Product ID:127A100, 5-STAR P.V.A. LATEX BLOCK FILLER
MSDS Date:10/01/1986
FSC:8010
NIIN:00N028985
MSDS Number: BNBPB

Emergency Phone: 312-720-0600

Info Phone: 312-720-0600

Cage: ACEHA

Telephone: 708-720-0600

Cage: ACEHA

NON HAZARDOUS INGREDIENT

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: IN A CONFINED AREA VAPORS IN
HIGH CONCENTRATION ARE ANESTHETIC. IRRITANT TO SKIN AND UPPER
RESPIRATORY SYSTEM. OVEREXPOSURE MAY RESULT IN LIGHTHEADEDNESS AND
STAGGERING GAIT.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:CHRONIC PROBLEMS WITH RESPIRATORY
SYSTEM MAY BE AGGRAVATED BY EXPOSURE TO VAPORS.

First Aid:INHAL: RESTORE BREATHING, KEEP WARM AND QUIET. SKIN: WASH
AFFECTED AREAS THOROUGHLY WITH SOAP AND WATER. REMOVE CONTAMINATED
CLOTHING AND LAUNDER BEFORE RE-USE. EYES: FLUSH WITH WATER FOR AT
LEAST 15 MIN. GET MEDICAL ATTENTION. INGEST: GETMD IMMEDIATELY .

Flash Point Method:PMCC
Flash Point:199F,93C
Extinguishing Media:"ALCOHOL" FOAM, CO2, DRY CHEMICAL.
Fire Fighting Procedures:NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP. H2O
SPRAY MAY NOT BE EFTIVE. H2O MAY BE USED TO COOL CLSD CNTNRS TO
PVNT PRESS BUILD UP & POSS (SUPP DATA)
Unusual Fire/Explosion Hazard:EXTREME HEAT MAY CAUSE CLOSED CONTAINER
TO BURST.

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:DOL STORAGE CATEGORY - 3B.
Other Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE. TRANSFER ONLY
TO APPROVED CONTAINERS WITH COMPLETE AND APPROPRIATE LABELING. DO
NOT TAKE INTERNALLY. KEEP OUT OF REACH OF CHILDREN.

Respiratory Protection:IF PERSONAL EXPOSURE CANNOT BE CONTROLLED BELOW
APPLICABLE LIMITS BY VENTILATION, WEAR NIOSH/MSHA APPROVED
RESPIRATORY DEVICE.
Ventilation:LOC EXHST PREFERABLE, GENL EXHST ACCEPT BELOW TLV OF INGRED
SECTION. REFER OSHA STDS. 1910.94, 1910.107, 1910.108.
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:USE ONLY W/ADEQ VENT. AVOD BREATHING VAPOR AND
SPRAY MIST. AVOID CONTACT WITH SKIN AND EYES. WASH HANDS AFTER
USING.
Supplemental Safety and Health
FIRE FIGHT PROC: AUTO IGNITION WHEN EXPOSED TO EXTREME HEAT.

HCC:V4
Boiling Pt:B.P. Text:212F,100C
Vapor Density:HVR/AIR
pH:8.5-9
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:45.40

Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:EXTREME HEAT AND OPEN FLAME
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE AND CARBON
MONOXIDE.

Waste Disposal Methods:INCINERATE IN APPROVED FACILITY. DO NOT
INCINERATE CLOSED CONTAINERS. DISPOSE OF IN ACCORDANCE WITH
FEDERAL, STATE, AND LOCAL REGULATIONS REGARDING POLLUTION.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.