Product ID:03-GY-52 BASE,GRAY 16440,POLYURETHANE
MSDS Date:01/01/1985
FSC:8010
NIIN:00K001217
Kit Part:Y
MSDS Number: BCCKM

DEFT CHEMICAL COATINGS

17451 VON KARMAN AVE
IRVINE, CA 92714-6205
US

Cage: EO418

DEFT, INC.

IRVINE, CA 92614 US

Telephone: 949-474-0400

Cage: 33461

TOLUENE (SARA III)

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 5.0%

OSHA PEL 200 PPM/150 STEL

ACGIH TLV: 50 PPM; 9293

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

N-BUTYL ACETATE (SARA III)

CAS: 123-86-4

RTECS: AF7350000

Fraction By Weight: 5.0%

OSHA PEL 150 PPM/200 STEL

ACGIH TLV: 150 PPM/200STEL;9192

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

2-ETHOXYETHYL ACETATE (CELLOSOLVE ACETATE) (EGEEA)

CAS: 111-15-9

RTECS: KK8225000

Fraction By Weight: 15.0%

OSHA PEL S,100 PPM

ACGIH TLV: S, 5 PPM; 9192

METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 20.0%

OSHA PEL 200 PPM/300 STEL

ACGIH TLV: 200 PPM/300STEL 9192

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

SC150 HIGH BOILING AROMATIC HYDROCARBON (<5.0% WT)

Fraction By Weight: 5.0%

Effects of Overexposure:YES:MODERATE IRRIT;SKIN:POSSIBLE IRRIT BY
SOLVENTS;INH:SOLVENT VAPORS CAN CAUSE IRRIT OR NARCOSIS

First Aid:SKIN:WIPE OFF WITH A RAG THEN THOROUGH RINSING W/H*2O &
WASHING W/MILD SOAP AND WATER;EYES:FLUSH W/WATER FOR AT LEAST 10
MIN & CONSULT AN EYE PHYSICIAN;INH:REMOVE TO FRESH AIR.GIVE
CPR/OXYGEN IF NEEDE D.

Flash Point:28F(-2.2C)-OC
Extinguishing Media:CO*2, FOAM, DRY CHEM & H*2O FOG.
Fire Fighting Procedures:USE SELF-CNTND BRTHNG APP;CAN USE H*2O SPRAY
EFFECTIVLY.
Unusual Fire/Explosion Hazard:CAUTION AGAINST APPLICATION TO HOT
SURFACES & USE IN AREAS WHERE SOURCES OF IGNITION MAY BE PRESENT.

Spill Release Procedures:EVACUATE UNPROTCTD PERSONS.ELIM IGN
SOURCES.USE SAFETY EQUIP.VENTILATE AREA.STOP LEAK W/O RISK;ABSORB
SM SPILL W/OIL ABSORBING COMPD/RAGS.PER MFR,FLUSH AREA W/LG AMT
H*2O;DIKE LG SPILL.PUMP LIQ TO SAL VAGE TANK.SHOVEL UP RESIDUE INTO
COVERED CONTNRS.

Handling and Storage Precautions:STORE IN COOL,DRY,WELL VENT,LOW FIRE
RISK AREA. PROTECT FROM PHYSICAL DAMAGE.AVOID ANY PHYSICAL CONTACT.
KEEP CONTAINERS TIGHTLY CLOSED.
Other Precautions:AVOID PROLONGED INHALATION OF VAPORS.IF VENTILATION
IS POOR,USE A FRESH AIR SUPPLY MASK.

Respiratory Protection:GOOD VENTILATION,PER MFR;MAY USE NIOSH APPRVD
RESP FOR PAINT IF REQD
Ventilation:MECH(GEN)OR LOCAL EXHAUST THAT PROVIDES ADEQUATE
VENTILATION
Protective Gloves:RUBBER/NEOPRENE
Eye Protection:SAFETY/CHEM GOGGLES
Other Protective Equipment:AS REQUIRED TO PREVENT PROLONGED CONTACT.
Supplemental Safety and Health
MSDS DATED 11/74: TWO PART RESIN MODIFIED POLYURETHANE COATING: THIS IS
OR BASE: SEE P/N IND "B" FOR CATALYST: ALSO CONTAINS APPROX 50%
NON-AQUEOUS SOLUTION, HAZ UNK, UNIDENTIFIED. KEY1: J1.

Vapor Density:>1.0
Spec Gravity:1.1731
Evaporation Rate & Reference:<1(ALWR THAN ETHR)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR THIN ORGANIC LIQ MIXTUR-ODOR OF MEK
Percent Volatiles by Volume:62.4

Stability Indicator/Materials to Avoid:YES
OXIDIZERS, CORROSIVES, PEROXIDES
Stability Condition to Avoid:SHOCK,HEAT,IGNITION SOURCES
Hazardous Decomposition Products:CO*2, CO, TOXIC OXIDES.

Waste Disposal Methods:KEEP IN CLOSED CONTNRS PENDING DISPOSAL.MFR
SUGGESTED,DISPOSE IN TIGHTLY CLOSED CONTAINERS & FINALLY DISPOSE BY
SANITARY LANDFILL IAW APPLICABLE REGS;HANDLE & DISPOSE IN FULL
COMPLIANCE W/ALL FED,STAT E,& LOCAL REGULATIONS CONCERNING WASTE
DISPOSAL

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.