Product ID:602, FEATHER FILL HARDENER
MSDS Date:08/29/1988
FSC:8040
NIIN:01-091-3748
MSDS Number: BHBVF

FIBRE GLASS-EVERCOAT CO.,INC.

6600 CORNELL ROAD
CINCINNATI, OH 45242-2033
US

Emergency Phone: 800-543-4530

Info Phone: 513-489-7600

Cage: 18731

FIBRE GLASS-EVERCOAT CO INC

CINCINNATI, OH 45242 US

Telephone: 513-489-7600

Cage: 18731

METHYL ETHYL KETONE PEROXIDE (MEKP) (SARA III)

CAS: 1338-23-4

RTECS: EL9450000

Fraction By Weight: 50%

OSHA PEL C 0.7 PPM

ACGIH TLV: C 0.2; 9394

EPA Report Quantity: 10 LBS

DOT Report Quantity: 10 LBS

DIMETHYLPHTHALATE (SARA III)

CAS: 131-11-3

RTECS: TI1575000

Fraction By Weight: 50%

OSHA PEL 5 MG/M3

ACGIH TLV: 5 MG/M3; 9192

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

LD50 LC50 Mixture:LD50 (ORAL RAT) IS 484 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: HARMFUL IF SWALLOWED, INHALED
OR ABSORBED THROUGH SKIN. MATERIAL IS EXTREMELY DESTRUCTIVE TO
TISSUE OF THE MUCOUS MEMBRANES AND UPPER RESPIRATORY TRACT, EYES
AND SKIN. INHALATION MAY BE FATAL A S A RESULT OF SPASM,
INFLAMMATION AND EDEMA OF THE LARYNX AND BRONCHI, CHEMICAL
PHEUMONITIS AND PULMONARY EDEMA.
Explanation of Carcinogenicity:THIS COMPOUND IS NOT LISTED BY IARC,
NTP, OR OSHA AS A CARCINOGEN.
Effects of Overexposure:MAY INCLUDE BURNING SENSATION, COUGHING,
WHEEZING, LARYNGITIS, SHORTNESS OF BREATH, HEADACHE, NAUSEA AND
VOMITING.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF AILMENTS
OR WITH A PRE-EXISTING DISEASE INVOLVING THE EYES, SKIN, OR
RESPIRATORY TRACT MAY BE AT INCREASED RISK FROM EXPOSURE.

First Aid:EYES:IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR 15 MINUTES
HOLDING EYELIDS OPEN. GET IMMEDIATE MEDICAL ATTENTION. SKIN:REMOVE
CONTAMINATED CLOTHING. WASH WITH SOAP AND WATER. GET MEDICAL
ATTENTION. I NGESTION:DO NOT INDUCE VOMITING. GIVE NOTHING BY
MOUTH IF UNCONSCIOUS. GET IMMEDIATE MEDICAL ATTENTION. INHALATION:
REMOVE TO WELL VENTILATED AREA. IF BREATHING STILL DIFFICULT, CALL
A PHYSICIAN.

Flash Point Method:TCC
Flash Point:180F,82C
Extinguishing Media:USE CARBON DIOXIDE, FOAM, DRY CHEMICAL, OR WATER
FOG.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:CONTAINERS MAY BURST WHEN EXPOSED TO HEAT
OF FIRE.

Spill Release Procedures:COVER WITH DRY LIME, SAND, OR SODA ASH. PLACE
IN COVERED CONTAINERS USING NONSPARKING TOOLS AND TRANSPORT
OUTDOORS. SHUT OFF ALL SOURCES OF IGNITION. EVACUATE AREA.
VENTILATE AREA & WASH SPILL SITE AF TER MATERIAL PICKUP IS
COMPLETE.
Neutralizing Agent:DRY LIME

Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
AREA AWAY FROM DIRECT SUNLIGHT. KEEP CONTAINERS TIGHTLY CLOSED WHEN
NOT IN USE. STORE IN ORIGINAL CONTAINERS.
Other Precautions:DO NOT TAKE INTERNALLY. DO NOT BREATHE MIST. AVOID
ALL CONTACT. MAY DEVELOP PRESSURE. VENT PERIODICALLY. REFRIGERATE.
USE WITH ADEQUATE VENTILATION. WASH THOROUGHLY AFTER HANDLING. FOR
INDUSTRIAL USE ONLY.

Respiratory Protection:IF VENTILATION DOES NOT MAINTAIN INHALATION
EXPOSURES BELOW PEL(TLV), USE NIOSH/MSHA APPROVED ORGANIC VAPOR
CARTRIDGE AND DUST/MIST PRE-FILTER RESPIRATORS AS PER CURRENT 29
CFR 1910.134, INSTRUCTIONS/ WARNINGS AND NIOSH-RESPIRATOR
SELECTION.
Ventilation:MECHANICAL (GENERAL) ROOM VENTILATION IS REQUIRED. LOCAL
EXHAUST MAY BE REQUIRED IF WORK AREA NOT VENTILATED.
Protective Gloves:CHEMICAL RESISTANT POLYETHYLENE
Eye Protection:CHEMICAL SPLASH GOGGLES WITH FACE SHIELD
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED. RUBBER BOOTS
RECOMMENDED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. REMOVE AND WASH CONTAMINATED CLOTHING
PROMPTLY.
Supplemental Safety and Health
KEY1: R1-D2. PART B OF A TWO PART KIT. SEE P/N IND A, THIS NSN, FOR
ADDITIONAL INFORMATION.

HCC:V4
Boiling Pt:B.P. Text:DECOMPOSES
Vapor Density:>1
Spec Gravity:1.15
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR, COLORLESS LIQUID, MILD ODOR.
Percent Volatiles by Volume:100

Stability Indicator/Materials to Avoid:YES
METALLIC CONTAMINATION, AMINES, ORGANIC METAL SALTS.
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, OPEN FLAMES,
DIRECT SUNLIGHT, STATIC ELECTRICITY AND CONFINEMENT UNDER PRESSURE.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE

Waste Disposal Methods:DISPOSAL SHOULD BE MADE IN ACCORDANCE WITH ALL
APPLICABLE FEDERAL, STATE AND LOCAL LAWS AND REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.