Product ID:ELECTRO WASH C80, C16, C24, C240-4
MSDS Date:01/01/1991
FSC:6850
NIIN:00D000975
MSDS Number: BBDQP

CHEMTRONICS INC

8125 COBB CENTER DR
KENNESAW, GA 30144
US

Emergency Phone: 404-424-4888/800-424-9300(CHEMTREC)

Info Phone: 404-424-4888

Cage: 2M589

CHEMTRONICS INC (CANCELLED USE 21267)

HAUPPAUGE, NY 11760 US

Telephone: 770-424-4888/800-645-5244

Cage: 2M589

TRICHLOROTRIFLUOROETHANE (FREON 113) (SARA III)

CAS: 76-13-1

RTECS: KJ4000000

Fraction By Weight: 70%

OSHA PEL 1000PPM/1250STEL

ACGIH TLV: 1000PPM/1250STEL9192

CARBON DIOXIDE

CAS: 124-38-9

RTECS: FF6400000

OSHA PEL 5000 PPM

ACGIH TLV: 5000PPM/30000STEL;93

TRICHLOROFLUOROMETHANE (CFC-11) (SARA III)

CAS: 75-69-4

RTECS: PB6125000

OSHA PEL 1000 PPM

ACGIH TLV: C, 1000 PPM; 9293

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:YES
Health Hazards Acute and Chronic:INHALATION-VAPOR IS HEAVIER THAN AIR
AND CAN CAUSE SUFFOCATION BY REDUCING OXYGEN AVALIABLE FOR
BREATHING. EYE-LIQUID CONTACT CAN CAUSE DISCOMFORT. USUALLY NO
EXTENDED EFFECT. ORAL-ALTHOUGH ORAL TOXIC ITY IS LOW, INGESTION IS
TO BE AVOIDED.SKIN-REPEATED LIQUID CONTACT CAN CAUSE DEFATTING OF
THE SKIN.
Explanation of Carcinogenicity:COMPONENTS ARE NOT LISTED AS CARCINOGENS
BY IARC OR NTP. OSHA REGULATED-YES; OSHA AIR CONTAMINANT.
TOXIC-TES; LOW TOXIC
Effects of Overexposure:INHALATION-BREATHING HIGH CONCENTRATIONS OF
VAPOR CAN CAUSE LIGHT HEADEDNESS, GIGGINESS, SHORT OF BREATH & MAY
LEAD TO NARCOSIS, CARDIAC IRREGULARITIES, UNCONSCIOUSNESS & DEATH.
SKIN-IRRITATION OR RED NESS MAY OCCUR DUE TO DEFATTING.
INGESTION-MAY CAUSE NAUSEA & VOMITING. EYE-CONTACT MAY CAUSE
TEMPORARY DISCOMFORT.
Medical Cond Aggravated by Exposure:CARDIOVASCULAR DISEASE.

First Aid:INHALATION:REMOVE TO FRESH AIR & CALL A PHYSICIAN. IF NOT
BREATHING PERFORM CPR. IF BREATHING IS HARD GIVE OXYGEN. DO NOT
GIVE EPINEPHRINE OR SIMILAR DRUGS. SKIN:FLUSH WITH WATER.
INGESTION-NO SPECIFI C INTERVENTION IS INDICATED. HOWEVER, CONSULT
A PHYSICIAN IF NEEDED. DO NOT INDUCE VOMITING DUE TO ASPIRATION
HAZARD. EYE-IMMEDIATELY FLUSH WITH WATER FOR 15 MIN. SEEK MEDICAL
ATTENTION.

Flash Point:NONE,AEROSOL
Extinguishing Media:NONFLAMMABLE.
Fire Fighting Procedures:SELF-CONTAINED BREATHING APPARATUS (SCBA) MAY
BE REQUIRED IF CONTAINERS RUPTURE & CONTENTS ARE RELEASED UNDER
FIRE CONDITIONS.
Unusual Fire/Explosion Hazard:PRESSURIZED AEROSOL CONTAINERS MAY VENT,
RUPTURE OR EXPLODE AND ADD TO FYLING AND FALLING DEBRIS.
DECOMPOSITION MAY OCCUR.

Spill Release Procedures:VENTILATE AREA. REMOVE OPEN FLAMES OR OTHER
SOURCES OF IGNITION.. COLLECT SPILLED PRODUCT WITH ABSORBENT
MATERIAL AND PLACE IN CLOSED STEEL DRUMS FOR PROPER DISPOSAL.

Handling and Storage Precautions:DO NOT STORE NEAR SOURCES OF HEAT, IN
DIRECT SUNLIGHT, OR WHERE TEMPERATURES EXCEEED 120F. DO NOT
PUNCTURE OR DAMAGE CONTAINERS. ROTATE STOCK.
Other Precautions:THIS PRODUCT CONTAINS THE FOLLOWING TOXIC CHEMICALS
SUBJECT TO THE REPORTING REQUIREMENTS OF SECTION 313 OF THE
EMERGENCY PLANNING & COMMUNITY RIGHT TO KNOW ACT OF 1986: 70%,
TRICHLOROTRIFLUOROETHANE, CAS# 76-13-1.

Respiratory Protection:NO; GOOD VENTILATION/H.C. RESPIRATOR.
Ventilation:NO; AS NEEDED TO COMPLY WITH TLV.
Protective Gloves:YES; BUTYL GLOVES.
Eye Protection:YES; CHEMICAL SPLASH GOGGLES.
Other Protective Equipment:YES; EYE BATH AND PROTECTIVE CLOTHING.
Work Hygienic Practices:NORMAL VENTILATION FOR STANDARD PROCEDURES;
LOCAL EXHAUST FOR LARGE RELEASES; MECHANICAL VENTILATION IN LOW
PLACES.
Supplemental Safety and Health
NOTE TO PHYSICAN: BECAUSE OF THE POSSIBLE INCREASED RISK OF ELICITING
CARDIAC ADYSRYTHMIAS, CATECHOLINAMINE DRUGS, SUCH AS EPINEPHRINE,
SHOULD BE USED ONLY AS A LAST RESORT IN LIFE THREATENING EMERGE
NCIES.

HCC:V2
Boiling Pt:=23.9C, 75.F
Vapor Pres:334 MMHG
Vapor Density:4.6 @77F
Spec Gravity:1.46
Evaporation Rate & Reference:>1 (BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:COLORLESS LIQUID, FAINT SOLVENT ODOR.

Stability Indicator/Materials to Avoid:YES
ALKALI & ALKALINE EARTH METAL-POWDERED ALUMINUM, BERYLLIUM, ZINC, AND
MAGNESIUM.
Stability Condition to Avoid:AVOID SPRAYING NEAR OPEN FLAMES OR RED HOT
SURFACES. DO NOT HEAT AEROSOL CONTAINERS ABOVE 120F/49C.
Hazardous Decomposition Products:COMPOUND CAN BE DECOMPOSED BY HIGH
TEMPERATURES FORMING HYDROCHLORIC & HYDROFLUORIC ACIDS & POSSIBLY
CARBONYL HALIDES.

Waste Disposal Methods:COMPLY WITH ALL FEDERAL, TATE, & LOCAL
REGULATIONS. DO NOT PUNCTURE OR INCINERATE AEROSOL CANS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.