Product ID:TT-E-508
MSDS Date:01/01/1987
FSC:8010
NIIN:00N010735
MSDS Number: BHCHY

Emergency Phone: 213-686-1246

Info Phone: 213-686-1246

Cage: 52100

Telephone: 800-272-4687/818-442-7269

Cage: 52100

MINERAL SPIRITS

CAS: 64742-88-7

Fraction By Weight: 30%

OSHA PEL OSHA PEL

ACGIH TLV: ACGIH TLV

LD50 LC50 Mixture:
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:SEE SIGNS & SYMPTOMS OF OVEREXPOSURE.
Explanation of Carcinogenicity:N/A FPN
Effects of Overexposure:ACUTE:HEADACHE,NAUSEA,DIZZINESS,LASSITUDE,LOSS
OF COORDINATION OR CONSCIOUSNESS.CHRONIC;NONE RECOGNIZED.
Medical Cond Aggravated by Exposure:N/K

First Aid:INHALATION:REMOVE TO FRESH AIR,GIVE ARTIFICIAL RESPIRATION IF
BREATHING HAS STOPPED,EYE;FLUSH EYES W/ COPIOUS AMOUNTS OF WATER
FOR AT LEAST 15 MINUTESSKIN:WASH SKIN WITH SOAP AND WATER CHANGE CL
OTHES AND SHOES.INGEST:DO NOT INDUCE VOMITING.ASPIRATION OF VOMITUS
MAY RESULT IN CHEMICAL PNEUMONITIS AND/OR PULMONARY EDEMA,CALL A
PHYSICIAN.

Flash Point Method:TCC
Flash Point:130 F.
Lower Limits:
Upper Limits:
Extinguishing Media:USE FOAM,DRY CHRMICAL OR CO#2.
Fire Fighting Procedures:SCBA RECOMMENDED.WATER MAY BE UNSUITABLE AS AN
EXTINGUISHING MEDIUM,BUT HELPFUL IN COOLING CONTR & SURFACES.NEVER
USE A DIRECT STREAM OF H*2O.USE H2O(SUP DATA)
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR & MAY
ACCUMULATE IN LOW AREAS OF POOR VENT.VAPORS CAN TRAVEL ALONG THE
GROUND TO REMOTE IGNITION SITES.CLOSED CONTRS CAN (SUP DATA)

Spill Release Procedures:REMOVE SOURCES OF IGNITION,INCLUDING HOT METAL
SURFACES,CLEAN UP SPILL IMMEDIATELY BY SOAKING UP W/ ABSORBENTS
SUCH AS CLAY,SAND,DIATOMACEOUS EARTH,ETC.
Neutralizing Agent:

Handling and Storage Precautions:KEEP COOL,DRY,AND AWAY FROM IGNITION
SOURCES.STORE IN WELL VENTILATED AREA.
Other Precautions:AVOID PERSONAL CONTACT (SKIN,EYES,ETC.). USE WITH
ADEQUARE VENT-DO NOT INHAL VAPORS.GROUND DRUMS WHEN POURING OR
OTHERWISE DISPENSING.DO NOT WELD,DRILL ,CUT OR HEAT FULL,PARTIAL,OR
EVEN EMPTY CONTAINE RS.

Respiratory Protection:IF TLV IS EXCEEDED USE A NIOSH APPROVED
RESPIRATOR OR A SCBA.USE MECHANICAL FILTER TO REMOVE SOLID AIRBORNE
PARTICLES DURING SPRAY APPLICATION.
Ventilation:GENERAL MECHANICAL VENT MAY BE SUFFICIENT TO,KEEP EXPOSURE
BELOW TLV.USE ONLY EXPLOSION PROOF VENT W/ FLAMMABLE MATERIAL
Protective Gloves:NEOPRENE GLOVES ARE SUGGESTED.
Eye Protection:CHEM WORK GOGGLES,FACESHLD OPTIONAL
Other Protective Equipment:APRONS,EYE WASHES,SAFETY SHOWERS.
Work Hygienic Practices:OBSERVE GOOD WORK HYGIENIC PRACTICES
Supplemental Safety and Health
WT PER GALLON 10.7SPECIAL FIRE FIGHTING PROCEDURES:FOG & AVOID SPREDING
BURNING LIQUID WHICH MAY FLOAT & BURN ON TOP OF H*20
SURFACE.UNUSUAL FIRE & EXPLOSION HAZARDS:BUILD UP PRESSURE WHEN
EXPOSED TO HEAT.

Boiling Pt:B.P. Text:318-390 F
Melt/Freeze Pt:M.P/F.P Text:N?K FPN
Decomp Temp:Decomp Text:
Vapor Pres:
Vapor Density:HEAV AIR
Spec Gravity:1.286
pH:
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:
Appearance and Odor:
Percent Volatiles by Volume:52
Corrosion Rate:

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS,STRONG ACIDS & BASES SELECTED AMINES.
Stability Condition to Avoid:
Hazardous Decomposition Products:CARBON MONOXIDE,CARBON
DIOXIDE,UNIDENTIFIED ORGANIC COMPOUNDS.
Conditions to Avoid Polymerization:HEAT,SPARKS,OPEN FLAME.

Waste Disposal Methods:PLACE IN NON-LEAKING CONTAINERS & DISPOSE OF IN
ACCORDANCE WITH APPLICABLE LOCAL,COUNTY,STATE AND FEDERAL
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.