Product ID:ENAMEL ALKYD SG GREEN 24410 ID 745442
MSDS Date:06/05/1989
FSC:8010
NIIN:00-530-5566
MSDS Number: BJDJW

PRATT AND LAMBERT INC

16116 E 13TH ST
WICHITA, KS 67201
US

Emergency Phone: 716-873-6000 DOT EMER 8002553924

Info Phone: 316-733-1361

Preparer: W.A. ELLISON

Cage: 61196

PRATT AND LAMBERT INC

6027 CLEVELAND, OH 44101-1027 US

Telephone: 216-566-2902

Cage: 61196

MINERAL SPIRITS (VAPOR PRESSURE 2 MM HG @ 20 C)

CAS: 64475-85-0

RTECS: PY8240000

Fraction By Weight: 35%

OSHA PEL 500 PPM 2950 MG/CU.M

ACGIH TLV: 100 PPM 525 MG/CU.M

SILICA, CRYSTALLINE - CRISTOBALITE

CAS: 14464-46-1

RTECS: VV7325000

Fraction By Weight: 5%

OSHA PEL SEE TABLE Z3

ACGIH TLV: 0.05 MG/M3 RDUST9293

TITANIUM DIOXIDE

CAS: 13463-67-7

RTECS: XR2275000

Fraction By Weight: 15 - 20%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST; 9293

SILICA, CRYSTALLINE - QUARTZ

CAS: 14808-60-7

RTECS: VV7330000

Fraction By Weight: 1 - 10%

OSHA PEL SEE TABLE Z3

ACGIH TLV: 0.1 MG/M3 RDUST;9293

TALC (CONTAINING NO ASBESTOS)

CAS: 14807-96-6

RTECS: WW2710000

Fraction By Weight: 15%

OSHA PEL 2 MG/M3 RDUST

ACGIH TLV: 2 MG/M3 RDUST; 9192

SILICA, CRYSTALLINE - QUARTZ

CAS: 14808-60-7

RTECS: VV7330000

Fraction By Weight: 1 - 10%

OSHA PEL SEE TABLE Z3

ACGIH TLV: 0.1 MG/M3 RDUST;9293

LEAD CHROMATE

CAS: 7758-97-6

RTECS: GB2975000

Fraction By Weight: 5%

OSHA PEL .0500 MG/CU.M.

ACGIH TLV: .0500 MG/CU.M.

VOC. ORGANIC CMPD 3.71 LB/GAL LESS WATER & NPRS* 455 G/L

RTECS: 9999999VO

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:SWALLOWING:GASTROINTESTINAL
IRRIT/NAUSEA/VOMIT/DIARRHEA. ASPIRATION OF MAT'L MAYCAUSE CHEM
PNEUMONITIS. INHALATION: NOSE/THROAT IRRIT. HIGH CONCENTRATION MAY
CAUSE CENTRAL NERVOUS SYSTEM DEPRESSION CHAR BY
HEADACHES/DIZZINESS/NAUSEA/CONFUSION. EYE: MAY CAUSE EYE IRRIT.
SKIN: MAY CAUSE DEFATTING AND IRRITATION.
Explanation of Carcinogenicity:NTP/IARC-CHROMIUM AND CERTAIN CHROMIUM
COMPOUNDS. IARC-LEAD CHROMATE LISTED AS A POTENTIAL
CARCINOGEN.
Effects of Overexposure:REPEATED EXPOSURE TO CRYSTALLINE SILICA MAY
CAUSE PNEUMOCONIOSIS. OCCUPATIONAL OVEREXPOSURE TO SOLVENTS ASSOC
W/PERM BRAIN/NERVOUS SYSTEM DAMAGE. INSOLUBLE CHROMATES MAY
CAUSE LUNG CANCER. LEAD-BL OOD DAMAGE &
NERVOUS/URINARY/REPRODUC-TIVE SYSTEMS. OVEREXPOSURE TO XYLENE MAY
CAUSE INJURY TO LIVER/KIDNEYS/BLOOD.

First Aid:INHALATION: REMOVE TO FRESH AIR. IF BREATHING HAS STOPPED
GIVE CPR/GET MED ATTN.EYE: FLUSH W/WATER FOR 15 MIN LIFTING
UPPER/LOWER LIDS. GET MED ATTN. SKIN: WASHAFFECTED AREA WITH SOAP
AND WATER. GET M EDICAL ATTENTION IF IRRITATION
PERSISTS.SWALLOWING: CAN CAUSE GASTROINTESTINAL IRRITATION, NAUSEA,
AND VOMITING. ASPIRATION OF MATERIAL INTO LUNG MAY CAUSE CHEMICAL
PNEUMONITIS WHICH CAN BE FATAL.

Flash Point:>102F
Extinguishing Media:USE NFPA CLASS B FIRE EXTINGUISHERS. POLYMER FOAM
IS PREFERRED FOR LARGE FIRES.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS. USE
WATER TO COOL CONTAINERS TO PREVENTPOSSIBLE
AUTO-IGNITION/EXPLOSION. IF WATER IS USED FOG NOZZLES ARE
PREFERRED.
Unusual Fire/Explosion Hazard:ISOLATE FROM HEAT/ELEC
EQUIP/SPARKS/FLAME.CONTAINER MAY EXPLODE WHEN EXPOSED TO HEAT.
OVEREXPOSURE TO DECOMP PRODUCTS MAY CAUSE HEALTH HAZ. OBTAIN MED
ATTN.

Spill Release Procedures:ELIM ALL IGNITION SOURCES. DIKE/CONTAIN SPILL
WITHINERT MAT'L. TRANSFER LIQ'S/ABSORBENT DIKING MAT'LIN COVERED
METAL CONT'S FOR RECOVERY/DISPOSAL. USEONLY NON-SPARKING TOOLS.
PREVENT CONTAM OF SEWERS/ STREAMS/GROUNDWATER W/SPILLED MAT'L/USED
ABSORBENT

Handling and Storage Precautions:DO NOT STORE ABOVE 120 DEGREES F.
STORE LARGE QUANTITIES IN COMPLIANCE WITH OSHA 29CFR1910.106.
Other Precautions:DO NOT TAKE INTERNALLY. CLOSE CONTAINER AFTER EACH
USE. DO NOT BREATHE SANDING DUST. EMPTY CONTAINERS MUST NOT BE
WASHED AND RE-USED FOR ANY PURPOSE. CONTAINERS SHOULD BE
GROUNDED AND BONDED TO THE RECEIVING CONTAINER.

Respiratory Protection:WELL VENTILATED AREA-USE NIOSH MECHANICAL FILTER
RESPIRATOR. RESTRICTED VENTIL- LATION USE A NIOSH (COMBINATION CHEM
CARTRIDGE/MECHAN FILTER) RESP. IN CONFINED AREAS USE NIOSH APPROVED
AIR-SUPPLIED RE SPIRATOR.
Ventilation:PROVIDE GENERAL DILUTION/LOCAL EXHAUST, VENTILATION TO KEEP
CONCENTRATIONS OF HAZARD INGREDIENTS BELOW EXPOSURE TLV.
Protective Gloves:SOLVENT IMPERMEABLE GLOVES.
Eye Protection:SAFETY SPEC W/SIDE SHIELDS. FACE SHIELD.
Other Protective Equipment:AS REQUIRED TO PREVENT SKIN CONTACT. SEE
OSHA STANDARD FOR LEAD.
Work Hygienic Practices:WASH WITH SOAP AND WATER HANDS/FACE THOROUGHLY
BEFORE EATING OR DRINKING.
Supplemental Safety and Health
SEE VENT. REQUIREMENT FOR LEAD: 29CFR1910.1025. DO NOT WELD, BRAZE OR
CUT ON EMPTY CONTAINER. NEVER USE PRESSURE TO EMPTY
CONTAINERS. DRUM IS NOT A PRESSURE VESSEL.

HCC:F4
Boiling Pt:B.P. Text:280F/388F
Vapor Density:>AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:56

Stability Indicator/Materials to Avoid:YES
STRONG ACIDS OR ALKALINE MATERIALS.
Stability Condition to Avoid:NONE KNOWN
Hazardous Decomposition Products:BURNING, INCLUDING WHEN HEATED BY
WELDING/CUTTING, WILL PRO-DUCE SMOKE/CARBON MONOXIDE/CARBON
DIOXIDE/OXIDES OF LEAD.
Conditions to Avoid Polymerization:KEEP AWAY FROM HEAT SPARKS AND
FLAME.

Waste Disposal Methods:INCINERATE ONLY IN EPA PERMITTED FACILITY.
DISPOSEONLY IAW FED/STATE/LOCAL REGS. DO NOT INCINERATE CLOSED
CONTAINERS. OBSERVE PRECAUTIONS FOR DIS- POSAL OF FLAMMABLE
MAT'S. CONTAMINATED ABSORBENT MAY BE DISPOSED IN A HAZARDOUS
WASTE LANDFILL.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.