Product ID:LXP-16A CATALYST,EPOXY-AMINE PRIMER
MSDS Date:01/01/1985
FSC:8010
NIIN:00K001223
Kit Part:Y
MSDS Number: BCCKY

DEFT CHEMICAL COATING

17451 VON KARMAN AVE
IRVINE, CA 92714-6205
US

Cage: EO418

DEFT, INC.

IRVINE, CA 92614 US

Telephone: 949-474-0400

Cage: 33461

XYLENES (O-,M-,P- ISOMERS) (SARA III)

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: 5.0%

OSHA PEL 100 PPM/150 STEL

ACGIH TLV: 100 PPM/150STEL;9192

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

TOLUENE (SARA III)

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 5.0%

OSHA PEL 200 PPM/150 STEL

ACGIH TLV: 50 PPM; 9293

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

Effects of Overexposure:EYES:MODERATE IRRIT;SKIN:POSSIBLE IRRIT BY
SOLVENTS;INH:SOLVENT VAPORS CAN CAUSE IRRIT OR NARCOSIS.

First Aid:SKIN:WIPE OFF WITH A RAG THEN THOROUGH RINSING W/H*2O &
WASHING W/MILD SOAP AND WATER;EYES:FLUSH W/WATER FOR AT LEAST 10
MIN & CONSULT AN EYE PHYSICIAN;INH:REMOVE TO FRESH AIR.GIVE
CPR/OXYGEN IF NEEDE D.

Flash Point:28F(-2.2C)-TOC
Lower Limits:UNK
Extinguishing Media:CO*2,DRY CHEM,FOAM
Fire Fighting Procedures:DO NOT USE H*2O STREAM ON FIRE.H*2O STRAY/FOG
IS MORE EFFCTV
Unusual Fire/Explosion Hazard:CAUTION AGAINST APPLICATION TO HOT
SURFACES & USE IN AREASWHERE SOURCES OF IGNITION MAY BE PRESENT

Spill Release Procedures:EVACUATE UNPROTECTED PERSONS.ELIM IGN
SOURCES.USE SAFETY EQUIP.VENTLATE AREA.STOP LEAK W/O RISK.ABSORB SM
SPILL W/OIL ABSORBNG COMPD/RAGS;DIKE LG SPILL.PUMP LIQ TO SALVAGE
TANK.SHOVEL UP RESIDUE INTO COVRD DRUMS;PER MFR,FLUSH AREA W/LG
AMOH*2O.

Handling and Storage Precautions:STORE IN COOL,WELL VENTILATED,LOW FIRE
RISK AREA.KEEP CONTNRS TIGHTLY CLOSED.KEEP AWAY FM HEAT,SPARK OR
OPEN FLAME.
Other Precautions:AVOID PROLONGED INHALATION OF VAP.PER MFR,WATER SPRAY
OR FOG CAN BE USED EFFECTIVELY ON FIRE AND TO COOL HEAT/FIRE
EXPOSED CONTNRS.

Respiratory Protection:GOOD VENTILATION IS NEEDED.HOWEVER USE NIOSH
APPRVD SCBA FOR PAINTS.
Ventilation:USE ADEQUATE VENTILATION USING EXHAUST FAN.
Protective Gloves:IMPERVIOUS
Eye Protection:SAFETY/CHEM GOGGLES
Other Protective Equipment:AS REQD TO PREVENT PROLONGED OR REPEATED
CONTACT.
Supplemental Safety and Health
MSDS FM MFR DATE: 10/16/80: TWO PART RESIN MODIFIED POLYURETHANE
COATING: THIS DATA DESCRIVES CATALYST: SEE P/N IND "B" FOR OTHER
INGRED & P/N IND "A" FOR BASE, SAME NSN: SPEC REF: LAC-C37 1045B.
KEY1 :J 1.

Boiling Pt:B.P. Text:175-313F
Vapor Pres:UNK
Vapor Density:>1.0
Spec Gravity:0.8400
Evaporation Rate & Reference:<1(SLWR THAN ETHER
Solubility in Water:NEGLIGIBLE
Appearance and Odor:WATER WHITE CLEAR ORGANIC LIQ-ODOR OF MEK.
Percent Volatiles by Volume:96.4

Stability Indicator/Materials to Avoid:YES
OXIDIZING & CORROSIVE MATERIALS.
Stability Condition to Avoid:SOURCE OF IGN,SPARK,HEAT & OPEN FLAME

Waste Disposal Methods:KEEP IN CLOSED CONTNRS PENDING DISPOSAL.MFR
SUGGESTED,DISPOSE IN TIGHTLY CLOSED CONTAINERS & FINALLY DISPOSE BY
SANITARY LANDFILL IAW APPLICABLE REGS;HANDLE & DISPOSE IN FULL
COMPLIANCE W/ALL FED,STAT E,& LOCAL REGULATIONS CONCERNING WASTE
DISPOSAL.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.