Product ID:6665 PART B
MSDS Date:10/12/1987
FSC:8040
NIIN:00N017570
Kit Part:Y
MSDS Number: BLCMG

EPOXYLITE CORPORATION

9400 TOLEDO WAY
IRVINE, CA 92713-9671
US

Emergency Phone: 800-424-9300 (CHEMTREC)

Info Phone: 714-951-3231

Preparer: RICHARD KUDER

Cage: GO286

THE EPOXYLITE CORPORATION

19671 IRVINE, CA 92713-9671 US

Telephone: 714-951-3231

Cage: 11147

4,5 DIANHYDRIDE;

CAS: 89-32-7

RTECS: DB9300000

Fraction By Weight: 45-50%

ACGIH TLV: 3 MG/M3 RDUST (MFR)

SILICA, CRYSTALLINE - QUARTZ

CAS: 14808-60-7

RTECS: VV7330000

Fraction By Weight: 20-25%

OSHA PEL SEE TABLE Z3

ACGIH TLV: 0.1 MG/M3 RDUST;9293

ORAL TOX OF THE CMPD

RTECS: 9999999ZZ

EFTS SHOW IN ANIMAL STUDIES. BECAUSE OF ITS IRRITANT

RTECS: 9999999ZZ

THE MATL W/THE SKIN/EYES & SHOULD AVOID INHALING

RTECS: 9999999ZZ

TIGHTLY CLSD WHEN NOT IN USE. DO NOT GET ON

RTECS: 9999999ZZ

LEATHER GOODS. THIS CONTR HAZ WHEN EMPTY. SINCE EMPTY

RTECS: 9999999ZZ

LBLD HAZ PREC MUST BE OBSERVED. DO NOT REUSE "EMPTY

RTECS: 9999999ZZ

CONSUMPTION OR SKIN CONT W/OUT PROFESSIONAL CLEANING.

RTECS: 9999999ZZ

LD50 LC50 Mixture:(SEE INGREDIENTS)
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYE:MAY LEAD TO IRRIT, W/TEARING.
SKIN:MINOR IRRIT MAY RSLT W/SKIN MOISTURE. ALLERGIC SENSITIVITY MAY
OCCUR FOR SOME INDIVIDUALS. INGEST:IRRIT & POSS CORR ACTION ON THE
MOUTH & STOM TISS. VOM MAY OCCU R. INHAL:MAY CAUSE BREATHLESSNESS,
SEV COUGHING, CHEST DISCOMFORT, IRRIT OF MUC MEMB & REDUCED PULM
(SEE EFTS OF OVEREXP
Explanation of Carcinogenicity:CRYSTALLINE SILICA: GROUP 2A (IARC)
Effects of Overexposure:HLTH HAZ:FUNCTION (RXN MAY BE DELAYED 4-8
HOURS). SOME INDIVIDUAL MAY DEVELOP SENSITIVITY LEADING TO SOME
ASTHMA-LIKE SYMPS OF SUBSEQUENT EXPOS BELOW THE TLV.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:EYE:FLUSH W/RUNNING WATER FOR AT LEAST 15 MINS. CALL MD
IMMED. SKIN:WASH W/SOAP & WATER. ALCOHOL MAY BE HELPFUL. CALL MD IF
SWELLING/REDDENING OCCURS. INGEST:DRINK WARM WATER & INDUCE VOM BY
TOUCHING BACK OF THROAT W/FINGER &/OR ADMINISTERING SYRUP OF
IPECAC. FOLLOW W/MILK & A MILD CATHARTIC (MILK OF MAGNESIA). CALL
MD OR POIS CTL CTR IMMED. INHAL:MOVE PERS OUT OF EXPOS AREA IMMED.
(SEE SUPP DATA)

Flash Point Method:PMCC
Flash Point:546F,286C
Extinguishing Media:WATER FOG, FOAM, ALCOHOL FOAM, CARBON DIOXIDE OR
DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . WATER SHOULD BE USED TO KEEP FIRE-EXPOSED
CONTAINERS COOL.
Unusual Fire/Explosion Hazard:AVOID WATER CONTAMINATION IN CLOSED
CONTAINER OR CONFINED AREA (CO*2 EVOLVED EXOTHERMIC).

Spill Release Procedures:ONLY PROPERLY PROTECTED PERSONNEL SHOULD
REMAIN IN THE IMMEDIATE AREA. CONTAIN SPILL, COVER LIQUID
W/ABSORBENT MATERIAL (SAW DUST, OIL ABSORBENT, ETC).
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE IN A COOL/DRY PLACE. KEEP AWAY
FROM HEAT/SPARKS/OPEN FLAME. FOR INDUS USE ONLY. USE ONLY W/ADEQ
VENT. DO NOT HNDL UNTIL MSDS IS READ/UNDERSTOOD.
Other Precautions:MATL SLOWLY ABSORBS MOISTURE IF EXPOSED TO THE ATM
FOR APPRECIABLE LENGTHS OF TIME. PARTICULARLY UNDER CNDTNS OF HIGH
TEMPS & HIGH RELATIVE HUMIDITY. IT IS STRONGLY RECOM THAT PREC BE
TAKEN TO KEEP ST OR CONTRS SEALED OR (SEE INGRED 6)

Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR RECOMMENDED
W/APPROPRIATE ACID/GAS FILER.
Ventilation:GOOD ROOM VENTILATION USUALLY ADEQUATE FOR MOST OPERATION.
Protective Gloves:IMPERVIOUS GLOVES.
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:CLEAN, BODY-COVERS & CLOTHING TO MINIMIZE
SKIN CONTACT.
Work Hygienic Practices:IN CASE OF CONT, WASH IMMED W/SOAP & WATER.
REMOVE CONTAMD CLTHG & WASH BEFORE REUSE.
Supplemental Safety and Health
SOL IN H*2O:PARTIAL HYDROLYSIS PROD 1%. FIRST AID PROC:IF BRTHG IS
LABORED OR DFCLT, O*2 SHOULD BE ADMINISTERED BY TRAINED PERS. CALL
MD IMMED. NOTE TO MD:TREAT SYMPTOMATICALLY. BRONCHODILATORS:O*2. R
ESP RESPONSE MAY BE DELAYED 4-8 HOURS AFTER EXPOS. NEVER GIVE
FLUIDS OR INDUCE VOM IF PATIENT IS UNCON (SEE INGRED 3)

Boiling Pt:B.P. Text:>752F,>400C
Spec Gravity:2
Solubility in Water:(SEE SUPP DATA)
Appearance and Odor:WHITE TO TAN COLORED POWDER; ODORLESS
Percent Volatiles by Volume:NIL

Stability Indicator/Materials to Avoid:YES
WATER, STRONG ALKALIES, ALCOHOLS, METAL COMPOUNDS OR SURFACE ACTIVE
AGENTS.
Stability Condition to Avoid:AVOID PROLONGED HEATING OVER 160 F OR
STORAGE BELOW 80 F.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
OXIDES OF NITROGEN & TRACES OF HYDROGEN CYANIDE.

Waste Disposal Methods:DISPOSE OF MATERIAL ACCORDING TO ALL FEDERAL,
STATE & LOCAL LAWS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.