Product ID:RP605Z, MT TONER POSITIVE-POSITIVE
MSDS Date:01/31/1990
FSC:6850
NIIN:00N028646
MSDS Number: BNBHM

MINOLTA CORP

101 WILLIAMS DR
RAMSEY, NJ 07446
US

Emergency Phone: 201-825-4000

Info Phone: 201-825-4000

Cage: GO339

MINOLTA CORPORATION

RAMSEY, NJ 07446 US

Telephone: 201-825-4000

Cage: 23736

STYRENE ACRYLATE COPOLYMER

Fraction By Weight: >80%

COPPER OXIDE

CAS: 1317-38-0

RTECS: GL7900000

Fraction By Weight: 5-10%

ORGANIC PIGMENT

Fraction By Weight: 1-5%

CARBON BLACK

CAS: 1333-86-4

RTECS: FF5800000

Fraction By Weight: 1-5%

OSHA PEL 3.5 MG/M3

ACGIH TLV: 3.5 MG/M3

PROPENE POLYMERS; (POLYPROPYLENE)

CAS: 9003-07-4

RTECS: UD1842000

Fraction By Weight: 1-3%

LD50 LC50 Mixture:LD50: (ORAL,RAT) > 5G/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:TONER PRESENTS A LOW HAZ FOR USUAL
OCCUP SETTING. BASED ON AVAIL DATA, HUMAN EXPOS TO TONER HAS BEEN
SHOWN TO CAUSE MINIMAL RESP TRACT IRRIT AS MAY OCCUR W/LRG AMTS OF
ANY NON-TOXIC DUSTS. MAY CAUSE C OUGH & RAISE PHLEGM. THE RSLT OF
ONE ANIMAL STUDY WHERE RATS INHALED TONER THAT WAS TEN TIMES MORE
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: RESPIRABLE THAN COMMERCIALLY
AVAILABLE TONER WERE OBSERVED TO HAVE NO LUNG CHANGES AT LOW
EXPOSURE (THE MOST RELEVANT LEVEL TO POTENTIAL HUMAN EXPOSURES). AT
HIGHER LEVELS A SLIGHT DEGREE OF LUNG FIBROSIS WAS OBSERVED DUE TO
EXCESSIVE AMOUNTS OF DUST RETAINED IN THE LUNGS FOR A PROLONGED
INTERVAL.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INHAL: WASH NOSTRILS, RINSE MOUTH. INGEST: DILUTE STOMACH
CONTENTS WITH SEVERAL GLASSES OF WATER. EYES: FLUSH WITH WATER FOR
AT LEAST 15 MIN. SKIN: WASH WITH SOAP AND WATER.

Extinguishing Media:WATER, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:AVOID INHALATION OF SMOKE. WEAR NIOSH/MSHA
APPROVED SCBA AND FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:TONER IS A COMBUSITBE POWDER. WHEN
DISPERSED IN AIR, IT FORMS EXPLOSIVE MIXTURES.

Spill Release Procedures:IF SPILLED, SWEEP UP OR VACUUM.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.

Respiratory Protection:NONE REQUIRED WHEN USED AS INTENDED IN MINOLTA
EQUIPMENT. NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE
OF CONCERN .
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.

HCC:N1
Spec Gravity:1.2
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK POWDER, FAINT ODOR.

Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:PRODUCTS OF COMBUSTION ARE TOXIC.
AVOID BREATHING OF SMOKE.

Waste Disposal Methods:DO NOT INCINERATE. NO SPECIAL TECHNIQUES BEYOND
NORMAL PRACTICE. ENSURE CONFORMITY WITH FEDERAL, STATE AND LOCAL
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.