Product ID:6638 SAFETY KLEEN PREMIUM GOLD SOLVENT
MSDS Date:01/26/1995
FSC:6850
NIIN:00F049681
MSDS Number: BZWJT

Emergency Phone: 800-752-7869(US)/312-942-5969(CAN)

Info Phone: 800-669-5840/312-694-2700

Cage: 30530

Telephone: 1-803-933-4200

Cage: 30530

KEROSENE (PETROLEUM), HYDROTREATED (C10-C15 SATURATED

CAS: 64742-47-8

RTECS: OA5504000

Fraction By Weight: 100%

OSHA PEL 500 PPM

ACGIH TLV: 100 PPM

LD50 LC50 Mixture:ORAL LD50(RAT): >5000 MG/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES: MILD TO MODERATE IRRITATION &
MAY CAUSE CONJUNCTIVITIS. SKIN: MILD TO SEVERE IRRITATION, BURNING
& DERMATITIS. INHALATION: MAY IRRITATE THE NOSE, THROAT/RESPIRATORY
TRACT, CNS EFFECTS, RAPID CNS DEPRESSION, LUNG INJURY & DEATH.
INGESTION: LOW TOXICITY, THROAT IRRITATION, MYOCARDIAL INJURY & CNS
EFFECTS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, WATERING, STINGING, REDNESS,
DRYNESS, CRACKING, BURNING, NAUSEA, VOMITING, IRREGULAR HEARTBEAT,
HEADACHES, DIZZINESS, INCOORDINATION, NUMBNESS, UNCONSCIOUSNESS,
SUDDEN COLLAPSE, DEEP COMA.
Medical Cond Aggravated by Exposure:PRE-EXISTING LUNG, CARDIAC,
CNS/SKIN DISORDERS.

First Aid:EYES: FLUSH W/WATER FOR 15 MINS. SKIN: WASH TWICE W/SOAP &
WATER. INHALATION: REMOVE TO FRESH AIR. USE OXYGEN/CPR IF
NEEDED.DON'T LEAVE VICTIM UNATTENDED. INGESTION: DON'T INDUCE
VOMITING. IF VOMITIN G OCCURS, KEEP HEAD BELOW HIPS TO
AVOIDASPIRATION INTO THE LUNGS. OBTAIN MEDICAL ATTENTION IN ALL
CASES. NOTE TO PHYS: TREAT SYMPTOMATICALLY & SUPPORTIVELY, PERFORM
GASTRIC LAVAGE BY QUALIFIED PERSON

Flash Point Method:TCC
Flash Point:150F
Lower Limits:1
Upper Limits:9.3
Extinguishing Media:CO2, FOAM, DRY CHEMICAL/WATER SPRAY
Fire Fighting Procedures:KEEP STORAGE CONTAINERS COOL W/WATER SPRAY.
USE POSITIVE PRESSURE SCBA & STRUCTURAL FIREFIGHTERS PROTECTIVE
CLOTHING.
Unusual Fire/Explosion Hazard:HEATED CONTAINERS MAY RUPTURE/EXPLODE
INTO THE AIR. VAPORS ARE > THAN AIR & TRAVEL LONG DISTANCES TO
IGNITION SOURCE/FLASHBACK. AUTOIGNTION TEMP: <440F. (SUPP)

Spill Release Procedures:REMOVE IGNITION SOURCES. STOP LEAK SAFELY.
WEAR PROTECTIVE EQUIPMENT. VENTILATE AREA & AVOID BREATHING
VAPOR/MIST. LARGE: ISOLATE & DENY ENTRY; DIKE FOR LATER DISPOSAL.
CONTAIN FOR RECOVERY W/ABSORBEN T MATERIAL & SHOVEL W/A CLEAN,
NON-SPARKING TOOL.

Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS/FLAME. USE
WELL VENTILATED AREA. KEEP CONTAINER TIGHTLY CLOSED WHEN NOT IN
USE. GROUND & BOND MATERIAL WHEN TRANSFERRING.
Other Precautions:AVOID CONTACT W/EYES, SKIN, CLOTHING/SHOES. DON'T
PRESSURIZE, DRILL, CUT, HEAT, WELD, BRAZE, GRIND/EXPOSE CONTAINERS
TO SOURCES OF IGNITION. EMPTY CONTAINERS MAY CONTAIN PRODUCT
RESIDUE. USE SAFE EQUI PMENT WHERE EXPLOSIVES MAY BE PRESENT.

Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATORY PROTECTIVE
EQUIPMENT WHEN VAPOR/MIST EXCEEDS APPLICABLE EXPOSURE LIMIT. A SCBA
& FULL PROTECTIVE EQUIPMENT ARE REQUIRED FOR LARGE SPILLS/FIRE
EMERGENCIES.
Ventilation:GENERAL TO MAINTAIN CONCENTRATION < APPLICABLE LIMITS.
LOCAL EXHAUST TO CONTROL AIRBORNE LEVELS < EXPOSURE LIMITS.
Protective Gloves:NITRILE/VITON/BUTYL/NATURAL RUBBER
Eye Protection:CHEMICAL GOGGLES
Other Protective Equipment:CHEMICAL RESISTANT BOOTS, APRON, PROTECTIVE
CLOTHING, CLEAN WATER FOR FLUSHING EYES & SKIN.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING, SHOES &
PROTECTIVE EQUIPMENT BEFORE REUSE. USE GOOD PERSONAL HYGIENE.
Supplemental Safety and Health
WASH THOROUGHLY W/SOAP & WATER AFTER HANDLING & BEFORE EATING,
DRINKING/USING TOBACCO PRODUCTS. DISCARD CONTAMINATED
CLOTHING/SHOES/PROTECTIVE EQUIPMENT IF NOT THOROUGHLY CLEANED. FIRE
HZRD: VAPOR EXP LOSION HAZARD INDOORS, OUTDOORS/IN SEWERS. RUN-OFF
TO SEWER MAY CREATE FIRE/EXPLOSION HAZARD. DON'T USE CONTACT
LENSES.

Boiling Pt:B.P. Text:350-470F
Melt/Freeze Pt:M.P/F.P Text:<-45F
Vapor Pres:0.4-1
Vapor Density:5.3-6.2
Spec Gravity:0.78-0.82
VOC Pounds/Gallon:820
Evaporation Rate & Reference:(BU AC = 1): <0.1
Solubility in Water:INSOLUBLE
Appearance and Odor:LIQUID, CLEAR W/CHARACTERISTIC HYDROCARBON ODOR
Percent Volatiles by Volume:100/WT

Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, BASES/OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, SPARKS, FLAME, IGNITION SOURCES
Hazardous Decomposition Products:CHLORINE MAY CAUSE A VIOLENT REACTION,
CO.

Waste Disposal Methods:DISPOSE IAW/FEDERAL, STATE & LOCAL REGULATIONS.
CONTACT SAFETY KLEEN REGARDING RECYCLING/PROPER DISPOSAL.
COMBUSTIBLE LIQUID NA1993.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.