Product ID:ROYCO 22D, 22C
MSDS Date:02/23/1989
FSC:9150
NIIN:01-262-3358
MSDS Number: BJDPZ

ROYAL LUBRICANTS COMPANY INC.

72 EAGLE ROCK AVE
EAST HANOVER, NJ 07936
US

Emergency Phone: 201-887-7411

Info Phone: 201-887-3100

Cage: 07950

ROYAL LUBRICANTS COMPANY INC.

518 EAST HANOVER, NJ 07936 US

Telephone: 973-887-7411/7410

Cage: 07950

POLYALPHAOLEFINS

CAS: 68037-01-4

Fraction By Weight: 70-80%

ORGANOPHILIC CLAY

CAS: 71011-25-1

Fraction By Weight: 5-10%

SODIUM NITRITE (SARA III)

CAS: 7632-00-0

RTECS: RA1225000

Fraction By Weight: <2.0%

EPA Report Quantity: 100 LBS

DOT Report Quantity: 100 LBS

SODIUM CHROMATE (SARA III)

CAS: 7775-11-3

RTECS: GB2955000

Fraction By Weight: <1.0%

OSHA PEL 0.1 PPM CRO3;CEILING

ACGIH TLV: 0.05 MG CR/M3; 9192

EPA Report Quantity: 10 LBS

DOT Report Quantity: 10 LBS

MIXED SYNTHETIC ESTERS

CAS: 103-24-2

Fraction By Weight: 1-2%

OTHER COMPONENTS (TYPE NOT SPECIFIED)

Fraction By Weight: 4.0%

Routes of Entry: Inhalation:NO Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE:MAY BE MILDLY IRRITATING.
SKIN:RELEASE DURING HIGH PRESSURE USAGE MAY RESULT IN INJECTION OF
OIL INTO THE SKIN CAUSING LOCAL NECROSIS. INHALATION:NOT EXPECTED
TO BE A RELEVANT ROUTE OF EXPO SURE; HIGH TEMPERATURE VAPORS
IRRITATE RESPIRATORY TRACT. INGESTION:LOW LEVEL OF TOXICITY.
CHRONIC: SKIN DISORDERS.
Explanation of Carcinogenicity:NONE OF THE COMPOUNDS IN THIS PRODUCT IS
LISTED BY IARC, NTP, OR OSHA AS A CARCINOGEN.
Effects of Overexposure:MAY CAUSE EYE, SKIN & RESPIRATORY TRACT
IRRITATION. LOCAL NECROSIS IS EVIDENCED BY DELAYED ONSET OF PAIN
AND TISSUE DAMAGE A FEW HOURS FOLLOWING INJECTION.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN DISORDERS MAY BE
AGGRAVATED BY EXPOSURE TO THIS PRODUCT.

First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE OXYGEN IF BREATHING IS
DIFFICULT. GET MEDICAL ATTENTION. EYE: FLUSH WITH WATER FOR 15
MINUTES WHILE HOLDING EYELIDS OPEN. GET MEDICAL ATTENTION. SKIN:
WASH WITH S OAP & WATER/WATERLESS CLEANER. REMOVE CONTAMINATED
CLOTHING. IF IRRITATION PERSISTS, GET MEDICAL ATTENTION. INGESTION:
DO NOT INDUCE VOMITING. IN GENERAL, NO TREATMENT IS REQUIRED. GET
MEDICAL ADVICE.

Flash Point Method:PMCC
Flash Point:450F,232C
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:FIRE OR EXCESSIVE HEAT MAY CAUSE
PRODUCTION OF HAZARDOUS DECOMPOSITION PRODUCTS.

Spill Release Procedures:SCOOP UP EXCESS GREASE. CLEAN AREA WITH
APPROPRIATE CLEANER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE IN A COOL, DRY PLACE WITH
ADEQUATE VENTILATION. KEEP CONTAINERS TIGHTLY CLOSED WHEN NOT IN
USE. KEEP AWAY FROM OPEN FLAMES & HIGH TEMPERATURES.
Other Precautions:MINIMIZE SKIN CONTACT. WASH WITH SOAP & WATER BEFORE
EATING, DRINKING, SMOKING OR USING TOILET FACILITIES. LAUNDER
CONTAMINATED CLOTHING BEFORE REUSE. PROPERLY DISPOSE OF
CONTAMINATED LEATHER ARTICLES (SHOES) THAT CAN NOT BE
DECONTAMINATED.

Respiratory Protection:IF VENTILATION DOES NOT MAINTAIN INHALATION
EXPOSURES BELOW PEL(TLV), USE NIOSH/MSHA APPROVED RESPIRATORS AS
PER CURRENT 29 CFR 1910.134, INSTRUCTIONS/WARNINGS. RESPIRATORY
PROTECTION NOT ORDINARILY R EQUIRED.
Ventilation:NONE REQUIRED
Protective Gloves:NEOPRENE RUBBER AS REQUIRED.
Eye Protection:SAFETY GLASSES RECOMMENDED.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
DO NOT GET IN EYES OR ON CLOTHING.

HCC:V6
Solubility in Water:INSOLUBLE
Appearance and Odor:BROWN,SMOOTH,SLIGHT ODOR

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, AND OPEN FLAMES
Hazardous Decomposition Products:A MIXTURE OF AIRBORNE SOLID, LIQUID
PARTICULATES AND GASES (CO) WILL EVOLVE WHEN THIS MATERIAL
UNDERGOES COMBUSTION.

Waste Disposal Methods:DISPOSE OF IN AN APPROPRIATE DISPOSAL FACILITY
IN COMPLIANCE WITH LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.