Product ID:189S ADDITIVES FOR TOPCOATS
MSDS Date:04/01/1991
FSC:8010
NIIN:00F000442
MSDS Number: BBGQL

EI DUPONT/AUTOMOTIVE PRODS DEPT

1007 MARKET ST BRANDYWINE BLDG 3332
WILMINGTON, DE 19898
US

Emergency Phone: (800) 441-7515

Info Phone: (800) 441-7515

Cage: EO478

EI DUPONT/AUTOMOTIVE PRODS DEPT

WILMINGTON, DE 19898 US

Telephone: (800) 441-7515

Cage: EO478

DIBUTYLTIN DILAURATE

CAS: 77-58-7

RTECS: WH7000000

Fraction By Weight: 0.07%

OSHA PEL 0.1 MG/CUM (SN)

ACGIH TLV: 0.1 MG/CUM, SN(SKIN)

2,4-PENTANEDIONE

CAS: 123-54-6

RTECS: SA1925000

7.20-11.41

RTECS: 9999999WG

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INGESTION: GASTROINTESTINAL DISTRESS.
INHALATION: NOSE/THROAT IRRITATION, EYE WATERING, HEADACHES,
NAUSEA, DIZZINESS & LOSS OF COORDINATION. EYES: IRRITATION OR
BURNING. SKIN: IRRITATION, DISCOMFORT & DERMATITIS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INGESTION: GASTROINTESTINAL DISTRESS.
INHALATION: PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE. EYES:
IRRITATION OR BURNING. SKIN: IRRITATION, DISCOMFORT & DERMATITIS.

First Aid:INHALATION: REMOVE TO FRESH AIR. EYES: FLUSH W/PLENTY OF
WATER FOR AT LEAST 15 MINS. SKIN: WASH W/SOAP & WATER. INGESTION:
OBTAIN MEDICAL ATTENTION IN ALL CASES.

Flash Point Method:CC
Flash Point:100F
Lower Limits:0.9%
Upper Limits:13.1%
Extinguishing Media:WATER SPRAY, FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:USE FULL PROTECTIVE EQUIP & SCBA. USE WATER
FROM FOG NOZZLES TO COOL CLOSED CONTAINERS TO PREVENT PRESSURE
BUILD UP.
Unusual Fire/Explosion Hazard:WHEN HEATED >100F, EMITS FLAMMABLE VAPORS
WHICH, WHEN MIXED W/AIR CAN BURN OR BE EXPLOSIVE. FINE MISTS/SPRAYS
MAY BE FLAMMABLE AT TEMPS <100F.

Spill Release Procedures:VENTILATE AREA. REMOVE SOURCES OF IGNITION.
CONFINE & REMOVE W/INERT ABSORBENT.

Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS & OPEN
FLAME. DON'T STORE >120F. CLOSE CONTAINER AFTER EACH USE. GROUND
CONTAINERS WHEN POURING. OBSERVE LABEL PRECAUTIONS
Other Precautions:DON'T SAND, FLAME CUT, BRAZE OR WELD DRY COATING
W/OUT A NIOSH/MSHA APPROVED RESPIRATOR OR APPROPRIATE VENTILATION.
AVOID CONTACT W/SKIN & BREATHING OF VAPOR OR MISTS. DON'T PERMIT
ANYONE W/OUT PROTEC TION IN THE PAINTING AREA.

Respiratory Protection:FOR USE W/PAINTS DURING APPLICATION & UNTIL ALL
VAPORS/SPRAY MISTS ARE EXHAUSTED USE A PROPERLY FITTED
VAPOR/PARTICULATE RESPIRATOR NIOSH/MSHA (TC-23). IN CONFINED SPACES
USE A POSITIVE PRESSURE SUPPL IED AIR RESPIRATOR (TC-19C).
Ventilation:SUFFICIENT IN VOLUME & PATTEN TO KEEP Protective Gloves:NEOPRENE
Eye Protection:SPLASH GUARDS, SIDE SHIELDS
Other Protective Equipment:COVERALLS
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING & BEFORE EATING
OR SMOKING.
Supplemental Safety and Health
BOILING RANGE: 167-374F. VOLATILE PERCENT BY WEIGHT: 41.8-99.9%

Boiling Pt:B.P. Text:SEE SUPP
Vapor Density:>AIR
Evaporation Rate & Reference:LESS THAN ETHER
Solubility in Water:MISCIBLE
Percent Volatiles by Volume:53-99%

Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME, TEMPS >120F OR
OTHER SOURCES OF IGNITION
Hazardous Decomposition Products:CO, CO2, SMOKE

Waste Disposal Methods:DON'T ALLOW MATERIAL TO CONTAMINATE GROUND WATER
SYSTEMS. INCINERATE ABSORBED MATERIAL IN ACCORDANCE W/FEDERAL,
STATE & LOCAL REQUIREMENTS. DON'T INCINERATE IN CLOSED CONTAINERS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.