Product ID:B54 R28 SAFETY RED
MSDS Date:10/10/1987
FSC:8010
NIIN:00F007113
MSDS Number: BHBMC

SHERWIN-WILLIAMS COMPANY

101 PROSPECT AVENUE N.W.
CLEVELAND, OH 44115

Emergency Phone: (216) 566-2917

Info Phone: (216) 566-2917

Cage: 54636

SHERWIN-WILLIAMS CO THE

CLEVELAND, OH 44115-1042 US

Telephone: 800-251-2486/216-566-2242

Cage: 54636

HYDROTREATED LIGHT DISTILLATE, PETROLEUM

CAS: 64742-47-8

Fraction By Weight: 35-45%

OSHA PEL 500 PPM

ACGIH TLV: 100 PPM

ETHYLENE GLYCOL (SARA III)

CAS: 107-21-1

RTECS: KW2975000

Fraction By Weight: 0-5%

OSHA PEL C 50 PPM

ACGIH TLV: C 50 PPM,VAPOR; 9192

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

TITANIUM DIOXIDE

CAS: 13463-67-7

RTECS: XR2275000

Fraction By Weight: 0-25%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST; 9293

Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHALATION: IRRITATION OF EYES,
RESPIRATORY SYSTEM, HEADACHE, DIZZINESS, NAUSEA, LOSS OF
COORDINATION, NERVOUS SYSTEM DEPRESSION, UNCONSCIOUSNESS, &
POSSIBLY DEATH. EYE/SKIN: REDNESS, ITCHING, & BURN SENSATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: UNCONSCIOUSNESS & POSSIBLY DEATH,
HEADACHE, DIZZINESS, NAUSEA & LOSS OF COORDINATION. PROLONGED
OVEREXPOSURE MAY CAUSE ADVERSE EFFECTS TO LIVER, URINARY,
REPRODUCTIVE SYSTEM, PERMANENT BRA IN & NERVOUS SYSTEM DAMAGE.
IRRITATION TO RESPIRATORY SYSTEM. SKIN/EYE: REDNESS/ITCHING &
BURNING SENSATION.
Medical Cond Aggravated by Exposure:ETHYLENE GLYCOL IS CONSIDERED AN
ANIMAL TERATOGEN.IT HAS BEEN SHOWN TO CAUSE BIRTH DEFECTS IN
RATS/MICE AT HIGH DOSES WHEN GIVEN IS DRINKING WATER OR BY GAVAGE.

First Aid:INHALATION: REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP
WARM & QUIET. SKIN: WASH AFFECTED AREA THOROUGHLY W/SOAP & WATER.
REMOVE CONTAMINATED CLOTHING & LAUNDER BEFORE REUSE. EYES: FLUSH
W/LARGE AMO UNTS OF WATER FOR 15 MINUTES. GET MEDICAL ATTENTION.

Flash Point Method:PMCC
Flash Point:101F
Lower Limits:1.0%
Extinguishing Media:CO2, DRY CHEMICAL, FOAM
Fire Fighting Procedures:FULL PROTECTIVE EQUIPMENT/SCBA. WATER SPRAY
MAY BE INEFFECTIVE. IF WATER IS USED, FOG NOZZLES ARE PREFERABLE.
KEEP CONTAINER TIGHTLY CLOSED.
Unusual Fire/Explosion Hazard:WATER MAY BE USED TO COOL CLOSED
CONTAINERS TO PREVENT PRESSURE BUILD-UP/AUTOIGNITION/EXPLOSION WHEN
EXPOSED TO EXTREME HEAT. ISOLATE FROM HEAT/SPARKS/FLAMES.

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE &
REMOVE W/INERT ABSORBENT.

Handling and Storage Precautions:CONTENTS ARE COMBUSTIBLE. KEEP AWAY
FROM HEAT/OPEN FLAME/HOT SURFACES. AVOID BREATHING VAPOR/SPRAY
MISTS. AVOID CONTACT W/SKIN & EYES.
Other Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE. KEEP OUT OF
THE REACH OF CHILDREN. INTENTIONAL MISUSE BY CONCENTRATING &
INHALING THE CONTENTS CAN BE HARMFUL OR FATAL. WASH HANDS AFTER
USING. DON'T TAKE INTERN ALLY.

Respiratory Protection:WEAR A VAPOR/PARTICULATE RESPIRATOR APPROVED BY
NIOSH/MSHA FOR PROTECTION.
Ventilation:PROVIDE LOCAL EXHAUST/MECHANICAL VENTILATION TO KEEP Protective Gloves:RECOMMENDED
Eye Protection:SAFETY SPECTACLES W/SIDESHIELDS.
Work Hygienic Practices:AVOID CONTACT W/SKIN & EYES. REMOVE/LAUNDER
CONTAMINATED CLOTHING BEFORE REUSE. AVOID BREATHING VAPOR/SPRAY
MIST.
Supplemental Safety and Health
WT PER GAL: 8-10 LBS. THIS COATING MAY CONTAIN MATERIALS CLASSIFIED AS
NUISANCE PARTICULATES, SUCH AS TITANIUM DIOXIDE OR CALCIUM
CARBONATE WHICH MAY BE PRSENT AT HAZARDOUS LEVELS ONLY DURING
SANDING OR ABRADING OF THE DRIED FILM.

Boiling Pt:B.P. Text:395F
Vapor Density:>AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:60%

Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT, SPARKS, HOT SURFACES & OPEN FLAME.
Hazardous Decomposition Products:CO2, CO, OXIDES OF METALS

Waste Disposal Methods:WASTE MUST BE TESTED IGNITABILITY &
EXTRACTABILITY TO DETERMINE THE APPLICABLE EPA HAZARDOUS WASTE
NUMBERS. INCINERATE IN APPROVED FACILITY. DON'T INCINERATE CLOSED
CONTAINER. DISPOSE OF IN ACCORDANCE W/FEDERAL, STATE & LOCAL
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.