Product ID:X-1273
MSDS Date:01/11/1995
FSC:8010
NIIN:00-290-6648
MSDS Number: BZSTW

SENTRY PAINT AND CHEMICAL COMPANY

237 MILL STREET
DARBY, PA 19023
US

Emergency Phone: 800-424-9300

Info Phone: 215-522-1900

Preparer: ALBERT FALCO

Cage: 34346

SENTRY PAINT AND CHEMICAL CO

DARBY, PA 19023 US

Cage: 34346

VOC = 3.82 LBS/GAL, 4.59 GRAMS/LITER

RTECS: 9999999VO

OSHA PEL 500 PPM

ACGIH TLV: 100 PPM; 9293

STODDARD SOLVENT (VP = 2 MM @ 20C)

CAS: 8052-41-3

RTECS: WJ8925000

Fraction By Weight: 30-50%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

ZINC OXIDE (SARA 313) (CERCLA)

CAS: 1314-13-2

RTECS: ZH4810000

Fraction By Weight: 0.1-5.0%

OSHA PEL 10 MG/M3

ACGIH TLV: 10 MG/M3

LEAD TETRAOXIDE, (RED LEAD OXIDE) (SARA 313) 10 @ 1985 F

CAS: 1314-41-6

RTECS: OG5425000

Fraction By Weight: 5-15%

OSHA PEL 0.05 MG/M3 AS LEAD

ACGIH TLV: 0.15 MG/M3 AS LEAD

LEAD SULFOCHROMATE (SARA 313)

CAS: 1344-37-2

Fraction By Weight: 5-15%

OSHA PEL 0.05 MG/M3

ACGIH TLV: 0.05 MG/M3

Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:INHAL/INGEST: HARMFUL. CANCER, BLOOD/
GASTROINTEST/NERVOUS/REPRODUCTION SYS. ACUTE: LEAD INTOX. INHAL:
NEURITIS, ENCEPHALOPATHY. CHRONIC: TOXIC. BLOOD/NERV/DIGEST SYS
EFFECTS. NEUROMUSCULAR DYSFUNCT, PARALYSIS. EYE: IRRIT. SKIN:
IRRIT, DERMATITIS. INHAL: NASAL/RESP IRRIT. INGEST: ASPIRATION
(LUNG) - CHEM PNEUMONITIS.
Explanation of Carcinogenicity:CONTAINS 2-A [53-96-3]
WHICH IS LISTED BY NTP AND IARC AND REGULATED BY OSHA AS A
CARCINOGEN.
Effects of Overexposure:COLIC, ANEMIA, VOMIT, PERIODIC CRAMPS, ACHING
BONE/MUSCLE, UNCOORDINAT, CONVULS, STUPOR, COMA. FATIGUE, SLEEP
DISTURB, HEADACHE, CONSTIPATION, ABDOM PAIN, APPETITE LOSS. NAUSEA,
CONSTIPATION. PARALYSI S. EYE: RED, TEAR, BLURR VISION. SKIN: DRY.
INHAL: DIZZY, WEAK, NAUSUA, HEADACHE. INGEST: NAUSUA, VOMIT,
DIARRHEA.

First Aid:REMOVE TO FRESH AIR IMMED. IF BREATHING STOPPED GIVE ARTIF
RESP. KEEP WARM/QUIET. GET MED AID IMMED. EYE: FLUSH W/ LRG AMT
WATER, LIFTING EYELIDS OCCASIONALLY FOR 15 MIN. GET MED AID. SKIN:
THOROUGHLY WASH W/SOAP & WATER. REMOVE CONTAMINATED CLOTHING.
INGEST: DON'T INDUCE VOMITING. KEEP WARM/QUIET. GET MED AID.
ASPIRATION OF MAT'L INTO LUNGS DUE TO VOMIT CAN CHEM PNEUMONITIS
(CAN BE FATAL).

Flash Point:105F,41C
Lower Limits:1.00
Upper Limits:7.00
Extinguishing Media:CARBON DIOXIDE OR DRY CHEMICALS FOR SMALL FIRES.
FOAM FOR LARGE FIRES.
Fire Fighting Procedures:COOL CLOSED CONTAINERS WITH WATER SPRAY.
CO2/CO ARE COMBUSTION PRODUCTS. USE APPROPRIATE RESPIRATOR FOR
PROTECTION.
Unusual Fire/Explosion Hazard:CLSD CNTNR MAY BLD EXPLOS PRESS W/HEAT.
VAPOR HEAVIER THAN AIR & MAY TRAVEL ALONG GRND/IGNITED AT DISTANT
LOCATION. NEVER USE WELD/CUT TORCH ON/NEAR DRUM.

Spill Release Procedures:EVAC AREA. ELIMINATE IGNIT SOURCE. DIKE/
CONTAIN W/INERT ABSORB. TRANSFER LIQ TO COVERED METAL CNTNR
(RECOVERY/ DISPOSAL) OR REMOVE W/INERT ABSORB. USE NON-SPARKING
TOOLS. PUT USED ABSORB IN COVRD MET AL CNTNRS. PREVENT
CONTAM-SEWER/STREAM/GRNDWATER.

Respiratory Protection:USE SELF-CONTAINED BREATHING APPARATUS WHERE
CONCENTRATIONS MAY BE ABOVE TLV LIMITS. BELOW TLV LIMITS, USE A
NIOSH APPROVED VAPOR RESPIRATOR.
Ventilation:LOCAL EXHAUST MUST BE SUFFICIENT TO KEEP AIRBORNE VAPOR
CONCENTRATIONS BELOW THE TLV LIMIT.
Protective Gloves:CHEMICAL RESISTANT GLOVES.
Eye Protection:SAFETY GLASSES WITH SIDE SHIELDS.
Other Protective Equipment:EYE BATH AND SAFETY SHOWER. TO PREVENT
REPEATED OR PROLONGED SKIN CONTACT. WEAR IMPERVIOUS CLOTHING AND
BOOTS.
Work Hygienic Practices:LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
VISCOSITY - #4 FORD CUP

Boiling Pt:B.P. Text:282 TO 315F
Melt/Freeze Pt:M.P/F.P Text:NA
Vapor Density:> AIR
Spec Gravity:1.364
pH:NA
Viscosity:*
Evaporation Rate & Reference:SLOWER THAN ETHER.
Solubility in Water:NEGLIGIBLE
Appearance and Odor:COLOR-OLIVE DRAB, ODOR-HYDROCARBON
Percent Volatiles by Volume:59.4

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:EXCESS HEAT, SPARKS, AND OPEN FLAME.
Hazardous Decomposition Products:FUMES MAY CONTAIN THE HAZARDOUS
MATERIALS LISTED ABOVE.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL LAWS. INCINERATE ONLY IN EPA PERMITTED FACILITY. DO NOT
INCINERATE CLOSED CONTAINERS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.