Product ID:NICROBRAZ CEMENT 300
MSDS Date:03/28/1989
FSC:3439
NIIN:01-159-2207
MSDS Number: BHBXT

CX

WALL COLMONOY CORP.
MADISON HEIGHTS, MI 48071

Emergency Phone: 313-585-6400

Info Phone: 313-585-6400

Cage: NO091

WALL COMPANY CORP

MADISON HEIGHTS, MI 48071 US

Telephone: 313-585-6400

Cage: 63585

METHYL CHLOROFORM (1,1,1-TRICHLOROEHANE) (SARA III)

CAS: 71-55-6

RTECS: KJ2975000

Fraction By Weight: 77%.

OSHA PEL 350 PPM/450 STEL

ACGIH TLV: 350 PPM/450STEL;9192

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

NON-HAZARDOUS RESIN(WHICH IS A 'TRADE SECRET')

Fraction By Weight: 23%.

PER CALIFORNIA RULE 1107, PARAG. 3 & 15,

RTECS: 9999999V0

LD50 LC50 Mixture:LD50(ORAL RAT) 10300 MG/KG; LC50 1000PPM
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: 'CNS' DEPRESSANT, RESPIRATORY
SYSTEM IRRITANT, AS WELL AS EYE/SKIN IRRITANT. CHRONIC: LIVER &
KIDNEY TOXIN UPON PROLONGED EXPOSURE ABOVE EXPOSURE LIMITS.
EXPOSURE TO HIGH-CONCENTRATIONS IN A CO NFINED OR POORLY VENTED
AREA MAY CAUSE DEATH.
Effects of Overexposure:INHAL: HEADACHE, DIZZINESS, STUPOR,
NAUSEA(VOMITING, FATIGUE, RESPIRATORY SYSTM IRRITATION,
LIGHT-HEADNESS, COORDINATION & EQUILIBRIUM LOSS; EYE: IRRITATION,
REDNESS; SKIN: IRRITATION, DERMATITIS, RED NESS; INGEST: NAUSEA,
VOMITING.
Medical Cond Aggravated by Exposure:LIVER DISEASE & RYYTHMM DISORDERS
OF THE HEART. NOTE: HEART MAY BE SENSITIZED BY OVER-EXPOSURE &
VENTRICULAR ARRHYTHMIA MAY BE INDUCED BY EPINEOPHRINE
ADMINISTRATION.

First Aid:INHAL: MOVE PERSON TO FRESH AIR. IF UNCONSCIOUS, GIVE
ARTIFICIAL RESPIRATAIN OR 02 AS SITUATION DICTATES; EYES: FLUSH
W/WATER AT LEAST 15 MIN. SEEK MED. ATTN.; SKIN: WASH W/PLENTY OF
SOAP & WATER; ING EST: DO NOT INDUCE VOMITING. SEEK IMMEDIATE
MEDICAL ATTENTION.

Flash Point Method:TCC
Flash Point:NONE
Lower Limits:8.0
Upper Limits:10.5
Extinguishing Media:FIRE UNLIKELY, BUT IF IT OCCURS, CAN BE CONTROLLED
BY CARBON DIOXIDE, DRY CHEMICALS OR WATER FOG.
Fire Fighting Procedures:SELF-CONTAINED RESPIRATORY PROTECTION.
CONTAINERS EXPOSED TO FIRE SHOULD BE KEPT COOL W/WATER SPRAY.
Unusual Fire/Explosion Hazard:VAPORS CAN BE DECOMPOSED BY INTENSE HEAT
OR OPEN FLAMES TO RELEASE HCL OR PHOSGENE.

Spill Release Procedures:UP W/ABSORBENT MATERIAL, PLACE IN CLOSED
CONTAINER, LABEL & STORE IN SAFE PLACE UNTIL DISPOSAL.

Handling and Storage Precautions:KEEP TIGHTLY CLOSED, IN A COOL, WELL
VENTILATED AREA.DONOT STORE IN PITS OR BASEMENTS. KEEP IN LABELLED
CONTAINER.
Other Precautions:AVOID WELDING, OPEN FLAMES & INFRA-RED HEATERS. DONOT
STORE IN ALUMINUM CONTAINERS.

Respiratory Protection:NOT REQUIRED IF USED W/GOOD VENTILATION. IF
ENGINEERING CONTROLS DO NOT KEEP INHALATION EXPOSURES BELOW
PEL/TLV, USE NIOSH/MSHA APPROVED RESPIRATORS PER CURRENT
29CFR1910.134,INSTRUCTIONS/WARNING & NI OSH-RESPIRATOR DECISION
LOGIC.
Ventilation:PROVIDE SUFFICIENT GENERAL/LOCAL EXHAUST VENTILATION IN
PATTERN/VOLUME TO CONTROL INHALATION EXPOSURE BELOW PEL/TLV.
Protective Gloves:POLYVINYL ALCOHOL TYPE/ NEOPRENE.
Eye Protection:AS REQUIRED FOR TASK AT HAND(CHM GOGGLES
Other Protective Equipment:AS REQUIRED FOR TASK AT HAND TO *MINIMIZE
EXPOSURE.
Work Hygienic Practices:AVOID REPEATED CONTACT W/SKIN OR PROLONGED
BREATHING OF VAPORS. DONOT GET NEAR ANY STRONG OXIDANTS.
Supplemental Safety and Health
WASH SKIN AFTER HANDLING & BEFORE EATING. DONOT EAT IN VICINITY OF USE.
WASH CONTAMINATED CLOTHING BEFORE REUSE.

HCC:T4
Boiling Pt:B.P. Text:165F/73.9C
Vapor Pres:125 @ 77F
Vapor Density:4.55
Spec Gravity:1.17
Evaporation Rate & Reference:(BUT ACETATE =1), 0.37
Solubility in Water:0.07 %
Appearance and Odor:CLEAR, COLORLESS LIQUIDW/ CHLOROFORM-

Stability Indicator/Materials to Avoid:YES
STRONG ALKALINES SUCH AS SODIUM HYDROXIDE. SHOULD NOT BE USED IN
CONTACT WITH ALUMINUM OR ZINC OR THEIR ALLOYS.
Stability Condition to Avoid:WELDING, OPEN FLAMES, & INFRA-RED HEATERS.
Hazardous Decomposition Products:HCL DURING THERMAL DECOMPOSITION.

Waste Disposal Methods:NORMALLY RECOVERED FROM RESIDUES BY
DISTILLATION. SMALL QUANTITIES MAY BE DISPOSED VIA AN
INCINERATION-SCRUBBER OR A LICENSED WASTE HAULER CHECK LOCAL
REGULATIONS. DO NOT CONTAMINATED WATER SUPPLIES.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.