Product ID:ALKYD GLOSS ENAMEL BLUE 15526
MSDS Date:10/04/1989
FSC:8010
NIIN:00-577-4130
MSDS Number: BHDNP

Emergency Phone: 404-509-4400

Info Phone: 404-622-1326

Cage: OO269

Telephone: 404 622 1326

Cage: OO269

MINERAL SPIRITS

CAS: 8032-32-4

Fraction By Weight: 30-35%

OSHA PEL 500 PPM

ACGIH TLV: 100 PPM

Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Health Hazards Acute and Chronic:ASPIRATION OF MATERIAL INTO LUNGS CAN
CAUSE CHEMICAL PNEUMONITIS,WHICH CAN BE FATAL.
Effects of Overexposure:EYES:SEVERE IRRIT.,REDNESS,TEARING,BLURRED
VISION.SKIN:PROLONGED/REPEAT CONTACT CAN CAUSE
MOD.IRRIT.,DEFATTING,DERMATITIS.INHALATION:NASAL/RESP.
IRRIT,DIZZINESS,WEAKNESS,FATIGUE,NAUSEA,HEADACHE,UNCONS
CIOUSNESS,ASPHYXIATION,INGESTION,GASTRO-INTESTINAL
IRRIT.,NAUSEA,VOMITING,DIARRHEA,ASPIRATION CAUSES FATAL
CHEM.PNEUMON.

First Aid:SKIN:THOROUGHLY WASH W/SOAP & WATER.IF IRRIT. PERSISTS,GET
MEDICAL ATTN. EYES:FLUSH W/LGE AMTS OF WATER,LIFTING
UPPER/LOWER LIDS OCCAS.,GET MED. ATTN. INGESTION:DO NOT INDUCE
VOMITING.KEEP PE RSON WARM,QUIET,GET MEDICAL ATTN.INHALATION:REMOVE
TO FRESH AIR OR ADMINISTER OXYGEN. IF BREATHING STOPPED,ARTIFICIAL
RESPIRATION.KEEP PERSON WARM,QUIET,GET MEDICAL ATTN.

Flash Point Method:TCC
Flash Point:105F/40.56C
Upper Limits:1.0
Extinguishing Media:FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:WEAR S.C.B.A. WITH A FULL FACEPIECE OPERATED
IN PRESSURE DEMAND OR OTHER POSITIVE PRESSURE MODE WHEN
FIGHTING FIRES. WATER SPRAY MAY BE INEFFECTIVE.
Unusual Fire/Explosion Hazard:CONTAINERS MAY EXPLODE WHEN EXPOSED TO
EXTREME HEAT. VAPORS ARE HEAVIER THAN AIR& MAY TRAVEL ALONG THE
GROUND & IGNITE BY FLAMES,SPARKS,SMOKING & OTHER SOURCES.

Spill Release Procedures:ELIMINATE ALL SOURCES OF IGNITION.SMALL
SPILLS: ABSORB LIQ ON PAPER/OTHER ABSORBENT MATERL,TRF TO
HOOD.LARGE SPILLS:WEAR PROT.EQUIP.STOP @ SOURCE,DIKE,PUMP LIQ TO
SALVAGE TANK,REMAINING TO CONTAINRS PREVENT RUN-OFF:IF IT
OCCURS,NOTIFY PROPER AUTHOR.

Handling and Storage Precautions:AVOID STORING IN HIGH TEMP/NEAR OPEN
FLAME. STORE DRUM OUT OF SUN AND AWAY FROM HEAT.
Other Precautions:DO NOT STORE OR USE NEAR HEAT,SPARK,OR FLAME,KEEP
CLOSURE TIGHT/CONTNR UPRIGHT TO PREVENT LEAKAGE.DONT
WELD/FLAME-CUT EMPTY DRUM.THEY SHOULD BE GROUNDED/BONDEDWHEN
POURING.DO NOT BREATHE THE SANDING DUST.EMPTY CONTAINERS ARE
HAZARDOUS.

Respiratory Protection:A NIOSH/MSHA JOINTLY APPROVED AIR SUPPLIED
RESPIRATOR IS ADVISED.OSHA REGULATIONS ALSO PERMIT OTHER NIOSH/MSHA
RESPIRATORS UNDER SPECIFIED CONDITIONS.
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL AND/OR LOCAL EXHAUST
VENTILATION)TO MAINTAIN EXPOSURE BELOW TLV(S).
Protective Gloves:NITRILE RUBBER OR NEOPRENE.
Eye Protection:CHEM SPLASH GOGGLES,OTH SAFETY GLASSES
Other Protective Equipment:IMPERVIOUS CLOTHING AND BOOTS
Work Hygienic Practices:SKIN:AVOID REPEAT/PROLONG CONTACT.WASH HANDS
BEFORE EATING/ USING WASHROOM.SMOKE IN SMOKING AREAS ONLY.
Supplemental Safety and Health
NK

Boiling Pt:B.P. Text:300F
Vapor Density:>AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:49.0

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:AVOID HIGH TEMPERATURES,OPEN FLAME,AND
SPARKS.
Hazardous Decomposition Products:MAY FORM TOXIC MATERIALS SUCH AS
CARBON DIOXIDE,CARBON MONOXIDE,AND VARIOUS HYDROCARBONS.
Conditions to Avoid Polymerization:AVOID HIGH TEMPERATURES,OPEN FLAME
AND SPARKS

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL,STATE AND
FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.