VARIOUS HYDROCARBONS.

Waste Disposal Methods:DESTROY BY LIQUID INCINERATION. DISPOSE OF IN
ACCORDANCE WITH ALL APPLICABLE LOCAL, STATE, AND FEDERAL
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.