Product ID:NAPA MV MOTOR OIL SAE 10W30
MSDS Date:02/28/1996
FSC:9150
NIIN:00N053354
MSDS Number: CGRTT

VALVOLINE INC

LEXINGTON, KY 40512
US

Emergency Phone: 800-274-5263

Info Phone: 606-357-7847

Cage: GO029

VALVOLINE OIL CO

14000 LEXINGTON, KY 40512 US

Telephone: 606-357-7206 / 800-274-5263

Cage: 72527

MINERAL OIL, PETROLEUM DISTILLATES, SOLVENT-DEWAXED HEAVY

CAS: 64742-65-0

RTECS: PY8038501

Fraction By Weight: 83-93%

OSHA PEL N/K

ACGIH TLV: N/K

HYDROTREATMENT); (ALIPHATIC PETROLEUM DISTILLATES)

RTECS: 9999999ZZ

OSHA PEL N/K

ACGIH TLV: N/K

DETERGENT/DISPERSANT ENGINE OIL PACKAGE

Fraction By Weight: 6-16%

OSHA PEL N/K

ACGIH TLV: N/K

PHOSPHORODITHIOC ACID, O-O-D1 C1-14-ALKYL ESTERS, ZINC

CAS: 68649-42-3

Fraction By Weight: 1.1%

OSHA PEL N/K

ACGIH TLV: N/K

WATER, & GET MED ATTN IMMED. IF POSSIBLE,

RTECS: 9999999ZZ

IMMED MOVE AWAY FROM EXPOS & INTO FRESH AIR. SEEK

RTECS: 9999999ZZ

BREATHING, BEGIN ARTIFICIAL RESPIRATION. IF

RTECS: 9999999ZZ

SHOULD BE EXCLUDED FROM AREA OF SPILL UNTIL

RTECS: 9999999ZZ

AREA OF SPILL TO PREVENT SPREADING, PUMP LIQUID TO

RTECS: 9999999ZZ

CLAY, EARTH, FLOOR ABSORBENT OR OTHER ABSORBENT

RTECS: 9999999ZZ

(GENERAL &/OR LOCAL EXHAUST) VENTILATION TO MAINTAIN

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYE: EXPOS MAY CAUSE MILD IRRIT. SYMPS
MAY INCL STINGING, TEARING & REDNESS. SKIN: EXPOS MAY CAUSE MILD
SKIN IRRIT. PRLNGD/RPTD EXPOS MAY DRY SKIN. SYMPS MAY INCL REDNESS,
BURNING, DRYING & CRACKING & SKIN BURNS. INGEST: SINGLE DOSE ORAL
TOX IS LOW. SWALLOWING SM AMTS DURING NORM HNDLG IS NOT LIKELY
TO(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: CAUSE HARMFUL EFTS; SWALLOWING LG
AMTS MAY BE HARMFUL. INHAL:EXPOS IS POSS UNDER CERTAIN CNDTNS OF
HNDLG & USE (FOR EX, DURING HEATING, SPRAYING OR STIRRING). SYMPS
ARE MRE TYPICALLY SEEN AT AIR CONCS EXCEEDING RECOMD EXPOS
LIMS.SYMPS OF EXPOS:GI IRRIT (NAUS, VOMIT, DIARR), IRRIT (NOSE,
THROAT, RESP(SUPDAT)
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN DISORDERS MAY BE
AGGRAVATED BY EXPOSURE TO THIS MATERIAL. PRE-EXISTING LUNG
DISORDERS, EG ASTHMA-LIKE CONDITIONS, MAY BE AGGRAVATED BY EXPOSURE
TO THIS MATERIAL.

First Aid:EYES: IF SYMPS DEVELOP, MOVE INDIVIDUAL AWAY FROM EXPOS &
INTO FRESH AIR. FLUSH EYES GENTLY W/WATER WHILE HOLDING EYELIDS
APART FOR AT LEAST 15 MIN. IF SYMPS PERSIST OR THERE IS ANY VISUAL
DFCLTY, SEE K MED ATTN. SKIN: REMOVE CONTAMD CLTHG.WASH EXPOSED
AREA W/SOAP & WATER. IF SYMPS PERSIST, SEEK MED ATTN. LAUNDER CLTHG
BEFORE REUSE. INGEST: DO NOT INDUCE VOMIT. GIVE ONE GLASS OF MILK
OR (ING 5)

Flash Point Method:COC
Flash Point:430F,221C
Extinguishing Media:REGULAR FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . WATER/FOAM MAY CAUSE FROTHING WHICH CAN BE VIOLENT &
POSSIBLE ENDANGER LIFE OF FIREFIGHTER.
Unusual Fire/Explosion Hazard:NEVER USE WELDING/CUTTING TORCH ON/NEAR
DRUM EVEN EMPTY) BECAUSE PROD (EVEN JUST RESIDUE) CAN IGNITE EXPLO.
DENSE SMOKE MAY BE GENERATED WHILE BURNING. (SUPDAT)

Spill Release Procedures:SM SPILL: ABSORB LIQ ON VERMICULITE, FLOOR
ABSORB OR OTHER ABSORB MATL. LG SPILL: PVNT RUN-OFF TO SEWERS,
STREAMS OR OTHR BODIES OF WATER. IF RUN-OFF OCCURS, NOTIFY PROPER
AUTHS AS REQD THAT A SPILL H AS OCCURED. PERS NOT WEARING PROT
EQUIP(ING 8)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:CNTNRS OF MATL MAY BE HAZ WHEN
EMPTIED. SINCE EMPTIED CNTNRS RETAIN PROD RESIDUES (VAP, LIQ &/OR
SOLID) ALL HAZ PRECS GIVEN IN MSDS MUST BE OBSERVED.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.

Respiratory Protection:NOT REQUIRED UNDER NORMAL CONDITIONS OF USE.
HOWEVER, IF OIL MISTS ARE GENERATED ABOVE RECOMMENDED PEL/TLV OF 5
MG/M3 THEN A NIOSH APPROVED RESPIRATOR IS ADVISED IN ABSENCE OF
PROPER ENVIRONMENTAL CON TROL (CONSULT INDUSTRIAL HYGIENIST).
Ventilation:NOT REQD UNDER NORM CNDTNS OF USE. HOWEVER, IF UNUSUAL
OPERATING CNDTNS EXIST, THEN PROVIDE SUFFICIENT MECH (ING 11)
Protective Gloves:RESISTANT SUCH AS NITRILE RUBBER.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
WEAR NORMAL WORK CLOTHING COVERING ARMS & LEGS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLO HAZ: HAZ PRODS OF COMBUSTION: MAY FORM CARBON DIOXIDE & CARBON
MONOXIDE, OXIDES OF SULFUR, NITROGEN & PHOSPHORUS, VARIOUS
HYDROCARBONS. EFTS OF OVEREXP: TRACT), ABDOM PAIN. USED MOTOR OIL
HAS BE EN SHOWN TO CAUSE SKIN CANCER IN LAB ANIMALS CONTINUALLY
EXPOSED BY RPTD APPLICATIONS. AVOID PRLNGD/RPTD SKIN CONTACT.

Boiling Pt:B.P. Text:425F,218C
Spec Gravity:0.881 @ 60F
Evaporation Rate & Reference:SLOWER THAN ETHYL ETHER
Appearance and Odor:DRY, CLEAR AND BRIGHT LIQUID.

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:MAY FORM CARBON DIOXIDE & CARBON
MONOXIDE, OXIDES OF SULFUR, NITROGEN & PHOSPHORUS, VARIOUS
HYDROCARBONS.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
LOCAL, STATE AND FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.