Product ID:CHAIN & BAR LUBRICANT OIL
MSDS Date:04/02/1995
FSC:3695
NIIN:01-066-3722
Status Code:A
MSDS Number: CJDQH

SPECIALTY (WESTLAND) OIL COMPANY

2740 VALLEYVIEW DR
SHREVEPORT, LA 71148
US

Emergency Phone: 318-687-8000

Info Phone: 757-486-9251

Preparer: DENA HARLEES

Cage: 0A6L6

STIHL INC

VIRGINIA BEACH, VA 23452 US

Telephone: 757-486-9113

Cage: 9Z575

HYDROTREATED HEAVY NAPHTHENIC DISTILLATE

CAS: 64742-52-5

RTECS: PY8035000

OSHA PEL 5 MG/M3 (OIL MIST)

ACGIH TLV: 5 MG/M3 (OIL MIST)

DISTILLATES (PETROLEUM), HYDROTREATED LIGHT

CAS: 64742-53-6

RTECS: PY8036000

OSHA PEL 5 MG/M3 (OIL MIST)

ACGIH TLV: 5 MG/M3 (OIL MIST)

ADDITIVE PACKAGE

LD50 LC50 Mixture:LD50 (ORAL, RAT) > 5,000 MG/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS: EYES, SKIN. ACUTE- EYE
CONTACT: MAY CAUSE IRRITATION. SKIN CONTACT: PROLONGED OR REPEATED
CONTACT WITH THIS PRODUCT TENDS TO REMOVE SKIN OILS POSSIBLY
LEADING TO IRRITATION AND DERMATIT IS. HOWEVER, BASED ON HUMAN
EXPERIENCE AND AVAILABLE TOXICOLOGICAL DATA, THIS PRODUCT IS JUDGED
TO BE NEITHER A "CORROSIVE" NOR AN "IRRITANT" BY OSHA CRITERIA.
INHALATION: MISTS MAY CAUSE RESPIRATORY TRACT IRRITATION.
INGESTION: PRODUCT HAS LOW ORDER OF ACUTE ORAL AND DERMAL TOXICITY,
BUT MINUTE AMOUNTS ASPIRATED INTO LUNGS DURING INGESTION OR
VOMITING MAY CAUSE MILD TO SEVERE PULMONARY INJURY AN D POSSIBLE
DEATH. CHRONIC - UNKNOWN.
Explanation of Carcinogenicity:USED MOTOR OILS HAVE BEEN SHOWN TO CAUSE
SKIN CANCER IN MICE FOLLOWING REPEATED APPLICATION AND CONTINUOUS
EXPOSURE.
Effects of Overexposure:IRRITATION, COUGH, TEARING, NAUSEA
Medical Cond Aggravated by Exposure:NONE RECOGNIZED.

First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALATION: VAPOR
PRESSURE IS VERY LOW. VAPOR INHALATION UNDER AMBIENT CONDITIONS IS
NORMALLY NOT A PROBLEM. IF OVERCOME BY VAPOR FROM HOT PRODUCT OR
MISTS, IMMED IATELY REMOVE TO FRESH AIR. GIVE ARTIFICAL RESPIRATION
IF NOT BREATHING. IF BREATHING IS DIFFICULT, OXYGEN MAY BE GIVEN BY
QUALIFIED PERSONNEL. EYE CONTACT: IMMEDIATELY FLUSH WITH WATER FOR
AT LEAST 1 5 MINUTES. HOLD EYELIDS OPEN. SKIN: REMOVE CONTAMINATED
CLOTHING. WASH SKIN WITH SOAP & WATER. ORAL: DO NOT INDUCE
VOMITING. SEEK MEDICAL ATTENTION IMMEDIATELY. IF VOMITING OCCURS,
KEEP HEAD BELOW HIP S.

Flash Point Method:COC
Flash Point:>229.4C, 445.F
MINIMUM
Autoignition Temp:>315.6C, 600.F
Lower Limits:0.9%
Upper Limits:7%
Extinguishing Media:USE WATER SPRAY OR FOAM, DRY CHEMICAL, FOAM OR
CARBON DIOXIDE
Fire Fighting Procedures:WATER OR FOAM MAY CAUSE FROTHING. USE WATER TO
KEEP FIRE EXPOSED CONTAINERS COOL. WATER SPRAY MAY BE USED TO
FLUSH SPILLS AWAYFROM EXPOSURES. WEAR SUPPLIED-AIR BREATHING
EQUIPMENT FOR ENCLOSED OR CON FINED SPACES.
Unusual Fire/Explosion Hazard:TOXIC GASES MAY BE FORMED.

Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. PROVIDE ADEQUATE
VENTILATION. RECOVER FREE OIL. REMOVE SPILL WITH INERT ABORBENT
SUCH AS SAND, CLAY, EARTH. TRANSFER TO PROPER CONTAINERS FOR
DISPOSAL. PREVENT RUN-OFF TO EN TER SEWERS OR WATERWAYS. REPORT
SPILLS AS REQUIRED TO AUTHORITIES. ASSURE CONFORMITY WITH
APPLICABLE GOVERNMENTAL REGULATIONS.

Handling and Storage Precautions:STORE AT ROOM TEMPERATURE AWAY FROM
INCOMPATIBLES.
Other Precautions:EMPTY CONTAINERS RETAIN PRODUCT RESIDUES (VAPORS,
LIQUID, AND/OR SOLID) AND CAN BE DANGEROUS. DO NOT PRESSURIZE, CUT,
WELD, BRAZE, SOLDER OR DRILL. KEEP OUT OF REACH OF CHILDREN. AVOID
BREATHING VAPOR S OR MISTS. DO NOT GET IN EYE, ON SKIN OR ON
CLOTHING.

Respiratory Protection:NONE SHOULD BE NEEDED. A NIOSH-APPROVED
AIR-SUPPLIED RESPIRATOR SHOULD BE WORN IN CONFINED SPACES, IF
NEEDED.
Ventilation:GENERAL MECHANICAL VENTILATION IS ADEQUATE FOR NORMAL USE.
LOCAL EXHAUST IS RECOMMENDED FOR CONFINED AREAS.
Protective Gloves:RUBBER IF NEEDED
Eye Protection:CHEMICAL SAFETY GLASSES OR GOGGLES WHEN CONTACT MAY
OCCUR
Other Protective Equipment:EYE BATH, WASHING FACILITY, LAB COAT OR
UNIFORM.
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. WASH AFTER HANDLING AND BEFORE EATING,
DRINKING OR SMOKING.
Supplemental Safety and Health

HCC:V5
Boiling Pt:B.P. Text:N/D
Melt/Freeze Pt:=-17.8C, 0.F
M.P/F.P Text:POUR POINT ASTM D97
Vapor Pres:<.01MM HG@20C
Vapor Density:>5(AIR=1)
Spec Gravity:0.9200
Viscosity:151 CST @40C
Evaporation Rate & Reference:(N-BUTYL ACETATE=1) <.01
Solubility in Water:<0.1%
Appearance and Odor:CLEAR AND BRIGHT,MILD BLAND PETROLEUM OIL
Percent Volatiles by Volume:NEGLIGIBLE

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS SUCH AS LIQUID CHLORINE, CONCENTRATED OXYGEN,
SODIUM HYPOCHLORITE OR CALCIUM HYPOCHLORITE
Stability Condition to Avoid:EXCESSIVE HEAT
Hazardous Decomposition Products:FUMES, SMOKE, CARBON MONOXIDE, CARBON
DIOXIDE, SULFUR OXIDES AND OTHER DECOMPOSITION PRODUCTS MAY BE
FORMED.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. DISPOSE OF IN AN APPROVED INCINERATOR OR
CONTRACT WITH A LICENSED WASTE DISPOSAL SERVICE.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.