Product ID:O-402 SAFETY ORANGE HEAVY DUTY & MARINE ENAMEL
MSDS Date:01/15/1994
FSC:8010
NIIN:00F052882
MSDS Number: CDCFN

ALASKAN PAINT MFG CO INC

2040 SPAR AVE
ANCHORAGE, AK 99501-5000
US

Emergency Phone: 907-272-2942(AM)/907-337-0565(PM)

Info Phone: 907-272-2942

Cage: 0SVG0

ALASKAN PAINT MFG CO INC

ANCHORAGE, AK 99501-5000 US

Telephone: 907-272-2942

Cage: 0SVG0

MINERAL SPIRITS

Fraction By Weight: 40%

ACGIH TLV: 100 PPM

LEAD (IARC CARC GROUP 2B) *96-4*

CAS: 7439-92-1

RTECS: OF7525000

Fraction By Weight: 15%

ACGIH TLV: 0.15 MG/CUM

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

CHROMIUM, CHROMIUM METAL, CHROME (CARCINOGEN BY NTP; IARC

CAS: 7440-47-3

RTECS: GB4200000

Fraction By Weight: <5%

ACGIH TLV: 0.5 MG/CUM

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHALATION: MAY CAUSE MILD ANESTHESIA
& ASPHYXIATION. SKIN: IRRITATION & DERMATITIS. EYES: SEVERE
IRRITATION. INGESTION: GI IRRITATION. INHALATION/INGESTION OF PAINT
LIQUID, SPRAY MIST/DRY DUST MAY RE SULT IN TOXIC LEVELS OF LEAD IN
THE BODY/LEAD POISONING.
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:HEADACHE, NAUSEA, DIZZINESS, UNCONSCIOUSNESS,
ASPHYXIATION, IRRITATION, DRYNESS, DEFATTING, REDNESS, TEARING,
BLURRED VISION, VOMITING, DIARRHEA, ANEMIA, FATIGUE, WEIGHT LOSS,
CONSTIPATION, COLIC.

First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE CPR IF NEEDED. SKIN:
WASH W/SOAP & WATER. EYES: FLUSH W/LARGE AMOUNTS OF WATER FOR 15
MINS. INGESTION: DON'T INDUCE VOMITING. KEEP WARM & QUIET. OBTAIN
MEDICAL AT TENTION IN ALL CASES. NOTE TO PHYSICIAN: INGESTION OF
PRODUCT/SUBSEQUENT VOMITING CAN RESULT IN ASPIRATION OF LIGHT
HYDROCARBON LIQUID WHICH CAN CAUSE PNEUMONITIS.

Flash Point:103F
Lower Limits:1
Extinguishing Media:FOAM, CO2, DRY CHEMICAL.
Fire Fighting Procedures:USE A SCBA. WATER MAY BE UNSUITABLE
EXTINGUISHING MEDIUM, BUT CAN KEEP CONTAINERS COOL. AVOID SPREADING
BURNING LIQUID W/WATER USED FOR COOLING PURPOSES.
Unusual Fire/Explosion Hazard:COMBUSTIBLE LIQUID. CLOSED CONTAINERS MAY
EXPLODE WHEN EXPOSED TO HIGH HEAT. DON'T APPLY TO HOT SURFACES.

Spill Release Procedures:ELIMINATE IGNITION SOURCES. STOP AT SOURCE,
DIKE AREA TO PREVENT SPREADING. ABSORB LIQUID ON VERMICULITE, FLOOR
ABSORBENT/OTHER ABSORBENT INERT MATERIAL. PLACE IN SUITABLE
CONTAINER.

Handling and Storage Precautions:KEEP CONTAINERS TIGHTLY CLOSED.
ISOLATE FROM HEAT, ELECTRICAL EQUIPMENT, SPARKS & OPEN FLAME.

Respiratory Protection:IF TLV IS EXCEEDED, A NIOSH APPROVED AIR
SUPPLIED RESPIRATOR IS ADVISED. OSHA REGULATIONS ALSO PERMIT OTHER
APPROVED RESPIRATORS UNDER SPECIFIC CONDITIONS.
Ventilation:SUFFICIENT MECHANICAL TO MAINTAIN EXPOSURE BELOW TLV.
Protective Gloves:IMPERMEABLE
Eye Protection:SAFETY GLASSES/GOGGLES
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
VAPOR PRESSURE & LEL IS FOR MINERAL SPIRITS.

Vapor Pres:2
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:ORANGE LIQUID PAINT W/HYDROCARBON ODOR
Percent Volatiles by Volume:40/WT

Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS, ACIDS & BASES, PLASTICS & RUBBER.
Stability Condition to Avoid:HIGH TEMPS, DIRECT HEATING, HEAT,
ELECTRICAL EQUIPMENT, SPARKS, OPEN FLAME, HOT SURFACES.
Hazardous Decomposition Products:CO2, CO & POSSIBLY ACROLEIN GAS. LEAD
& CHROMIUM OXIDES.

Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.