Product ID:M-FLUX AR
MSDS Date:08/24/1995
FSC:3439
NIIN:00N085300
MSDS Number: CHBKG

MEASUREMENTS GROUP INC

RALEIGH, NC 27611
US

Emergency Phone: 800-424-9300 (CHEMTREC)

Info Phone: 919-365-3800

Preparer: R.L. FRIDLEY

Cage: 88952

MEASUREMENTS GROUP INC

WENDELL, NC 27591 US

Telephone: 919-365-3800

Cage: 88952

ETHYL ALCOHOL; (ETHANOL)

CAS: 64-17-5

RTECS: KQ6300000

Fraction By Weight: 17%

OSHA PEL 1000 PPM

ACGIH TLV: 1000 PPM

SEC-BUTYL ALCOHOL; (2-BUTANOL) (SARA 313)

CAS: 78-92-2

RTECS: EO1750000

Fraction By Weight: 45%

OSHA PEL 150 PPM

ACGIH TLV: 100 PPM

ROSIN ACID; (MODIFIED ROSIN)

CAS: 8050-09-7

Fraction By Weight: 35%

OSHA PEL N/K

ACGIH TLV: N/K

TOLUENE (SARA 313) (CERCLA)

CAS: 108-88-3

RTECS: XS5250000

OSHA PEL 200 PPM

ACGIH TLV: 50 PPM, S

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

ISOPROPYL ALCOHOL; (ISOPROPANOL) (SARA 313)

CAS: 67-63-0

RTECS: NT8050000

OSHA PEL 400 PPM

ACGIH TLV: 400 PPM;500 STEL

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:IRRITATION OF MUCOUS
MEMBRANES AND PULMONARY SYSTEM. HIGH CONCENTRATIONS CAN CAUSE
HEADACHE, DIZZINESS, NARCOSIS AND NAUSEA. EYE CONTACT:IRRITATION
FROM CONTACT WITH LIQUID AND SMOKE FROM SOLDERING. SKIN
CONTACT:LOCAL IRRITATION. INGEST:BURNING SENSATION IN THE DIGESTIVE
TRACT. CHRONIC: (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:PRLNG/RPTD SKIN CONT CAN RSLT IN RASH.
SMOKE DURING SOLDERING WILL CONTAIN ROSIN WHICH IS AN ALLERGEN &
CAN CAUSE PULM IRRIT & DMG. NOTE:TOLUENE APPEARS ON NAVY LIST OF
OCCUP CHEM REPRO HAZS. SEEK CONSULTATION FROM APPROP HLTH
PROFESSIONALS CONCERNING LATEST HAZ LIST INFO & SAFE HNDLG & EXPOS
INFO .
Medical Cond Aggravated by Exposure:CHEMICAL HYPERSENSITIVITY, ASTHMA &
OTHER RESPIRATORY CONDITIONS. CONTINUED BREATHING OF HIGH
CONCENTRATIONS OF ALCOHOL VAPORS CAN AFFECT LIVER & CENTRAL NERVOUS
SYSTEM.

First Aid:INHAL:REMOVE VICTIM TO FRESH AIR. EYES:FLUSH W/PLENTY OF
WATER FOR AT LEAST 15 MINUTES. REMOVE ROSIN FROM AROUND EYES
W/DILUTE ETHANOL SOLUTION. SKIN:WASH THOROUGHLY W/SOAP & WATER.
INGEST:INDUCE VOMI TING & GET PROMPT MEDICAL ATTENTION.

Flash Point Method:TOC
Flash Point:65.0F,18.3C
Lower Limits:2.5%
Upper Limits:15%
Extinguishing Media:CARBON DIOXIDE, ALCOHOL FOAM OR DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . USE WATER SPRAY TO COOL FIRE EXPOSED CONTAINERS &
CONTROL VAPORS.
Unusual Fire/Explosion Hazard:A MODERATE EXPLOSION HAZARD EXISTS WHEN
EXPOSED TO HEAT OR FLAMES.

Spill Release Procedures:REMOVE ALL IGNITION SOURCES. PROVIDE ADEQUATE
VENTILATION. ABSORBENTS SUCH AS VERMICULITE CAN BE USED TO SOAK UP
SPILLED LIQUID. CLEAN UP RESIDUAL W/ALKALINE DETERGENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:FLAMMABLE LIQUIDS. STORE AWAY FROM
IGNITION SOURCES. STORAGE AT TEMPERATURES BELOW 40F (4C) MAY RESULT
IN PRECIPITATION OF SOME ROSIN.
Other Precautions:OPEN CONTAINERS CAUTIOUSLY TO ALLOW VENTING OF ANY
INTERNAL PRESSURE. EMPTY CONTAINERS MAY CONTAIN PRODUCT RESIDUE.
OBSERVE ALL LABEL PRECAUTIONS.

Respiratory Protection:NOT USUALLY REQUIRED. WHEN VENTILATION IS NOT
ADEQUATE TO REMOVE SMOKE FROM BREATHING ZONE A NIOSH APPROVED
CARTRIDGE TYPE RESPIRATOR SHOULD BE WORN.
Ventilation:LOCAL EXHAUST/MECHANICAL:KEEP BELOW TLV.
Protective Gloves:PLASTIC OR RUBBER GLOVES.
Eye Protection:ANSI APPROVED CHEM WORKERS GOGGS .
Other Protective Equipment:ANSI APPROVED EYE WASH FOUNTAIN & DELUGE
SHOWER . PLASTIC OR RUBBER APRON WHEN SPLASHING IS LIKELY TO OCCUR.
Work Hygienic Practices:WASH THOROUGHLY AFTER USE & BEFORE EATING,
DRINKING OR SMOKING.
Supplemental Safety and Health
HAZ DECOMP PROD:ALDEHYDES, ACIDS & TERPENES.

Boiling Pt:B.P. Text:170F,77C
Vapor Pres:40 @ 20C
Vapor Density:1.8
Spec Gravity:0.89 (H*2O=1)
VOC Pounds/Gallon:567
Evaporation Rate & Reference:1.8 (BUTYL ACETATE=1)
Solubility in Water:64%
Appearance and Odor:AMBER STICKY LIQUID W/ALCOHOL ODOR.

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING MATERIALS.
Stability Condition to Avoid:HEAT OR FLAME.
Hazardous Decomposition Products:WHEN HEATED TO SOLDERING TEMPS, SOLVS
ARE EVAPORATED & ROSIN MAY BE THERMALLY DEGRADED TO LIBERATE
ALIPHATIC (SUPP DATA)

Waste Disposal Methods:DISPOSE OF I/A/W LOCAL, STATE & FEDERAL
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.