Product ID:INSULATING VARNISH,ELECTRICAL
MSDS Date:12/29/1997
FSC:5970
NIIN:00-990-4924
Status Code:A
MSDS Number: CLLHT

HUMISEAL DIVISION, COLUMBIA CHASE CORP.

26-60 BROOKLYN QUEENS EXPRESSWAY WEST
WOODSIDE, NY 11377-0445
US

Emergency Phone: 800-424-9300

Info Phone: 718-932-0800

Preparer: BOBBY STOKES

Cage: 0SR97

HUMISEAL DIVISION, COLUMBIA CHASE CORP.

445 WOODSIDE, NY 11377-0445 US

Telephone: 718-932-0800

Cage: 0SR97

SECTION 3A (SARA RQ)

TOLUENE

CAS: 108-88-3

RTECS: XS5250000

OSHA PEL see Table Z-2

ACGIH TLV: 188 MG/M3;50 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

METHYL ETHYL KETONE

CAS: 78-93-3

RTECS: EL6475000

OSHA PEL 590 MG/M3;200 PPM

ACGIH TLV: 590 MG/M3;200 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

ACRYLIC POLYMER

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Effects of Overexposure:EYES: SHORT TERM CONTACT MAY RESULT IN SLIGHT
EYE IRRITATION AND CONJUNCTIVITIS. PROLONGED CONTACT WITH LIQUID
CAN RESULT IN CORNEAL BURNS. HIGH VAPOR CONCENTRATIONS>APPROX.
1000PPM ARE IRRITATING TO THE EYES. SKIN: PROLONGED AND
REPEATED LIQUID CONTACT CAN CAUSE DEFATTING AND DRYING OF THE SKIN
WHICH MAY RESULT IN SKIN IRRITATION AND DERMATITIS. DERMAL LD (50)
(RABBITS) :>2000MG/KG.SKIN ABSORPTION MAY ADD SIGNIFICANTLY TO
EXPOSURE. INHALATION: DIZZINESS, WEAKNESS, HEADACHE, NAUSEA.
INGESTION: MODERATELY TOXIC; SERIOUS HAZARD POSED BY VOMITING.

First Aid:EYES: FLUSH WITH WATER FOR 15 MINUTES WHILE HOLDING EYELIDS
OPEN. GET MEDICAL ATTENTION: SKIN: FLUSH WITH WATER WHILE
REMOVING CONTAMINATED CLOTHING AND SHOES, FOLLOW BY WASHING WITH
SOAP AND WAT ER. DO NOT REUSE CLOTHING OR SHOES UNTIL PROPERLY
CLEANED. IF IRRITATION PERSISTA, GET MEDICAL ATTENTION.
INHALATION: REMOVE VICTIM TO FRESH AIR AND PROVIDE OXYGEN IF
BREATHING IS DIFFICULT. G IVE ARTIFICIAL RESPIRATION IF NOT
BREATHING. GET MEDICAL ATTENTION. INGESTION: DO NOT INDUCE
VOMITING. IF VOMITING OCCURS SPONTANEOUSLY, KEEP HEAD BELOW HIPS
TO PREVENT ASPIRATION OF LIQUID INTO LUNG S. GET MEDICAL ATTENTION
IMMEDIATELY

Flash Point Method:TCC
Flash Point:=-1.1C, 30.F
Lower Limits:1.6
Upper Limits:11.2
Extinguishing Media:FOAM, CARBON DIOXIDE AND DRY CHEMICAL
Fire Fighting Procedures:FIGHT AS A FLAMMABLE LIQUID FIRE; WEAR
SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:VAPOR IS FLAMMABLE AND HEAVIER THAN AIR
AND MAY TRAVEL TO SOURCE OF IGNITION AND FLASHBACK

Spill Release Procedures:ABSORB WITH INERT MATERIAL (SAND, VERMICULITE,
ETC.) LARGE SPILLS MAY BE SCOOPED UP WITH NON-SPARKING TOOLS..
REMOVE SOURCES OF IGNITION. PROVIDE VENTILATION AND/OR RESPIRATORY
PROTECTION.

Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS, AND OPEN
FLAMES. STORE AT AMBIENT TEMPERATURE. GROUND TO PROTECT FROM STATIC
CHARGE. KEEP CONTAINER CLOSED. USE ADEQUATE VENTILATION.
Other Precautions:PREVENT CONTACT TO WORKERS AS REQUIRED. IF MORE THAN
2 ML/KG HAS BEEN INGESTED, AND VOMITING HAS NOT OCCURRED, EMESIS
SHOULD BE INDUCED WITH SUPERVISION. KEEP VICTIM'S HEAD BELOW HIPS
TO PREVENT ASP IRATION. IF SYMPTOMS SUCH AS LOSS OF GAG REFLEX,
CONVULSIONS OR UNCONSCIOUSNESS OCCUR BEFORE EMESIS , GASTRIC
LAVARGE US

Respiratory Protection:RESPIRATOR-ORGANIC VAPOR TYPE IF TLV IS EXCEEDED
(NIOSH APPROVED).
Ventilation:YES; MECHANICAL: EXPLOSION PROOF.
Protective Gloves:IMPERVIOUS TO CHEMICAL AND PETROLEUM (BUNA-N, SOLVEX,
ETC.)
Eye Protection:CHEMICAL TYPE GOGGLES MUST BE WORN.
Other Protective Equipment:PREVENT CONTACT TO WORKERS AS REQUIRED.
Supplemental Safety and Health
KEEP AWAY FROM HEAT, SPARKS AND OPEN FLAMES. STORE AT AMBIENT
TEMPERATURE. GROUND TO PROTECT FROM STATIC CHARGE. KEEP CONTAINER
CLOSED. USE ADEQUATE VENTILATION.

Boiling Pt:=82.2C, 180.F
Vapor Pres:(MM HG) : 45.4.
Vapor Density:4(AIR=1)
Spec Gravity:(H20=1) : .88.
Evaporation Rate & Reference:(BUAC=1) : 3.62
Solubility in Water:NEGLIGIBLE-LESS THAN 0.1
Appearance and Odor:WATER CLEAR, LOW VISCOSITY LIQUID, AROMATIC ODOR.
Percent Volatiles by Volume:62-68

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE
Conditions to Avoid Polymerization:WILL NOT OCCUR

Waste Disposal Methods:DISPOSAL OF HUMISEAL PRODUCTS REQUIRES STRICT
COMPLIANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS PERTAINING TO
DISPOSING HAZARDOUS WASTE MATERIALS. CONTACT THE APPROPRIATE
ENVIRONMENTAL AGENCIES.

======================================================================
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.